NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
614 reports216,000 miles · Aug 6, 2018
Service Brakes
BRAKE LINE UNDER THE CAB BROKE DUE TO RUST. I LIVE IN EAST TENNESSEE IN AN AREA THAT DOES NOT USE EXCESSIVE AMOUNTS OF SALT ON THE ROADS IN THE WINTER AND ALWAYS TAKE VERY GOOD CARE OF MY VEHICLES. I WOULD NOT EXPECT THIS MUCH RUST ON A SAFETY COMPONENT SUCH AS THE BRAKE LINE. WHEN SLOWING TO TURN OFF THE STREET INTO MY DRIVE…
Read full complaint
BRAKE LINE UNDER THE CAB BROKE DUE TO RUST. I LIVE IN EAST TENNESSEE IN AN AREA THAT DOES NOT USE EXCESSIVE AMOUNTS OF SALT ON THE ROADS IN THE WINTER AND ALWAYS TAKE VERY GOOD CARE OF MY VEHICLES. I WOULD NOT EXPECT THIS MUCH RUST ON A SAFETY COMPONENT SUCH AS THE BRAKE LINE. WHEN SLOWING TO TURN OFF THE STREET INTO MY DRIVEWAY THE BRAKE PEDAL WENT NEARLY TO THE FLOOR AND THE BRAKES WERE VERY WEAK. THERE WAS NO ACCIDENT CAUSED BY THE LINE RUPTURE. I CALLED THE LOCAL GM DEALERSHIP AND WAS QUOTED IN EXCESS OF $1,000 FOR REPAIR.
NHTSA ODI #11118089
220,000 miles · Jul 16, 2018
Service Brakes
TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 1500. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE ABS AUTOMATICALLY ENGAGED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED ABOUT THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 220,000.
NHTSA ODI #11111695
130,000 miles · Jul 1, 2018
Service BrakesUnknown Or Other
TOOK VEHICLE IN FOR SERVICE AND INSPECTION AND WAS TOLD FRAME WAS RUSTED AND NO LONGER SAFE TO DRIVE. FRAME FAILURE IS UNACCEPTABLE AND AN EXTREME SAFETY HAZARD. BRAKES LINES HAD ALSO RUSTED OFF PREVIOUS AND REPLACED. VEHICLE ONLY HAS 130,000 MILES.
NHTSA ODI #11104975
138,000 miles · Feb 22, 2018
Service Brakes
BRAKE LINE CORRODED (FROM OUTSIDE) AND DURING A TRIP HOME FROM WORK, I SUDDENLY HAD NO BRAKES WHEN BRAKE PEDAL WAS APPLIED. I HAD JUST ARRIVED IN MY DRIVEWAY AND WAS TURNING AROUND. I WAS PROBABLY DOING 1 MPH OR LESS AND VEHICLE WAS EXTREMELY DIFFICULT TO STOP.
NHTSA ODI #11074248
225,000 miles · Nov 4, 2017
Fuel/propulsion SystemSteeringSuspension
WHEN GOING THE SPEED LIMIT THE TRUCK SEEMS TO WANT TO CROSS OVER LANES JUST BY CROSSING A DIP. IT FEELS FLOATY ON THE ROAD ANOTHER WORDS IT DOESN'T WANT TO STAY IN ITS OWN LANE
NHTSA ODI #11043210
175,000 miles · Nov 4, 2017
Power TrainService BrakesSuspension
I JUST HAD TRANSMISSION WORK DONE ON MY TRUCK WHEN IT BURNED THE GEARS UP. MY BRAKES HAVE ALWAYS EITHER WENT COMPLETELY TO THE FLOOR BEFORE THEY STOPPED OR LOCKED UP. RIGHT NOW ITS BROKE DOWN DUE TO TOO MANY PROBLEMS FOR ME TO BE ABLE TO FIX BUT HAS ONLY BEEN NOT DRIVEABLE SINCE JULY 2017
NHTSA ODI #11043200
112,000 miles · Oct 4, 2017
Service Brakes
I WENT TO MOVE MY VEHICLE AND WAS ABLE TO BACK UP INTO THE ROAD. AS I WAS COMING BACK DOWN MY DRIVEWAY MY PEDAL WENT TO THE FLOOR AND I COULD NOT STOP. LUCKILY I WAS ONLY GOING A COUPLE MILES PER HOUR AND I WAS ABLE TO JAM IT IN PARK BEFORE GOING THROUGH OUR HOUSE. I GOT OUT VERY NERVOUS AND SAW BRAKE FLUID SPRAYING EVERYWHERE.
NHTSA ODI #11031696
175,000 miles · Sep 18, 2017
Service BrakesCrash
TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 1500. WHILE MAKING A LEFT TURN INTO A DRIVEWAY AT APPROXIMATELY 10-15 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 1500. WHILE MAKING A LEFT TURN INTO A DRIVEWAY AT APPROXIMATELY 10-15 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). NEITHER THE MANUFACTURER NOR THE DEALER WAS CONTACTED OR NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
NHTSA ODI #11024020
120,000 miles · Jul 6, 2017
Service Brakes
THE BRAKE LINES RUSTED THROUGH PREMATURELY, RESULTING IN A COMPLETE FAILURE TO STOP THE VEHICLE.
NHTSA ODI #11003457
292,000 miles · Jul 6, 2017
Air BagsCrash
TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 1500. WHILE DRIVING HIGHWAY SPEEDS, THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION DUE TO ANOTHER DRIVER HARD BRAKING. EVEN THOUGH THE VEHICLE WAS EQUIPPED WITH AN AIR BAG ON/OFF SWITCH, WHICH DISABLED THE PASSENGER SIDE AIR BAG FROM DEPLOYING, THE AIR BAG STILL DEPLOYED. A POLI…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 1500. WHILE DRIVING HIGHWAY SPEEDS, THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION DUE TO ANOTHER DRIVER HARD BRAKING. EVEN THOUGH THE VEHICLE WAS EQUIPPED WITH AN AIR BAG ON/OFF SWITCH, WHICH DISABLED THE PASSENGER SIDE AIR BAG FROM DEPLOYING, THE AIR BAG STILL DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE SCENE TO A&A TOWING SALVAGE YARD AND HAD NOT BEEN DETERMINED WHETHER IT WAS DESTROYED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS APPROXIMATELY 292,000.
NHTSA ODI #11003416
NHTSA investigations
2EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
Illustration