WIRING HARNESS: WAS DRIVING HOME AND SMOKE STARTED COMING OUT OF THE SIGNAL SWITCH. GOT THE VEHICLE HOME WITHOUT A FIRE. DROVE THE VEHICLE TO THE SHOP IN THE MORNING WITH THE SAME PROBLEM. WAS TOLD BY DEALER THAT WHEN THE WIRES AND SWITCH WERE PUT TOGETHER AT THE MANUFACTURER, THEY PUT GREASE ON THEM WHICH CAUSED THE WIRES TO …
Read full complaint
WIRING HARNESS: WAS DRIVING HOME AND SMOKE STARTED COMING OUT OF THE SIGNAL SWITCH. GOT THE VEHICLE HOME WITHOUT A FIRE. DROVE THE VEHICLE TO THE SHOP IN THE MORNING WITH THE SAME PROBLEM. WAS TOLD BY DEALER THAT WHEN THE WIRES AND SWITCH WERE PUT TOGETHER AT THE MANUFACTURER, THEY PUT GREASE ON THEM WHICH CAUSED THE WIRES TO MELT. *AK
NHTSA ODI #818578
Mileage unknown · Oct 16, 1996
Electrical SystemFire
ELECTRICAL SHORT IN THE TURN SIGNAL, CAUSING THE VEHICLE TO CATCH ON FIRE IN THE DASHBORAD. *AK
NHTSA ODI #803585
Mileage unknown · Aug 2, 1996
Electrical System
INSTRUMENT PANEL CLOSTER MODULE FAILURE. *AK
NHTSA ODI #506949
Mileage unknown · Apr 4, 1996
Electrical System
STARTER FAILS TO SHUT OFF EVEN AFTER KEY IS TURNED TO OFF POSITION. *SD
NHTSA ODI #503309
Mileage unknown · Nov 28, 1995
Electrical SystemFire
VEHICLE CAUGHT FIRE WHILE DRIVING, DUE TO THE ALTERNATOR FREEZING UP, TOTALLED. TT
NHTSA ODI #975622
Mileage unknown · Oct 2, 1995
Electrical System
ELECTRONIC MODULE THAT CONTROLS DASH BURNED OUT. TT
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence & remedy
Consequence: IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Remedy: INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
EA92015 · High Idle Flare
Opened May 22, 1992 · Closed May 28, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92001 · High Idle Flare
Opened Jan 7, 1992 · Closed May 22, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91057 · Headlight Switch Failure
Opened Mar 6, 1991 · Closed Jul 12, 1991
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
DP90006 · Lift Gate Falls Off
Opened Apr 13, 1990 · Closed Jul 24, 1990
Status: closed (inferred from source dates) · Unknown Or Other
LIFT GATE FALLS OFF
1989 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration