The cable harness in question runs from the fuse box under hood through firewall to the passenger side foot area. At this point it connects to another harness that connects to various items at the rear of the vehicle. One circuit in particular the rear window defogger is burning wiring and socket and plug of the two wiring harn…
Read full complaint
The cable harness in question runs from the fuse box under hood through firewall to the passenger side foot area. At this point it connects to another harness that connects to various items at the rear of the vehicle. One circuit in particular the rear window defogger is burning wiring and socket and plug of the two wiring harness. Either the wiring or connectors burned apart without the circuit fuse blowing. The circuit has a 40amp fuse. The wiring harness for this circuit is 12 Garage. I can't find any manufacturer who recommends using 12 gauge wire on a 40 Amp circuit. This isn't even close to being correct. This is so agreegessly out of specification it would appear GM knew they had an issue with the circuit and fixed it By over fusing the circuit. This same issue on multiple models over several years.
NHTSA ODI #11576777
163,600 miles · Jul 9, 2012
Exterior Lighting
TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. WHILE PARKED, THE CONTACT ATTEMPTED TO ACTIVATE THE HAZARD LIGHTS SEVERAL TIMES HOWEVER THE LIGHTS WERE INOPERABLE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 163,600.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration