IllustrationABS WARNING LIGHTS ON, REAR BRAKES LOCK IN DAMP / WET WEATHER / LOSS OF VEHICLE CONTROL / EXTENDED STOPPING DISTANCE. *AK *MR
1992 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1992 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 180 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports8 fire reports11 injury reports
What owners actually said
180 reportsPROBLEMS WITH THE FUEL TANK. *PH (NAR) FUEL TANK LEAKED. *NM
GAS TANK RUSTED UNDER THE COVER. WARRANTY EXPIRED, YET FUMES WERE NOTICED WITHIN 50 FEET OF THE VEHICLE. *AK *MR
MY SON AND I BOTH OWN CHEVROLETS S10 TRUCKS. BOTH OF THEM DEVELOPED PROFUSE OIL LEAKS FROM THE OIL FILTER ADAPTER LINES. THIS CAUSED A TOTAL HEMORRHAGE OF OIL BEFORE IT COULD BE DISCOVERED AND DAMAGED THE ENGINES. WHAT A SURPRISE TO DISCOVER SEVERAL OTHER SIMILAR GENERAL MOTORS VEHICLES IN THE SAME SHOP WITH THE SAME PROBLEM. TH…
Read full complaint
MY SON AND I BOTH OWN CHEVROLETS S10 TRUCKS. BOTH OF THEM DEVELOPED PROFUSE OIL LEAKS FROM THE OIL FILTER ADAPTER LINES. THIS CAUSED A TOTAL HEMORRHAGE OF OIL BEFORE IT COULD BE DISCOVERED AND DAMAGED THE ENGINES. WHAT A SURPRISE TO DISCOVER SEVERAL OTHER SIMILAR GENERAL MOTORS VEHICLES IN THE SAME SHOP WITH THE SAME PROBLEM. THE SHOP OWNERS SAID THIS IS A COMMON DEFECT WITH THESE CHEVROLET AND GMC TRUCKS, AND THAT THEY HAD REPLACED LEAKING LINES ON 8 OR 10 IN JUST THE PAST MONTH. IF THIS IS HAPPENING IN ONE SMALL SHOP IN TOWN, HOW MANY IS IT HAPPENING TO ALL OVER THE COUNTRY? MOST OF THE TRUCKS SUFFERED SIGNIFICANT ENGINE DAMAGE REQUIRING A COMPLETE OVERHAUL BECAUSE YOU DON'T KNOW THE OIL IS LEAKING OUT UNTIL THE ENGINE BEGINS MAKING NOISE OR SEIZES. THIS COULD BE A VERY DANGEROUS DEFECT BECAUSE THE OIL LINES ARE VERY NEAR THE EXHAUST PIPE AND COULD SPRAY OIL ONTO IT. SOMEONE TRAVELING AT HIGHWAY SPEEDS WOULD BE UNAWARE THIS WAS HAPPENING UNTIL THE VEHICLE WAS AFIRE. IT COULD ALSO SPRAY OIL ONTO THE TIRE AND CAUSE LOSS OF CONTROL. GENERAL MOTORS SHOULD BE MADE TO BE RESPONSIBLE FOR CORRECTING BOTH THE DEFECTIVE DESIGN AND FOR REPAIRING/REPLACING DAMAGED ENGINES CAUSED BY IT. *AK
WINDSHIELD WIPERS TURN ON WHEN TURN SIGNAL IS ACTIVATED.*MR CONSUMER FELT AS THOUGH THIS CAUSED A MINOR DISTRACTION TO THE DRIVER AND SHOULD BE CORRECTED. *PH *JB
THE LEFT REAR TIRE BLEW OUT ON THE VEHICLE. FIRESTONE TRIUMPH. *AK WHILE DRIVING, THERE WAS A LOUD NOISE, THE CONSUMER PULLED OVER, AND DISCOVERED, THE ENTIRE TIRE WAS IN SHREDS AND THE WHOLE SIDE OF THE WHITE WALL HAD BLOWN OFF AND WAS JUST HANGING BY LITTLE PIECES. *TS *JB
THE RIGHT PASSENGER TIRE EXPERIENCED TREAD SEPARATION. *JB SCC
POTENTIAL HAZARD IF HOIST BREAKS ON HIGHWAY SPARE TIRE MAY CAUSE SERIOUS DAMAGE OR INJURY TO VEHICLES IN REAR. MR
RECALL 99V193 REPAIRS FOR ABS BRAKES WERE COMPLETED, HOWEVER WHEN CONSUMER APPLIED THE BRAKES, THEY DID NOT HOLD. *AK CONSUMER ADDS; WHEN APPLYING THE BRAKES THEY DO NOT STOP THE VEHICLE AS QUICKLY AS OUR OTHER VEHICLES. *SCC
CONSUMER WAS GETTING INSIDE OF VEHICLE AND DRIVER'S SIDE SEAT BROKE. MOUNT WHICH IS LOCATED INSIDE OF SEAT CAME APART. DEALERSHIP IS AWARE OF PROBLEM.*AK
Official recalls
399V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
96V195000 · Steering:gear Box:shaft Sector
Oct 8, 1996
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
93V008000 · Engine And Engine Cooling:cooling System:fan
Jan 14, 1993
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence & remedy
Consequence: IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Remedy: INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
PE94046 · Abs Braking System Fails
Opened Jun 17, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available