IllustrationThe parking brake will fail without warning. The only way that it will work is with continuous adjustment. It has been repaired by a mechanic only to fail again. This has been a recurring problem since I purchased the vehicle in 2011.
2001 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
3825–50K
7150–75K
8075–100K
102100–150K
65150K+
385 reports with mileage · 83 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 147 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
48 crash reports5 fire reports20 injury reports
What owners actually said
468 reportsMy tires have very little wear because I drive far less now. On I-75 in FL recently, while coming off the ramp and increasing speed, the steering wheel began to wobble back and forth violently. As the road surface was wet, I lost control briefly. Once home, I began investigating the problem. I went back to Pep Boys and they insp…
Read full complaint
My tires have very little wear because I drive far less now. On I-75 in FL recently, while coming off the ramp and increasing speed, the steering wheel began to wobble back and forth violently. As the road surface was wet, I lost control briefly. Once home, I began investigating the problem. I went back to Pep Boys and they inspected and said the tire was separated and they would give me a credit, but they've discontinued that model tire and I'd have to buy 2 new tires. I could not afford that. So they placed it on the rear and I left mad. A month later the steering wobble returned. I then went elsewhere to have it investigated and they said two more were separated. It turns out 3 of the 4 tires I bought are separated so much they are unsuitable for use on the front and make noticeable vibration in the rear when placed there. Date codes on all of my tires are within two sets of weeks of each other, 1717 and 2717 and all are from the same factory. I placed the best two of the 4 on the back and have to replace them all now as there's no way to use any on the front as it's dangerous. They've discontinued this line, but it needs a recall. Pep Boys is coping out of their responsibility. It is Pep Boys Futura Scrambler A/P, 265/75R16. The DOT code is U973PAM1717 and 2717.
VEHICLE PARKED AT PRIVATE RESIDENCE. TAILGATE DOES NOT OPEN. SAFETY HAZARD SINCE THERE IS NO ACCESS TO REPLACE BAD BRAKE LIGHTS.
THE REAR BRAKE LINE ON MY 2001 CHEVT 1500 SILVERADO RUSTED INTO. IS WAS NOT A SALT CORRISON. MANY TRUCKS HAVE THIS ISSUE. I WORK IN A PARTS STORE AND A MAN CAME IN LAST WEEK WITH THE SAME PROBLEM. IT IS KNOW THESE CHECY TRUCKS IN THIS YEAR DO THIS. I HOPE U CAN TAKE THIS SERIOUS AND HAVE GM TO CORRECT IT BEFORE SOMEONE GETS KILL…
Read full complaint
THE REAR BRAKE LINE ON MY 2001 CHEVT 1500 SILVERADO RUSTED INTO. IS WAS NOT A SALT CORRISON. MANY TRUCKS HAVE THIS ISSUE. I WORK IN A PARTS STORE AND A MAN CAME IN LAST WEEK WITH THE SAME PROBLEM. IT IS KNOW THESE CHECY TRUCKS IN THIS YEAR DO THIS. I HOPE U CAN TAKE THIS SERIOUS AND HAVE GM TO CORRECT IT BEFORE SOMEONE GETS KILLED IF THEY HAVEN'T ALREADY. I RAN OFF THE ROAD DUE TO IT BREAKING AND SLIDE UPON A FENCE. WHEN I PUSHED ON THE BRAKE . I HAD NOTHING NO BRAKES AT ALL. PLEASE HELP. THANK YOU
CRACKED DASHBOARD
BRAKE SYSTEM FAILURE: SEPTEMBER 16, 2018 REAR BRAKE LINE SNAPPED WHILE DRIVING CAUSING IMMEDIATE LOSS OF BRAKE FLUID AND LOSS OF BRAKING. OWNER WAS DRIVING 20 MPH ON DIRT ROAD AND WAS ABLE TO STOP VEHICLE USING 4WHEEL DRIVE LOW. BRAKE LINE WAS REPLACED 9/18/2018 AND THE MECHANIC NOTED HE'D NEVER SEEN ANYTHING SNAP LIKE THAT BEFO…
Read full complaint
BRAKE SYSTEM FAILURE: SEPTEMBER 16, 2018 REAR BRAKE LINE SNAPPED WHILE DRIVING CAUSING IMMEDIATE LOSS OF BRAKE FLUID AND LOSS OF BRAKING. OWNER WAS DRIVING 20 MPH ON DIRT ROAD AND WAS ABLE TO STOP VEHICLE USING 4WHEEL DRIVE LOW. BRAKE LINE WAS REPLACED 9/18/2018 AND THE MECHANIC NOTED HE'D NEVER SEEN ANYTHING SNAP LIKE THAT BEFORE WITHOUT EVIDENCE OF DIRECT DAMAGE. ON INSPECTION BRAKE FLUID WAS CORRODED DESPITE HAVING BEEN RECENTLY CHANGED OUT. BRAKE SYSTEM SECOND FAILURE: ON APRIL 16, 2019 VEHICLE FAILED TO COME TO A STOP WHILE OWNER WAS BRAKING FOR A STOP SIGN. VEHICLE SLOWED BUT DIDN'T STOP DESPITE BRAKES APPLIED. OWNER WAS TICKETED FOR FAILURE TO STOP. OWNER ON TURNING VEHICLE ON AFTER TRAFFIC STOP SAW ABS LIGHT NOW ON (WASN'T ON PRIOR TO THIS) AND ON BRAKING TO TURN VEHICLE THEN FAILED TO BRAKE COMPLETELY AT WHICH POINT BOTH ABS DASH LIGHT AND RED BRAKE WARNING LIGHTS CAME ON. OWNER AGAIN STOPPED VEHICLE USING 4 WHEEL DRIVE LOW. OWNER IMMEDIATELY INSPECTED VEHICLE'S BRAKE FLUID LEVELS AND FOUND FLUID WAS AGAIN LOW DESPITE HAVING JUST BEEN SERVICED ON APRIL 10, 2019 WITH ENGINE REPLACEMENT AND BRAKE INSPECTION. OWNER ADDED FLUID, LOOKED FOR LEAKS AND ON "PUMPING UP THE BRAKES" FELT SUFFICIENT PRESSURE TO THEN TAKE THE VEHICLE BACK TO THE REPAIR SHOP THAT REPLACED THE ENGINE AND INSPECTED BRAKES 6 DAYS PRIOR. THE VEHICLE WAS EVALUATED BY LICENSED MECHANICS AND DETERMINED TO HAVE HAD ABS MODULE FAILURE, BRAKE FLUID FAILURE (AGAIN) AND COMPLETE BRAKE SYSTEM FAILURE. THE ABS CONTROL MODULE WAS REPAIRED/REPLACED, BRAKE FLUID WAS EVACUATED, FLUSHED AND REPLACED. THE VEHICLE HAS BEEN MAINTAINED WITH REGULAR BRAKE SYSTEM MAINTENANCE. IT HAS NOT BEEN ABUSED OR SUBJECT TO ANY CONDITIONS THAT WOULD CAUSE THE TYPE OF BRAKE SYSTEM FAILURES THAT IT IS EXPERIENCING. BECAUSE OF VIN FOR THIS VEHICLE IT WAS NOT INCLUDED IN GM RECALL FOR VEHICLES HAVING THESE PROBLEMS
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS OVER BUMPS IN THE ROAD, THE BRAKES SLIPPED AND THE PEDAL WAS STIFF. THE VEHICLE WOULD NOT RESPOND AND THE EMERGENCY BRAKE WAS ENGAGED TO STOP THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED PARAMUS CHEVROLET (94 NJ-17…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS OVER BUMPS IN THE ROAD, THE BRAKES SLIPPED AND THE PEDAL WAS STIFF. THE VEHICLE WOULD NOT RESPOND AND THE EMERGENCY BRAKE WAS ENGAGED TO STOP THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED PARAMUS CHEVROLET (94 NJ-17, PARAMUS, NJ 07652, (201) 261-7100) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 60,000.
I'VE HAD MULTIPLE EXTREMELY DANGEROUS SITUATION WITH THIS VEHICLE OVER 2 YEARS. ONE OF THE FIRST CONCERN WAS MY HEADLIGHT DAYTIME BULBS MELTED TO THE HARNESS AND THE ONE ON THE PASSENGER SIDE MELTED THRU THE NUMBER SO I STARTED CARRYING A FIRE EXTINGUISHER BEHIND THE DRIVER SEAT. BUT ONE OF THE MOST DANGEROUS INDECENT HAPPENED W…
Read full complaint
I'VE HAD MULTIPLE EXTREMELY DANGEROUS SITUATION WITH THIS VEHICLE OVER 2 YEARS. ONE OF THE FIRST CONCERN WAS MY HEADLIGHT DAYTIME BULBS MELTED TO THE HARNESS AND THE ONE ON THE PASSENGER SIDE MELTED THRU THE NUMBER SO I STARTED CARRYING A FIRE EXTINGUISHER BEHIND THE DRIVER SEAT. BUT ONE OF THE MOST DANGEROUS INDECENT HAPPENED WHILE DRIVING DOWN THE HIGHWAY WHEN MY WHEEL BEARING HUB GAVE OUT N THERE IS NOTHING ELSE TO SUPPORT THE TIRE ONTO THE TRUCK SO MY FRONT DRIVER TIRE WENT FLYING OFF N MY TRUCK COMING TO A COMPLETE STOP INTO THE GROUND CAUSING DAMAGE TO MY SELF, MY FINDER, THE WHEEL SENSOR, N THE DRIVER DOOR. AFTER GETTING ALL THAT FIXED I'M AFRAID OF THE OTHER HUBS GIVING OUT. ALSO WHEN I HIT MY BRAKES IT SEEMS LIKE THERE IS AIR IN THE PEDAL N THE TRUCK WILL NOT STOP. I DON'T KNOW IF IT'S BC THE SENSOR GOT DAMAGED OR IF THE ABS BOX IS DAMAGE FROM CORROSION AND MY EMERGENCY BRAKE HAS NEVER SEEM TO DO ANYTHING. I HAVE REPLACED MANY OF PARTS ON THIS TRUCK N WHEN I DO IT SEEMS LIKE ONE THING AFTER ANOTHER.
I'M HAVING PROBLEMS WITH INTERMITTENT STARTING. I HAVE POWER TO EVERYTHING BUT WILL NOT START WHEN KEY IS TURNED. BEEN STRANDED TWICE. ONCE IT STARTED AFTER 5 MINUTES THE NEXT TIME IT TOOK 26 HOURS.
THE BRAKES FAILED DUE TO CORROSIVE FAILURE OF BRAKE LINES. COMPLETE REPLACEMENT.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.