IllustrationTHE FUEL PUMP ASSEMBLY MELTED AND BURNED THE INSIDE OF THE GAS TANK. *JB
1996 Chevrolet Sierra Pu
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra Pu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
What owners actually said
4 reportsRIGHT FRONT PASSENGER'S SEAT BELT SUCKS BACK IN AFTER IT'S LOCKED IN BUCKLE. KEEPS TIGHTENING IF A BUMP IS HIT OR A PERSON MOVES. TOOK TO DEALER & WAS INFORMED IT'S FOR A CHILD RESTRAINT. CAN PULL OUT BELT, BUT IT KEEPS TIGHTENING. HAS CONTACTED THE MANUFACTURER. *AK *ML
PULLED OUT OF PARKING LOT ONTO THE HIGHWAY 29 IN LIBERTY HILL AND WENT OVER A OIL SPILL ABOUT A GALLON OF OIL.AFTER GOING OVER IT, THE VEHICLE LOST TOTAL CONTROL OF STEERING AND WENT TO THE LEFT SIDE OF THE ROAD .THE STEERING SHOT TO THE RIGHT, AND COULN'T MOVE THE WHEEL. VEHICLE RAN INTO THE DITCH AND HIT A TREE. DRIVER'S SIDE…
Read full complaint
PULLED OUT OF PARKING LOT ONTO THE HIGHWAY 29 IN LIBERTY HILL AND WENT OVER A OIL SPILL ABOUT A GALLON OF OIL.AFTER GOING OVER IT, THE VEHICLE LOST TOTAL CONTROL OF STEERING AND WENT TO THE LEFT SIDE OF THE ROAD .THE STEERING SHOT TO THE RIGHT, AND COULN'T MOVE THE WHEEL. VEHICLE RAN INTO THE DITCH AND HIT A TREE. DRIVER'S SIDE AIRBAG DIDN'T DEPLOY. DRIVING SPEED 40 TO 45MPH EVEN ROAD.TOOK THE VEHICLE 4 TIMES TO THE DEALER FOR THE SAME PROBLEM, AND HAS NOT BEEN FIXED. *AK
TWO TIRES WENT FLAT DUE TO PUNCTURE OF THE TREAD SIDE OF TIRE (WRANGLER 265/7R16 TIRES).
Official recalls
103V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.