WHILE FRIVING ON A STREET I 8NSERTED A CIG LIGHTER IN TO CIG LIGHGER SOCKET. AND PULLED IT OUT RIGHT AWAY. SMOKE STARTED.COMING OUG FROM DASH AND VENTS. I PULLED 9VER AND POURED WATER INTO SOCKET DUE TO FIRE .N9 MY BATTERY LIGHT AND ODOMETER LIGHTS DO JOT TURN 9FF WHEB KEY IS OFF. AND NOW I START IT AND IT KEEPS STALLING. WHERE …
Read full complaint
WHILE FRIVING ON A STREET I 8NSERTED A CIG LIGHTER IN TO CIG LIGHGER SOCKET. AND PULLED IT OUT RIGHT AWAY. SMOKE STARTED.COMING OUG FROM DASH AND VENTS. I PULLED 9VER AND POURED WATER INTO SOCKET DUE TO FIRE .N9 MY BATTERY LIGHT AND ODOMETER LIGHTS DO JOT TURN 9FF WHEB KEY IS OFF. AND NOW I START IT AND IT KEEPS STALLING. WHERE DO I START?
NHTSA ODI #11109580
93,000 miles · May 31, 2017
Electrical System
EMERGENCY LIGHT SWITCH ON STEERING COLUMN BROKE OFF. I NOTICED IT WAS BROKEN AFTER I BOUGHT THE VEHICLE ON CRAIG'S LIST. THE SWITCH COULD HAVE BEEN BROKEN FOR YEARS.
NHTSA ODI #10992376
Mileage unknown · Oct 11, 2016
Air BagsElectrical SystemElectronic Stability Control (esc)
EVAPORATED SYSTEM.
NHTSA ODI #10915372
213,090 miles · Apr 4, 2016
Electrical SystemEngine And Engine CoolingPower TrainCrashFire
TRANNY, ABS, COOLING SYSTEM, TAILGATE, ETC. I BOUGHT THE TRUCK 2003 DIDN'T EXCHANGE TITLE UNTIL LATER RECALL WHEN I FIRST BOUGHT IT UNDER 50,000 MILE WARRANTY. I FILE AN COMPLAIN RECALL REPAIR STILL HAVING SAME PROBLEM. SAD THING MY FATHER IS AN RETIRED EMPLOYEE IN DALLAS LOCATION. RESEARCHED THE RECALLS FROM PREVIOUSLY AND PRE…
Read full complaint
TRANNY, ABS, COOLING SYSTEM, TAILGATE, ETC. I BOUGHT THE TRUCK 2003 DIDN'T EXCHANGE TITLE UNTIL LATER RECALL WHEN I FIRST BOUGHT IT UNDER 50,000 MILE WARRANTY. I FILE AN COMPLAIN RECALL REPAIR STILL HAVING SAME PROBLEM. SAD THING MY FATHER IS AN RETIRED EMPLOYEE IN DALLAS LOCATION. RESEARCHED THE RECALLS FROM PREVIOUSLY AND PRESENT SAME RESULTS. THEY HAVE UNTIL 2 DAYS TO CONTACT ME @ [XXX] IN GOING TO THE WAREHOUSE AND RETURN THE VEHICLE TO THE OWNER, CFO, CEO WHOMEVER AND ASK FOR A FULL REFUND OR I'M FILING AN COMPLAINT AND SMALL CLAMS FOR 30 YRS WORTH. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10853201
50 miles · May 5, 2014
Electrical SystemFuel System, Gasoline
IN ABOUT 2006, THE FUEL GAUGE IN MY HUSBAND'S TRUCK STOPPED FUNCTIONING. IT SHOWED EMPTY WHEN TANK WAS FULL. NO RECALL NOTICE WAS ISSUED TO US. WHEN HE HAD DIAGNOSED, THE DIAGNOSIS WAS A BAD CHIP OR ELECTRICAL PROBLEM, OR SWITCH. IT WOULD BE EXPENSIVE TO FIX.AT THIS TIME I WAS DIAGNOSED WITH BREAST CANCER & UNDERWENT SURGERY $ M…
Read full complaint
IN ABOUT 2006, THE FUEL GAUGE IN MY HUSBAND'S TRUCK STOPPED FUNCTIONING. IT SHOWED EMPTY WHEN TANK WAS FULL. NO RECALL NOTICE WAS ISSUED TO US. WHEN HE HAD DIAGNOSED, THE DIAGNOSIS WAS A BAD CHIP OR ELECTRICAL PROBLEM, OR SWITCH. IT WOULD BE EXPENSIVE TO FIX.AT THIS TIME I WAS DIAGNOSED WITH BREAST CANCER & UNDERWENT SURGERY $ MOS. OF CHEMO. MY HUSBAND,MILITARY RETIREE, STAYED WITH ME IN HOSPITAL. AFTER MY CHEMO, HE HAD BOTH HIPS REPLACED AND WAS BEING TREATED UNTIL 2013 FOR SPINAL INJECTIONS. IN JULY 2013, HE WAS DIAGNOSED WITH STAGE 4 CANCER & PASSED AWAY IN AUGUST. IN THE MEANTIME, WHEN HE DROVE THE TRUCK HE RECORDED MILEAGE AFTER A FILL IN ORDER TO KEEP TRACK OF AMT. OF FUEL.I ALWAYS WORRIED ABOUT THIS AS BEING NON-SAFE, BUT HE COULD ONLY GET INTO A TRUCK BECAUSE OF HIS MEDICAL CONDITION, SO OUR CHOICES WERE LIMITED.NOW AFTER HIS PASSING, THE TRUCK IS IN MY NAME BUT I DO NOT DRIVE IT BECAUSE I AM AFRAID FOR MY SAFETY BECAUSE OF THE DEFECT.I AM STILL UNDER THE CARE OF AN ONCOLOGIST AND NEED THE TRUCK AT THIS TIME. ARE YOU ABLE TO HELP WITH THIS PROBLEM? IT WOULD RELIEVE THE STRESS & GIVE ME PEACE OF MIND REGARDING MY SAFETY. I AWAIT YOUR RESPONSE. I WAS REFERRED TO YOU BY THE NHTSA. *TR
NHTSA ODI #10586634
35,000 miles · Apr 2, 2014
Electrical System
I PURCHASE MY CHEVROLET 1500 PICKUP NEW IN 2001 AND HAVE MAINTAINED WELL. FOR NO APPARENT REASON, THE ON BOARD COMPUTER WARNING LIGHT WILL INDICATE MY FUEL TANK IS EMPTY AND THE FUEL GAUGE NEEDLE WILL GO TO EMPTY. THE LIGHT AND GAUGE WILL REMAIN THIS WAY UNTIL I TURN THE VEHICLE OFF. AT THAT TIME IT MAY WORK OR IT MAY NOT. I…
Read full complaint
I PURCHASE MY CHEVROLET 1500 PICKUP NEW IN 2001 AND HAVE MAINTAINED WELL. FOR NO APPARENT REASON, THE ON BOARD COMPUTER WARNING LIGHT WILL INDICATE MY FUEL TANK IS EMPTY AND THE FUEL GAUGE NEEDLE WILL GO TO EMPTY. THE LIGHT AND GAUGE WILL REMAIN THIS WAY UNTIL I TURN THE VEHICLE OFF. AT THAT TIME IT MAY WORK OR IT MAY NOT. I CURRENTLY HAVE 72,300 MILES ON THE VEHICLE. THIS OCCURRENCE BEGAN AROUND 35,000 MILES. I HAVE HAD THE VEHICLE INTO THE DEALER SEVERAL TIMES AND THEIR RESPONSE HAS BEEN THAT IT DOESN'T HAPPEN WHEN IT IS IN THE SHOP SO THEY CANNOT DO ANYTHING ABOUT IT. I AM CONCERN WITH THE CURRENT SAFETY RECALLS WITH THE IGNITION SWITCH AND THE POSSIBILITY THAT THE IMPACT BAG MAY NOT DEPLOY IN AN ACCIDENT MAY ALSO BE AN ISSUE WITH MY VEHICLE. I HAVE NOT WORRIED ABOUT THIS UNTIL THE RECENT PROBLEMS HAVE BEEN MADE PUBLIC. *TR
NHTSA ODI #10576707
81,000 miles · Sep 13, 2011
Electrical SystemFuel System, Gasoline
RAN OUT OF FUEL ON HIGHWAY,FUEL GAUGE ALL OF A SUDDEN DROP TO EMPTY TRUCK STALLED OUT,JUST RECENTLY PURCHASED TRUCK.PREVIOUS CAR 2000 BUICK LESABRE HAD SAME ISSUE COST ABOUT $500.00 TO REPAIR,ALSO HAVE A 1996 CHEVY VAN THAT DOES THE SAME THING GM CAN NOT TELL ME THAT THEY ARE UNAWARE OF THIS ISSUE,THIS IS A SAFETY ISSUE WHEN YOU…
Read full complaint
RAN OUT OF FUEL ON HIGHWAY,FUEL GAUGE ALL OF A SUDDEN DROP TO EMPTY TRUCK STALLED OUT,JUST RECENTLY PURCHASED TRUCK.PREVIOUS CAR 2000 BUICK LESABRE HAD SAME ISSUE COST ABOUT $500.00 TO REPAIR,ALSO HAVE A 1996 CHEVY VAN THAT DOES THE SAME THING GM CAN NOT TELL ME THAT THEY ARE UNAWARE OF THIS ISSUE,THIS IS A SAFETY ISSUE WHEN YOU RUN OUT OF FUEL AT HIGHWAY SPEEDS. *TR
NHTSA ODI #10425238
78,000 miles · Aug 6, 2011
Electrical SystemParking Brake
PARKING BRAKE IS NOT HOLDING AND WE HAVE USED IT MAYBE 2 OR 3 TIMES. ABS AND BRAKE LIGHTS STAY ON ALL THE TIME. WE HAVE A 2001 CHEVROLET SILVERADO 1500. I HAVE SEEN MANY COMPLAINTS ABOUT THIS ON THE ITERNET. CAN YOU NOT DO SOMETHING ABOUT THESE COMPLAINTS. *TT
NHTSA ODI #10417751
80 miles · Jun 4, 2010
Electrical SystemExterior Lighting
WIRES THAT ARE IN THE STEERING COLUMN THAT HOOK UP TO THE MULTI-FUNCTION SWITCH BREAK DO TO USE OF THE TILT-STEERING. THEY CAN BREAK AND SHORT OUT CAUSING THE HEAD LIGHTS TO MALFUNCTION OR NOT WORK AT ALL. OR TURN OFF UNEXPECTEDLY LIKE IN MY CASE. I WAS DRIVING IN THE MOUNTAINS ONE NIGHT AROUND 10.00 PM AND ALL OF A SUDDEN MY LI…
Read full complaint
WIRES THAT ARE IN THE STEERING COLUMN THAT HOOK UP TO THE MULTI-FUNCTION SWITCH BREAK DO TO USE OF THE TILT-STEERING. THEY CAN BREAK AND SHORT OUT CAUSING THE HEAD LIGHTS TO MALFUNCTION OR NOT WORK AT ALL. OR TURN OFF UNEXPECTEDLY LIKE IN MY CASE. I WAS DRIVING IN THE MOUNTAINS ONE NIGHT AROUND 10.00 PM AND ALL OF A SUDDEN MY LIGHTS QUIT WORKING. *TR
NHTSA ODI #10334605
75,000 miles · Dec 30, 2008
Electrical System
WE OWN A 2001 CHEVY Z71 PICKUP. WE ARE HAVING A RECURRING AND POSSIBLE COMMON CHEVY PROBLEM OF THE CHECK ENGINE LIGHT STAYING ON AND THE TRUCK FAILING TO START UNLESS THE SECURITY SYSTEM IS RESET. WE TOOK IT TO THE DEALER AND THEY UNHOOKED THE AFTER MARKET REMOTE START A COUPLE OF YEARS AGO, SAYING THAT IT WAS CONFUSING THE SECU…
Read full complaint
WE OWN A 2001 CHEVY Z71 PICKUP. WE ARE HAVING A RECURRING AND POSSIBLE COMMON CHEVY PROBLEM OF THE CHECK ENGINE LIGHT STAYING ON AND THE TRUCK FAILING TO START UNLESS THE SECURITY SYSTEM IS RESET. WE TOOK IT TO THE DEALER AND THEY UNHOOKED THE AFTER MARKET REMOTE START A COUPLE OF YEARS AGO, SAYING THAT IT WAS CONFUSING THE SECURITY SYSTEM. THIS DID NOT HELP. WE DESPERATELY NEED A RECALL ISSUED BECAUSE WE CANNOT AFFORD TO GET IT FIXED OTHERWISE. THIS HAS BEEN ROUGH ON MY HUSBAND, BECAUSE HE WORKS AWAY FROM HOME AND I HAVE HAD TO PICK HIM UP IN THE MIDDLE OF THE NIGHT MANY TIMES. *TR
NHTSA ODI #10253181
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
2001 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration