VEHICLE HAVING SERIES OF PROBLEMS AFTER AN ACCIDENT WITH A DEER. *MR THE HOOD LATCH HASN'T WORKED PROPERLY SINCE THE ACCIDENT, BOTH CHAIR LATCHES HAD BROKEN AFTER TWO TIMES OF USE, THE RIGHT FRONT OF THE VEHICLE MADE NOISE, THERE WAS NOISE IN THE STEERING, THE CENTRAL CONSOLE SNAPPED IN HALF, AND THE REAR WIPERS HAD GONE OUT…
Read full complaint
VEHICLE HAVING SERIES OF PROBLEMS AFTER AN ACCIDENT WITH A DEER. *MR THE HOOD LATCH HASN'T WORKED PROPERLY SINCE THE ACCIDENT, BOTH CHAIR LATCHES HAD BROKEN AFTER TWO TIMES OF USE, THE RIGHT FRONT OF THE VEHICLE MADE NOISE, THERE WAS NOISE IN THE STEERING, THE CENTRAL CONSOLE SNAPPED IN HALF, AND THE REAR WIPERS HAD GONE OUT. *SCC *JB
NHTSA ODI #10048207
Mileage unknown · Oct 24, 2002
SteeringInjury
BENT AND TWISTED FINGERS MR. SAM ADAMS FINGERS ARE TWISTED AND BENT FROM TO CONFORM TO THE CONTOUR OF THE STEERING WHEEL ON THE CHEVROLET S-10 HE DRIVES. MR. ADAMS WISHES HIS NAME BE HELD IN CONFIDENCE. THIS INFORMATION IS BEING SUPPLIED TO YOU FOR INFORMATION ON THE STEERING EFFORT DAMAGE TO DRIVERS FINGERS BY MIKE TOMICH 989…
Read full complaint
BENT AND TWISTED FINGERS MR. SAM ADAMS FINGERS ARE TWISTED AND BENT FROM TO CONFORM TO THE CONTOUR OF THE STEERING WHEEL ON THE CHEVROLET S-10 HE DRIVES. MR. ADAMS WISHES HIS NAME BE HELD IN CONFIDENCE. THIS INFORMATION IS BEING SUPPLIED TO YOU FOR INFORMATION ON THE STEERING EFFORT DAMAGE TO DRIVERS FINGERS BY MIKE TOMICH 989-665-2311
NHTSA ODI #768852
Mileage unknown · Jun 26, 2002
Electrical SystemSteering
VEHICLE STALLS AFTER FIRST START. ALSO,SECURITY SYSTEM LIGHT COMES ON. PLEASE ADD FURTHER INFORMATION.*AK
NHTSA ODI #8012686
Mileage unknown · Mar 9, 2001
Steering
STEERING HAD EXCESSIVE PLAY, VIRING EITHER WAY, THE STEERING GREAR BOX NEEDED TO BE REPLACE. JOHN L. SULLIVAN SOLD US THE TRUCK IN THAT CONDITION. WHEN QUESTIONED ABOUT THE PLAY IN THE STEERING, THEY SAID NOTHING WAS WRONG. HOWEVER ONCE I LOST CONTROL OF THE TRUCK I THEN KNEW THAT THERE HAD TO BE SOMETHING WRONG. SO I TOOK IT …
Read full complaint
STEERING HAD EXCESSIVE PLAY, VIRING EITHER WAY, THE STEERING GREAR BOX NEEDED TO BE REPLACE. JOHN L. SULLIVAN SOLD US THE TRUCK IN THAT CONDITION. WHEN QUESTIONED ABOUT THE PLAY IN THE STEERING, THEY SAID NOTHING WAS WRONG. HOWEVER ONCE I LOST CONTROL OF THE TRUCK I THEN KNEW THAT THERE HAD TO BE SOMETHING WRONG. SO I TOOK IT DIRECTLY TO WOODARD CHEVROLET, (THE CLOEST DEALERSHIP) WERE THEY REPAIRED IT ONCE THE PART WERE AVAILABLE.
NHTSA ODI #742156
Mileage unknown · Oct 5, 2000
Steering
PICKUP STILL HAS STEERING PROBLEMS/WANDERS ON UNEVEN ROADS/FREEWAYS. SHOULD FEEL TIGHTER AND MORE CONTROLLABLE FOR A TRUCK THIS NEW. I HAVE NOT BEEN OFF ROAD 4X4 OR HAD AN ACCIDENT WITH THIS VECHICLE. THE STEERING HAS BEEN A PROBLEM SINCE THE DAY I BOUGHT
NHTSA ODI #733531
Mileage unknown · Feb 24, 2000
SteeringSuspension
FRONT TIE RODS AND STABILIZER BAR AND EVERTHING IN BETWEEN BROKE WHICH MAY HAVE CAUSED A LOSS OF VEHICLE CONTROL AND RESULT IN A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #857483
Mileage unknown · Jan 16, 2000
SeatsSteering
MY POWER STEERING SYSTEM HAS ALWAYS MADE A NOISE WHEN I MAKE LEFT OR RIGHT HAND TURNS. I HAVE REPORTED IT TO THE DEALERSHIP ON TWO OCCASIONS, BUT THEY NEVER FOUND ANYTHIN WRONG WITH IT, AND NOW IT IS NOT UNDER WARRANTY. THEY SAID THAT THEY COULDN'T DUPLICATE IT BUT IT HAPPENS EVERY TIME IT IS DRIVEN, SO I DON'T SEE HOW THEY COUL…
Read full complaint
MY POWER STEERING SYSTEM HAS ALWAYS MADE A NOISE WHEN I MAKE LEFT OR RIGHT HAND TURNS. I HAVE REPORTED IT TO THE DEALERSHIP ON TWO OCCASIONS, BUT THEY NEVER FOUND ANYTHIN WRONG WITH IT, AND NOW IT IS NOT UNDER WARRANTY. THEY SAID THAT THEY COULDN'T DUPLICATE IT BUT IT HAPPENS EVERY TIME IT IS DRIVEN, SO I DON'T SEE HOW THEY COULD'VE MISSED IT. ALSO, THE RECLINER LEVER ON THE DRIVER SIDE SEAT BROKE OFF AT THE METAL AFTER THE WARRANTY HAD ALREADY EXPIRED SO I GUESS I'M OUT OF LUCK WITH THAT. *AK
NHTSA ODI #717405
Mileage unknown · Mar 31, 1999
Steering
STREERING WHEEL RATTLES/VIBRATES/SHAKES- IS LOOSE IN THE STEERING COLUMN. WAS INTO DEALER 3 TIMES, LAST TIME PICKED UP (TODAY) DEALER HAS SEEN THIS PROBLEM IN THIS MODEL TRUCK, AND EXPECTS A PRODUCT RECALL SOON, OR PARTS TO FIX THIS. CURRENTLY THERE IS NO FIX AND IS A MAJOR SAFTEY CONCERN TO ME.
NHTSA ODI #705145
Mileage unknown · Feb 1, 1999
Engine And Engine CoolingPower TrainSteering
BAD REAR DIFFERENTIAL GREASE SEAL CAUSED REAR END TO LEAK. YH
NHTSA ODI #608888
Mileage unknown · Feb 1, 1999
Steering
POWER STEERING ASSEMBLY FAILED, CAUSING LEAKAGE. *YC
VEHICLE DESCRIPTION: ELECTRIC PASSENGER VEHICLES AND PICKUP TRUCKS CONTAINING A NICKEL METAL HYDRIDE (NIMH) BATTERY PACK. THESE VEHICLES CONTAIN SOFTWARE WITHIN THE BATTERY PACK MODULE INTENDED TO DISABLE THE VEHICLE FROM BEING DRIVEN IF THE ELECTRICAL RESISTANCE WITH THE BATTERY PACK EXCEEDS A PRESCRIBED VALUE. AFFECTED VEHICLES WILL ILLUMINATE THE "SERVICE NOW" AND "REDUCED PERFORMANCE" TELLTALES AND CONTINUE TO FUNCTION IN A REDUCED PERFORMANCE MODEL INSTEAD OF BEING DISABLED.
Consequence & remedy
Consequence: IF THE TELLTALES ARE IGNORED AND THE AFFECTED VEHICLE CONTINUES TO BE DRIVEN, HEAT COULD BUILD UP AND A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL REVISED SOFTWARE IN THE BATTERY PACK MODULE.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence & remedy
Consequence: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence & remedy
Consequence: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Consequence & remedy
Consequence: THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence & remedy
Consequence: PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
EA99012 · Post Collision Fuel System Integrity
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGE THAT IN CERTAIN SIDE IMPACT CRASHES, THE SUBJECT FUEL TANKS MAY CONTACT THE PROP SHAFT REAR UNIVERSAL JOINT COMPONENTS WITH SUFFICIENT FORCE TO PUNCTURE THE TANK.
1998 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration