2001 Chevrolet Redundant Silverado 2500

EXTREME RUST, TAILGATE CABLES BROKE IN USE, HAD TO REPLACE. TAILGATE STILL WON'T LATCH PROPERLY, DROPPING OPEN WHILE DRIVING/HAULING FAIRLY OFTEN; BRAKE LINE RUSTED OUT, REPLACED BEFORE HAD ACCIDENT; WHOLE FRAME RUSTED - UNDER CARRIAGE//TIRE WELLS/DRIVE SHAFT/AROUND REECE HITCH SO I WORRY ABOUT PULLING TRAILER/HAILING. HORN HAS RUSTED OFF. ONLY 77,000 MILES AS I DO NOT DRIVE IT DAILY, JUST TO WORK AROUND MY PLACE OR PICKUP/HAUL/TRAILER SOMETHING. GM NEEDS RECALL TO ADDRESS THIS RUST ISSUE BECAUSE IT IS A MAJOR SAFETY ISSUE.

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500. WHILE DRIVING AT ANY SPEED, THE BRAKE LINES OFTEN FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKES NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED TWICE, BUT THE FAILURE RECURRED MANY TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. UPDATED 09/20/16*LJ *TR

THIS IS THE 5TH TIME MY BRAKES ARE HANGING UP AND OVER HEATING THE WHEEL. SMOKING SEVERLY. HAD PROBLEM WITH ABS. SYSTEM SO I UNPLUGGED SENSORS FROM FRONT WHEELS. AND ON THE 1ST THE RIGHT PASSENGER SIDE DID IT AGAIN. DOESN'T MATTER IF ON STATE HWY OR CITY STREETS. ALWAYS STARTS WHEN MOVING. A WOBBLE IN STEERING WHEEL. THEN PULLING RIGHT OR LEFT DEPENDING ON WHICH WHEEL IS LOCKING.

BRAKE LINES RUSTED OUT AND ALLOWED BRAKE FLUID TO LEAK OUT WHEN I APPLIED THE BRAKES. HAD VEHICLE TOWED TO CURRY AUTO IN BLOOMINGTON, IN FOR REPLACEMENT OF RUSTED BRAKE LINES. THIS HAPPENED A SECOND TIME ABOUT TWO MONTHS LATER WHEN ANOTHER ORIGINAL SET OF BRAKE LINES UNDER THE BED OF THE TRUCK RUSTED THROUGH AND CAUSED BRAKE FAILURE. BOTH TIMES I WAS DRIVING IN HILLY COUNTRY AND WAS FORTUNATE NOT TO CRASH INTO SOMETHING. DEALER SAID THAT THIS IS A COMMON PROBLEM WITH SILVERADO TRUCKS OF BRAKE LINES RUSTING OUT. I HAVE A 1996 BUICK ROADMASTER THAT HAS RUSTED OUT QUARTER PANELS AND THE BRAKE LINES ARE ORIGINAL.THIS TRUCK IS RUST FREE EXCEPT FOR THE BRAKE LINES. GM SHOULD PAY FOR THE REPLACEMENT OF THE BRAKE LINES ON THESE TRUCKS. *TR

BRAKE PEDAL WENT TO FLOOR AFTER LAUNCHING MY BOAT. FOUND THAT A BRAKE LINE HAD RUPTURED. GLAD IT DIDN'T HAPPEN WHILE I WAS ON THE ROAD WITH THE BOAT IN TOW. ALL BRAKES LINES WERE RUSTED AND I HAD THEM REPLACED FOLLOWING WEEK. VERY EXPENSIVE REPAIR. FOUND OUT THIS IS COMMON ON THESE VEHICLES. GM REALLY NEEDS TO FIX THIS ISSUE. *TR

ON THE WAY TO PICK UP SOME ITEMS FROM A RELATIVE THAT LIVED 42 MILES, APPROXIMATELY 32 MILES INTO THE TRIP IT WAS NOTICED THAT THE BRAKES WERE GETTING PROGRESSIVELY WORSE, WITHIN 4 MILES OF OUR DESTINATION, THE BRAKES WERE ALMOST NON-EXISTENT. FORTUNATELY, WE MADE IT, HOWEVER AS SOON AS WE PARKED AND TURNED THE ENGINE OFF, WE HEARD A POP AND LIQUID BEGAN SPRAYING FROM THE RIGHT SIDE OF THE FRONT GRILL NEAR THE HEADLIGHT. A VERY LARGE AMOUNT OF LIQUID THEN BEGAN POURING OUT OF THE RIGHT SIDE BY THE BUMPER AS WELL. ORIGINALLY WE BELIEVED IT TO BE COOLANT AS IT HAD A GREEN TINT TO IT, HOWEVER THIS DIDN'T EXPLAIN THE POOR BRAKE RESPONSE. WE THOUGHT PERHAPS THE BRAKE FLUID WAS LOW, AND CHECKED THE RESERVOIR. THE RESERVOIR HAD SOME STILL, BUT SHOWED LOW. WE ADDED SOME, BUT IT POURED OUT ALMOST AS FAST AS IT WENT IN. UPON FURTHER INVESTIGATION WE FOUND THE LEAK NOT TO BE COOLANT, BUT THE ACTUAL BRAKE LINES HAD BLOWN OUT DUE TO RUST, AND WHAT SPRAYED OUT WAS BRAKE FLUID MIXED WITH RUST. HAD THIS HAPPENED 20 MINUTES LATER, AFTER WE WOULD HAVE LOADED A LARGE AMOUNT OF BRICKS IN THE BED, AND WE HAD TO STOP SUDDENLY, THIS COULD HAVE BEEN DISASTROUS AND EVEN DEADLY. WE LEARNED ABOUT THIS SITE BY LOOKING ONLINE AND SEEING THE TENS OF THOUSANDS OF COMPLAINTS OF THE SAME THING - CHEVROLET SAVING A FEW DOLLARS AND USING STEEL FOR BRAKE LINES INSTEAD OF STAINLESS STEEL - A COST OF LESS THAN $40 PER VEHICLE (WE PRICED REPLACEMENTS AND THE STEEL WAS $195, WHILE STAINLESS STEEL WAS $233), AND NO WARNING TO CONSUMERS GIVEN EVEN AFTER THEY ACKNOWLEDGED PUBLICLY AND THE NHTSA INVESTIGATED, BUT DID NOTHING...SO MUCH FOR PROTECTING THE PUBLIC. IN ADDITION, WE HAD TO HAVE THE VEHICLE TOWED BACK TO OUR HOME. HOPEFULLY, NO ONE HAS TO DIE BEFORE THEY'RE FORCED TO INFORM ALL CURRENT OWNERS TO CHECK THEIR BRAKE LINES BECAUSE THEY CHOSE TO USE STEEL IN AN AREA OF THE COUNTRY KNOWN FOR STEEL RUSTING! *TR