I HAVE A 1999 CHEVROLET SILVERADO AND MY ABS LIGHT AND PARKING BRAKE LIGHT HAS CAME ON RECENTLY. THE BRAKING ON MY TRUCK IS NOT VERY GOOD IN WET CONDITIONS. I FOUND THAT IT IS A COMMON PROBLEM ON CHEVY TRUCKS, AND I WAS TOLD THAT I SHOULD JUST REMOVE THE FUSE. I WAS TOLD IT HAS SOMETHING TO DO WITH THE WHEEL HUB ASSEMBLY, AND I…
Read full complaint
I HAVE A 1999 CHEVROLET SILVERADO AND MY ABS LIGHT AND PARKING BRAKE LIGHT HAS CAME ON RECENTLY. THE BRAKING ON MY TRUCK IS NOT VERY GOOD IN WET CONDITIONS. I FOUND THAT IT IS A COMMON PROBLEM ON CHEVY TRUCKS, AND I WAS TOLD THAT I SHOULD JUST REMOVE THE FUSE. I WAS TOLD IT HAS SOMETHING TO DO WITH THE WHEEL HUB ASSEMBLY, AND IT IS A COSTLY FIX. I THINK FOR ONCE CHEVROLET SHOULD STEP UP AND PUT OUT A RECALL ON THIS PROBLEM. THERE IS ALSO ANOTHER COMMON COMPLAINT ABOUT MY DASH CLUSTER, WHICH I HAD ALSO FOUND IS A COMMON PROBLEM, THE ODOMETER WILL GO OFF AND ON WHEN IT FEELS LIKE, AND THE GAS GAUGE FREQUENTLY GOES UP AND DOWN, AND THE FUEL LIGHT COMES ON PERIODICALLY. THANK YOU FOR YOUR TIME. *TR
NHTSA ODI #10207095
38,621 miles · Dec 2, 2003
Power TrainSuspension
WHILE DRIVING 60 MPH THE CONSUMER HEARD A LOUD RATTLING NOISE AND PULLED OVER. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE THE MECHANIC INFORMED THE CONSUMER THAT THE PROBLEM WAS IN THE REAR END SUSPENSION. THE PROBLEM HAS NOT BEEN RESOLVED. *NLM *SCC THE DEALER REBUILT THE REAR DIFFERENTIAL. *JB
NHTSA ODI #10042272
Mileage unknown · Nov 19, 2003
Suspension
WHILE HAVING NEW TIRES PUT ON MECHANIC NOTICED THAT DRIVER'S SIDE BALL JOINTS FAILED AND NEEDED TO BE REPLACED. *AK
NHTSA ODI #10048243
Mileage unknown · Jun 12, 2001
Suspension
ALIGNMENT PROBLEM RUINED LEFT FRONT TIRE. THE SIDEWALLS WERE CRACKING ON ALL THE TIRES. DEALER SAID THE TIRES WERE NOT SUITABLE FOR THE WEIGHT OF THE VAN. THERE SHOULD BE A STANDARD FOR REPLACEMENT PART.
NHTSA ODI #9002778
Mileage unknown · Apr 25, 2001
Service Brakes, HydraulicSuspension
THE TRUCK HAS BEEN TO THE DEALER OFTEN AND THEY ADMITED THEY COULD NOT GUARNTEE THEY HAVE FIXED THE FRONT END THE SERVICE MGR CROSSED HIS FINGERS AND WITH A RESPONSE THAT HE HOPE SO WE DONT DRIVE THE TRUCK OFTEN FOR FEAR OF AN ACCIDENT EITHER THE WHEELS LOCKING UP OR THE BRAKES FAILING, HE SAID THEY TIGHTED A BOLT ON THE SUBFRAM…
Read full complaint
THE TRUCK HAS BEEN TO THE DEALER OFTEN AND THEY ADMITED THEY COULD NOT GUARNTEE THEY HAVE FIXED THE FRONT END THE SERVICE MGR CROSSED HIS FINGERS AND WITH A RESPONSE THAT HE HOPE SO WE DONT DRIVE THE TRUCK OFTEN FOR FEAR OF AN ACCIDENT EITHER THE WHEELS LOCKING UP OR THE BRAKES FAILING, HE SAID THEY TIGHTED A BOLT ON THE SUBFRAME AND THAT FIXED THE FRONT END BUT A GM ENGR TOLD ME THAT TRUCK DOES NOT HAVE A SUBFRAME ONLY VEHICLES WITH UNIBODIES USE SUBFRAMES, I HAVE DOCUMENTED ALL SERVICES AND RESPONSES IF NEEDED. *AK
NHTSA ODI #744506
Mileage unknown · Oct 23, 2000
Power TrainSeat BeltsSuspension
THE SEAT BELTS ARE PREMATURELY LOCKING. *MJS
NHTSA ODI #556504
Mileage unknown · Sep 1, 2000
Suspension
BOTH FRONT WHEEL BEARING WENT OUT AS WELL AS WINDOW REGULATOR'S WITH LESS THEN 3000 MILES ON THE PICK UP AND THE DEALER HAS HAD OTHER TRUCKS OF THE SAME TYPE WITH FRONT END SUSPENSION PROBLEMS WHICH DUPLICATES MINE.
NHTSA ODI #729795
Mileage unknown · Apr 19, 2000
Suspension
WHEELS CANNOT BE ALIGNED DUE TO THE WASHER WHICH IS WELDED ON. REPLACED TIRES LESS THAN ONE YEAR FROM PURCHASE, VEHICLE PULLS TO THE RIGHT. *AK *ML
NHTSA ODI #860604
Mileage unknown · Mar 15, 2000
Power TrainSuspensionTires
TRUCK VIBRATES AT HWY SPEED 65-70 SINCE PURCHASE. REPLACE GENERAL TIRES WITH MICHELIN TIRES TO NO AVAIL.
NHTSA ODI #9000091
Mileage unknown · Feb 2, 2000
SteeringSuspension
STEERING SHAFT BEARINGS FAILED CAUSING RATTLE IN STEERING WHEEL. *MJS
NHTSA ODI #550643
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
1999 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration