IllustrationWHILE DRIVING, FAN CAME OFF IN 1995 CHEVROLET BLAZER AND DAMAGE THE RADIATOR. THIS IS SIMILAR TO CAMPAIGN 95V-180. IF HOOD WOULD HAVE BEEN OPEN, THIS COULD HAVE BEEN A HAZARD. *TR
1995 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1995 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 28 of 910 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 306 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 206 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
176 crash reports13 fire reports100 injury reports
Engine And Engine Cooling complaints
84 reportsFROM WHAT I HAVE BEEN ABLE TO FIND OUT, THERE IS A CARBON BUILD UP IN THE ENGINE, AND WHEN SOME OF THIS CARBON FLAKES OFF IT CAUSES THE EGR VALVE TO STICK OPEN SLIGHTLY. THIS IN TURN CAUSES THE ENGINE IDLE VERY ERRATICALLY AND MOST OF THE TIME CAUSES THE ENGIE TO STALL. THIS ALWAYS OCCURS WHEN SLWOING DOWN AND STOPPING WHICH IS …
Read full complaint
FROM WHAT I HAVE BEEN ABLE TO FIND OUT, THERE IS A CARBON BUILD UP IN THE ENGINE, AND WHEN SOME OF THIS CARBON FLAKES OFF IT CAUSES THE EGR VALVE TO STICK OPEN SLIGHTLY. THIS IN TURN CAUSES THE ENGINE IDLE VERY ERRATICALLY AND MOST OF THE TIME CAUSES THE ENGIE TO STALL. THIS ALWAYS OCCURS WHEN SLWOING DOWN AND STOPPING WHICH IS QUITE THE SAFETY HAZARD AS WHEN THE VEHICLE BEGINS TO LOSE POWER AND STALL ALL THE POWER OPTIONS SUCH AS STEERING AND BRAKES ARE ALSO LOST. THIS HAS ALMOST CAUSED ME TO REAR END PEOPLE NUMEROUS TIMES ESPECIALLY IN SITUATIONS WHEN I HAVE HAD TO STOP QUICKLY. I WAS INFORMED BY MY MECHANIC THAT THIS ACTUALLY A RECALL AND WHENI CONTACTED CHEVROLET THEY SAID IT WAS NOT AN OFFICIAL RECALL BUT IF MY VEHICLE HAD LESS THAN 75,000 MILES ON IT I COULD HAVE THE PROBLEM FIXED. OF COURSE I HAD MORE THAN 75,000 MILES AND SO THEY REFUSED TO DO ANYTHING. OTHER THAN THIS MY TRUCK RUNS GREAT AND I LIKE IT BUT IT WILL COST APPROXIMATELY $700-$1000 TO HAVE THIS FIXED AND IN ALL HONESTY IT IS NOT MY FAULT THAT MY TRUCK DID NOT BREAK UNTIL AFTER THE 75,000 MARK. INSTEAD I AM BEING FORCED TO GET A NEW VEHICLE AND SPEND MONEY I SHOULD NOT HAVE TO BECAUSE THE TRUCK IS UNSAFE TO DRIVE AND THE REAPIRS ARE TO EXPENSIVE IN COMPARISON TO THE ACTUAL VALUE OF THE TRUCK.
THE VEHICLE HAS AN ONGOING PROBLEM WITH THE OIL COOLANT LINE FAILING WHILE DRIVING AT VARIOUS SPEEDS. THIS FAILURE RESULTS IN THE VEHICLE STALLING, BUT IT WILL RESTART WITHIN MINUTES. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP, WHERE THE FAILURE RECURRED. THE COOLANT LINE HAS BEEN REPLACED TWICE. THE FIRST FAILURE OCCURRED AT 30,…
Read full complaint
THE VEHICLE HAS AN ONGOING PROBLEM WITH THE OIL COOLANT LINE FAILING WHILE DRIVING AT VARIOUS SPEEDS. THIS FAILURE RESULTS IN THE VEHICLE STALLING, BUT IT WILL RESTART WITHIN MINUTES. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP, WHERE THE FAILURE RECURRED. THE COOLANT LINE HAS BEEN REPLACED TWICE. THE FIRST FAILURE OCCURRED AT 30,000 THEN 60,000 AND NOW AT 120,000. IT SEEMS TO BE OCCURRING EVERY 30,000 MILES. *JB THE INTAKE WAS LEAKING OIL. *SC
1995 CHEVROLET S10 DEVELOPED A PROBLEM WITH THE EGR VALVE CLOGGING AS WELL AS PROBLEMS WITH THE BRAKES.***NO ANSWER REQUIRED***. *MR THE MANUFACTURER FIXED THIS PROBLEM ABOUT TWO YEARS AGO BUT IT HAS FAILED AGAIN. THIS IS THE FOURTH TIME IT HAS FAILED. *NM
HAVING MAJOR HEAD GASKET PROBLEMS. ITS THE SEC. TIME HEAD GASKET HAS GONE OUT ON MY 2.2L S-10
I OWN A 1995 S10 (4X4) PICK UP. I PURCHASED THIS VEHICLE NEW IN 1994. I HAD TO REPLACED THE REMOTE OIL FILTER LINES 3 TIMES!!! MY THIRD SET IS CURRENTLY LEAKING. THE REMOTE OIL FILTER LINES FAIL WHERE THE RUBBER HOSE IS CRIMPED TO THE ALUMINUM TUBING. THIS IS A VERY POOR DESIGN. APPARENTLY, CHEVY DOESN'T ACKNOWLEDGE THE PROBLEM.
DEX-COOL FAILURE IN MY CHEVROLET VORTEC V6 ENGINE.
THIS IS THE 2ND TIME THE HEAD GASKET GOES OUT ON MY TRUCK. DT
OIL COOLING LINES WERE REPLACED DUE TO DEFECTS PRIOR TO THIS BLOWOUT. DEFECTIVE PRODUCTS = NEXT PURCHASE TO BE A TOYOTA.*JB
MY TRUCK WAS UNDER WARRANTY WHEN I FIRST TOOK IT TO THE DEALER FOR REPAIRS, THEY DID NOT DIAGNOSE IT AT THAT TIME. REPAIR WAS DONE AFTER WARRANTY EXPIRED, DEALER DID NOT PAY. A RECALL WAS IN EFFECT FOR THE SAME ENGINE AND YEAR, BUT ONLY COVERED CARS, NOT PICKUP TRUCKS. BLOWN CYLINDER HEAD GASKET . NLM
Official recalls
599V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
96V195000 · Steering:gear Box:shaft Sector
Oct 8, 1996
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
95V180000 · Engine And Engine Cooling:cooling System:fan
Sep 22, 1995
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.