Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 28 of 910 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 306 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 206 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
176 crash reports13 fire reports100 injury reports
What owners actually said
910 reports
Mileage unknown · May 6, 2000
Engine And Engine CoolingFuel System, GasolineVehicle Speed Control
THE EGR SYSTEM CONTINUALY FAILED NUMEROUS TIMES. WHEN THIS FAILURE HAPPENED, THE IDLE WOULD FLUCUATE WILDLY RESULTING IN THE LOSS OF THE ENGINE VACUUM AND THE LOSS OF POWER BRAKES. THIS HAPPENED OVER 5 TIMES, THANKFULLY ON UNCROWDED STREETS. THE CAR WOULD OFTEN HAVE LITTLE TO NO STOPPING POWER WHEN BELOW 20-25 MPH. OFTEN I WOULD…
Read full complaint
THE EGR SYSTEM CONTINUALY FAILED NUMEROUS TIMES. WHEN THIS FAILURE HAPPENED, THE IDLE WOULD FLUCUATE WILDLY RESULTING IN THE LOSS OF THE ENGINE VACUUM AND THE LOSS OF POWER BRAKES. THIS HAPPENED OVER 5 TIMES, THANKFULLY ON UNCROWDED STREETS. THE CAR WOULD OFTEN HAVE LITTLE TO NO STOPPING POWER WHEN BELOW 20-25 MPH. OFTEN I WOULD HAVE TO APPLY THE EMERGENCY BRAKE TO STOP THE CAR. THE PROBLEM WAS FIXED WITH A REPLACEMENT OF THE EGR VALVE, BUT HOPEFULLY THIS HORRIBLE PROBLEM WIL NOT OCCUR AGAIN. CURRENTLY I AM IN THE PROCESS OF TRYING TO GET CHEVROLET TO PAY FOR THE REPLACEMENT, SINCE APPARANTLY THIS IS A RESULT OF THEIR BAD FUEL INJECTORS. CHEVROLET HAS JUST ISSUED A RECALL ON THEIR FUEL INJECTORS WHICH APPARANTLY FAILED, AND LEAD TO CARBON BUILDUP ON THE EGR, WHICH CAUSES THIS TREMENDOUS SAFETY PROBLEM. THROUGH MY OWN RESEARCH ON OTHER WEBSITE, SUCH AS MSN CARPOINT, IT STATES THE THE 94-96 MODELS WITH THIS ENGINER REPORT EGR AND FUEL INJECTOR REPLACEMENT. THIS IS A HUGE SAFETY ISSUE CHEVROLET SHOULD TAKE RESPONSIBILITY FOR. THANK YOU.
NHTSA ODI #722327
Mileage unknown · Apr 17, 2000
Visibility
WINDSHIELD WIPERS MALFUNCTIONED, CAUSING VISUAL DIFFICULTY WHICH MAY RESULT IN A CRASH. THERE IS RECALL 98V150000 WHICH DEALS WITH THIS PROBLEM. BUT THIS VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN ALTHOUGH IT HAS THE SAME PROBLEM. *AK
NHTSA ODI #860450
Mileage unknown · Apr 7, 2000
Air BagsCrashInjury
WHILE VEHICLE WAS AT A COMPLETE STOP IT WAS REAR ENDED BY ANOTHER VEHICLE. CONSUMER'S VEHICLE WAS STUCK BETWEEN TWO VEHICLES, AND AIR BAGS DID NOT DEPLOY. *AK
NHTSA ODI #859907
Mileage unknown · Apr 7, 2000
Exterior Lighting
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #711156
Mileage unknown · Apr 5, 2000
Power Train
HEAT FROM DRIVING CAUSES THE CLUTCH TO STICK DUE TO DEFECTIVE CLUTCH MASTER RESERVOIR, THIS CAUSES THE TRUCK TO LUNGE FORWARD OR IN REVERSE IF CONSUMER TRIES TO DISENGAGE GEAR IN TRAFFIC. YH
NHTSA ODI #551754
Mileage unknown · Mar 29, 2000
Air BagsCrashInjury
WHEN TRUCK WAS INVOLVED IN A CRASH TRAVELING AT 35 MPH, THERE WAS NO DEPLOYMENT OF THE DRIVER'S SIDE AIR BAG. VEHICLE TOTAL LOSS. *AK.ET.
NHTSA ODI #859362
Mileage unknown · Mar 13, 2000
Visibility
COMPLETE WINDSHIELD WIPER/WASHER SYSTEM FAILED TO OPERATE WHEN TURNING, FAILURE OCCURRED FOR FIVE MIN. AND RESTARTED
NHTSA ODI #9000109
Mileage unknown · Mar 8, 2000
Fuel System, Gasoline
A BAD FUEL INJECTOR CAUSED FUEL TO LEAK INTO THE VEHICLE'S CYLINDERS,CRANKCASE AND TAILPIPE. YH
NHTSA ODI #551269
Mileage unknown · Mar 7, 2000
Engine And Engine Cooling
HEAD GASKET LEAK / EGR FAILURE @ 95000. *AK
NHTSA ODI #719817
Mileage unknown · Mar 2, 2000
Service Brakes, Hydraulic
ONGOING PROBLEM WITH EXCESSIVE WEAR AND FAULTY ROTORS. THREE ROTORS WERE REPLACED AND TURNED TWICE EACH. ALSO, FIVE SETS OF BRAKE PADS WERE REPLACED FROM 22,0000 MILES OF WEAR UNTIL THE PRESENT, 58,000 MILES OF WEAR. DEALER NOTIFIED. *AK *ML
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1995 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration