IllustrationPROBLEM WITH "NO POWER" WHICH CAUSED INOPERATIVE OPERATION TO THE VEHICLE. (NAR) *PH *CB
2002 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
3525–50K
2950–75K
2875–100K
36100–150K
21150K+
170 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports24 fire reports7 injury reports
What owners actually said
230 reportsLOWER COOLANT LIGHT COME ON BECAUSE OF POOR SEALANT OF THE LOWER INTAKE MANIFOLD. THIS RESULTED IN ANTI FREEZE LEAKING. *AK *MR
2002 MONTE CARLO SS STARTED: AT ABOUT 13000 MILES STARTED VIBRATING WHEN BRAKING. TOOK IT IN TO THE DEALERSHIP AT ABOUT 15000 MILES AND THEY SAID THE ROTORS NEEDED TO BE TURNED. I PAID FOR THAT TO BE DONE. AT ABOUT 28,000 AGAIN STARTED VIBRATING WHILE BRAKING. TOOK IT TO A BRAKE SPECIALIST AND HE SAID THE ROTORS NEEDED REP…
Read full complaint
2002 MONTE CARLO SS STARTED: AT ABOUT 13000 MILES STARTED VIBRATING WHEN BRAKING. TOOK IT IN TO THE DEALERSHIP AT ABOUT 15000 MILES AND THEY SAID THE ROTORS NEEDED TO BE TURNED. I PAID FOR THAT TO BE DONE. AT ABOUT 28,000 AGAIN STARTED VIBRATING WHILE BRAKING. TOOK IT TO A BRAKE SPECIALIST AND HE SAID THE ROTORS NEEDED REPLACING. CALLED THE DEALERSHIP AND THEY SAID THEY COULD NOT PAY FOR THIS TO BE DONE (NOT IN WARRANTY COVERAGE) SO WE HAD THE OUTSIDE SPECIALIST PUT ON ROTORS WITH A 50,000 MILE WARRANTY. I SEE MANY OTHER FOLKS HAVE THIS SAME PROBLEM. WHY DOES GM NOT COVER THIS? I THOUGHT WHEN I BOUGHT A NEW VEHICLE I WOULDN'T HAVE TO SINK MORE MONEY INTO REPAIRS UNTIL AFTER THE 36,000 WARRANTY WAS UP. HOPE GM STRAIGHTENS THIS OUT. I WAS LOOKING AT A USED 2001 GRAND AM FOR MY DAUGHTER BUT I SEE THERE ARE MANY OF THE SAME COMPLAINTS ON THAT VEHICLE. GUESS MY LIFE LONG RELATIONSHIP WITH GM VEHICLES IS BECOMING QUESTIONABLE? HOPE GM GETS THIS STRAIGHTENED OUT BEFORE THEY LOOSE OTHER DEVOTED GM FOLKS. *AK
2002 MONTE CARLO - AT 38000 MILES THIS WILL BE THE 2ND TIME THE BRAKE ROTORS ON THIS CAR NEED TO BE REPAIRED. THE FRONT END VIBRATES WHEN APPLYING BRAKES AT ANY SPEED. GM SERVICE DEALER ADVISED ME TO WAIT UNTIL THE PADS WERE WORN THIS TIME BEFORE REPAIRING ROTORS?????? THE CUSTOMER SERVICE REPRESENTATIVE I TALKED TO SUGGESTED TA…
Read full complaint
2002 MONTE CARLO - AT 38000 MILES THIS WILL BE THE 2ND TIME THE BRAKE ROTORS ON THIS CAR NEED TO BE REPAIRED. THE FRONT END VIBRATES WHEN APPLYING BRAKES AT ANY SPEED. GM SERVICE DEALER ADVISED ME TO WAIT UNTIL THE PADS WERE WORN THIS TIME BEFORE REPAIRING ROTORS?????? THE CUSTOMER SERVICE REPRESENTATIVE I TALKED TO SUGGESTED TAKING THE CAR TO A DIFFERENT DEALERSHIP FOR A 2ND OPINION????? IT IS UNACCEPTABLE THAT A HIGH PERFOMANCE CAR WOULD HAVE SUCH A DEFECT OR DESIGN PROBLEM. *AK
WHILE PARKED THE VEHICLE'S DRIVER SIDE AIR BAG DEPLOYED INADVERTENTLY. TWO WEEKS LATER THE PASSENGER SIDE AIR BAG DEPLOYED INADVERTENTLY WHILE DRIVING. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
I OWN A 2002 CHEVY MONTE CARLO. AT THE BEGINNING OF NOVEMBER 2003 THE QUAGES ON THE DASH BOARD (TACHOMETOR, SPEEDOMETOR, ABS LIGHT, AIR BAG LIGHT, CHECK ENGINE LIGHT ECT.) WOULD FLASH ON & OFF AND GUAGES WOULD SWEEP UP AND DOWN. ON NOVEMBER 9TH I STOP TO GET GAS AND SHUT THE CAR OFF. WHEN I GOT BACK IN THE CAR AND TURN IT ON THE…
Read full complaint
I OWN A 2002 CHEVY MONTE CARLO. AT THE BEGINNING OF NOVEMBER 2003 THE QUAGES ON THE DASH BOARD (TACHOMETOR, SPEEDOMETOR, ABS LIGHT, AIR BAG LIGHT, CHECK ENGINE LIGHT ECT.) WOULD FLASH ON & OFF AND GUAGES WOULD SWEEP UP AND DOWN. ON NOVEMBER 9TH I STOP TO GET GAS AND SHUT THE CAR OFF. WHEN I GOT BACK IN THE CAR AND TURN IT ON THE PASSANGER SIDE AIR BAG DEPLOYED. ON NOVEMBER 24TH WHILE I WAS DRIVING THE DRIVER AIR BAG DEPLOYED. I TOOK THE CAR BOTH TIME TO THE DEALER AND WAS TOLD BY GM THAT THEY WILL NOT FIX THE AIR BAGS. ABOUT A YEAR AGO I BUMPED A CAR IN FRONT OF ME WHILE STOP IN TRAFFIC AND IT MADE A 1 INCH CRACK IN MY BUMPER THE AIR BAGS DID NOT DEPLOY AT THAT TIME. GM STATES THE ACCIDENT THAT HAPPEN A YEAR AGO IS WHY THE AIR BAGS DEPLOYED IN NOVEMBER. THEY ADVISED ME TO CALL MY INSURANCE COMPANY. I TOOK THE CAR TO THE INSURANCE AND THEY CONFIRM THAT THE AIR BAG DEPLOYMENT WAS NOT CAUSE BY THE ACCIDENT. MY INSURANCE IS WORKING WITH ME TO GET GM TO TAKE RESPONSIBILTY FOR THE DEFECT. THEY ADVISED ME TO ALSO FILE A COMPLAINT WITH YOU.
I WAS TOLD TODAY THAT THE ROTORS HAVE TO BE TURNED AND THE BRAKES REPLACED..THIS IS NOW THE SECOND TIME THIS HAS BEEN DONE...ONE TIME IT WAS DONE ON A "IN SHOP REPAIR ORDER, NOT SENT TO GM" WHEN I QUESTIONED WHY IT WAS NOT BEING SENT TO GM I WAS TOLD IF THEY SEND IT TO GM THEN I HAVE TO PAY FOR THE BRAKE JOB. THERE HAVE BEEN SE…
Read full complaint
I WAS TOLD TODAY THAT THE ROTORS HAVE TO BE TURNED AND THE BRAKES REPLACED..THIS IS NOW THE SECOND TIME THIS HAS BEEN DONE...ONE TIME IT WAS DONE ON A "IN SHOP REPAIR ORDER, NOT SENT TO GM" WHEN I QUESTIONED WHY IT WAS NOT BEING SENT TO GM I WAS TOLD IF THEY SEND IT TO GM THEN I HAVE TO PAY FOR THE BRAKE JOB. THERE HAVE BEEN SEVERAL OTHER IN HOUSE REPAIRS CORRECTIONS MADE. WHEN I INQUIRED TO THE GENERAL MANAGER HE SAID THAT'S THE WAY IT IS DONE SO THEY GET THEIR MONEY. *NLM
2002 MONTE CARLO SS WITH STEERING SAFETY PROBLEMS STEERING COLUMN REPLACED FRONT END REPLACED STILL UNSAFE AND IN SHOP. RECALL CENTER SHOWS NO RECALLS FOR STEERING COLUMN DEALER SAYS THERE IS AND THERE HAVE BEEN REPORTS OF CRACKED FRAMES BUT THESE ARE JUST WHAT THEY CALLED "TECH BULLETINS FROM OTHER DEALER" THERE WAS ALSO A REC…
Read full complaint
2002 MONTE CARLO SS WITH STEERING SAFETY PROBLEMS STEERING COLUMN REPLACED FRONT END REPLACED STILL UNSAFE AND IN SHOP. RECALL CENTER SHOWS NO RECALLS FOR STEERING COLUMN DEALER SAYS THERE IS AND THERE HAVE BEEN REPORTS OF CRACKED FRAMES BUT THESE ARE JUST WHAT THEY CALLED "TECH BULLETINS FROM OTHER DEALER" THERE WAS ALSO A RECALL ON A COOLANT PROBLEM NOT LISTED. 1-160465811 CHEVY COMPLAINT NUMBER. *NLM
2002 MONTE CARLO : AT 29,000 MILES NEEDS ALL FRONT AND REAR BRAKE ROTORS RESURFACED DUE TO WARPING AND NEW BRAKE PADS. THIS WAS DESCRIBED TO US AS NORMAL AND NOT COVERED UNDER ANY WARRANTIES. VEHICLE IS DRIVEN MAJORITY OF TIME ON THE INTERSTATE HIGHWAY WHERE BRAKES ARE NOT NEEDED MUCH. IN ADDITION, WHEN TURNING A NOISE WAS HEAR…
Read full complaint
2002 MONTE CARLO : AT 29,000 MILES NEEDS ALL FRONT AND REAR BRAKE ROTORS RESURFACED DUE TO WARPING AND NEW BRAKE PADS. THIS WAS DESCRIBED TO US AS NORMAL AND NOT COVERED UNDER ANY WARRANTIES. VEHICLE IS DRIVEN MAJORITY OF TIME ON THE INTERSTATE HIGHWAY WHERE BRAKES ARE NOT NEEDED MUCH. IN ADDITION, WHEN TURNING A NOISE WAS HEARD/FELT IN STEERING WHEEL. G.M. DEALER SERVICE CENTER HAD TO REPLACE INNER STEERING SHAFT IN STEERING COLUMN? (THEIR DESCRIPTION) THIS WAS REPAIR UNDER WARRANTY. *LA
THE DRIVER INFORMATION CENTER-FUEL USED IS ALWAYS OFF AT LEAST 1.5 GALLONS WHEN FILLING THE TANK. THIS IN TURN CAUSES THE MILES PER GALLON TO ALSO BE OFF. ONE DEALER MECHANIC SAID THEY HAVE A PROBLEM WITH THE UNIT. BUT MY DEALER SAYS THIS IS NORMAL. WHEN ON A TRIP, MY BROTHERS TWO CADILLACS BOTH READ CORRECT FUEL USED. TH…
Read full complaint
THE DRIVER INFORMATION CENTER-FUEL USED IS ALWAYS OFF AT LEAST 1.5 GALLONS WHEN FILLING THE TANK. THIS IN TURN CAUSES THE MILES PER GALLON TO ALSO BE OFF. ONE DEALER MECHANIC SAID THEY HAVE A PROBLEM WITH THE UNIT. BUT MY DEALER SAYS THIS IS NORMAL. WHEN ON A TRIP, MY BROTHERS TWO CADILLACS BOTH READ CORRECT FUEL USED. THE GM 800 HELP LINE NEVER RETURNS MY CALLS. *LA
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.