IllustrationCAR PART RECALLED. GOT NOTICE IN JULY 09. CAR CAUGHT FIRE BECAUSE OF PART IN SEP 09. 2002 MONTE CARLO. I WAS TOLD THAT THE CAR'S WARRANTY HAD RUN OUT! PART WAS JUST RECALLED THIS YEAR. THEY JUST FOUND OUT THAT THE PART IS DEFECTIVE. DENIED CLAIM. 9 MO OLD AND 3 YR OLD IN CAR WHEN IT CAUGHT FIRE ON EXPRESSWAY. *TR
2002 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
3525–50K
2950–75K
2875–100K
36100–150K
21150K+
170 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports24 fire reports7 injury reports
Equipment complaints
5 reportsPOP IN STEERING AND CLUNK WHEN TURNING AT LOW SPEED. DEALERSHIP HAS REPLACED STEERING COLUMN, STEERING BOX, FRONT END AND ROTORS. HAVE SOLD THE VEHICLE TO INSURE THE SAFETY OF OUR FAMILY. *AK
2002 MONTE CARLO SS WITH STEERING SAFETY PROBLEMS STEERING COLUMN REPLACED FRONT END REPLACED STILL UNSAFE AND IN SHOP. RECALL CENTER SHOWS NO RECALLS FOR STEERING COLUMN DEALER SAYS THERE IS AND THERE HAVE BEEN REPORTS OF CRACKED FRAMES BUT THESE ARE JUST WHAT THEY CALLED "TECH BULLETINS FROM OTHER DEALER" THERE WAS ALSO A REC…
Read full complaint
2002 MONTE CARLO SS WITH STEERING SAFETY PROBLEMS STEERING COLUMN REPLACED FRONT END REPLACED STILL UNSAFE AND IN SHOP. RECALL CENTER SHOWS NO RECALLS FOR STEERING COLUMN DEALER SAYS THERE IS AND THERE HAVE BEEN REPORTS OF CRACKED FRAMES BUT THESE ARE JUST WHAT THEY CALLED "TECH BULLETINS FROM OTHER DEALER" THERE WAS ALSO A RECALL ON A COOLANT PROBLEM NOT LISTED. 1-160465811 CHEVY COMPLAINT NUMBER. *NLM
THESE ISSUES LISTED BELOW ARE TROUBLES I HAVE HAD WITH MY 2002 MONTE CARLO BOUGHT VEHICLE NEW 4/15/02 AND 21/02, FRONT BUMPER PAINT BEGAN TO PEEL. BUMPER REPAINTED./5/02 REAR SPEAKERS BEGIN TO CRACKLE AND QUIT WORKING. REPLACED./30/03 TOOK VEHICLE TO CHEVROLET GARAGE DUE TO VEHICLE PULSATING WHEN STOPPING AND THE CAR HAVIN…
Read full complaint
THESE ISSUES LISTED BELOW ARE TROUBLES I HAVE HAD WITH MY 2002 MONTE CARLO BOUGHT VEHICLE NEW 4/15/02 AND 21/02, FRONT BUMPER PAINT BEGAN TO PEEL. BUMPER REPAINTED./5/02 REAR SPEAKERS BEGIN TO CRACKLE AND QUIT WORKING. REPLACED./30/03 TOOK VEHICLE TO CHEVROLET GARAGE DUE TO VEHICLE PULSATING WHEN STOPPING AND THE CAR HAVING TROUBLE STARTING. FRONT AND REAR ROTORS FOUND WARPED AND RESURFACED. CARS FUEL PRESSURE REGULATOR FOUND TO BE LEAKING DOWN AND WAS REPLACED. 8/21/03 CAR PULSATING AGAIN WHEN STOPPING. RETURNED VECHICLE TO CHEVY GARAGE. FOUND REAR ROTORS RUSTED AGAIN AND REPLACED REAR ROTORS. WAS TOLD TIRES WERE CUPPING IN REAR. ROTATED TIRES ON 8/22/03 AND FOUND SCORE MARK ON REAR DRIVERS SIDE ROTOR. 8/22/03 RETURNED VEHICLE TO CHEVY GARAGE SHOWED SERVICE MANAGER THE DEFECT AND WAS TOLD THE PART WOULD NOT BE REPLACED AT THIS TIME EEVN THOUGH ROTOR WAS SCORED. S.MGR STATED THIS WAS NORMAL CONDITION DUE TO BRAKE PAD METALLIC LINING. 8/24/03 CONTACTED GM CUSTOMER SERVICE ABOUT ISSUE. ASKED TO HAVE NEW ROTORS AND BRAKES PUT ON VEHICLE. RESPONSE WAS "GM IS AWARE OF ISSUES WITH OUR BRAKES AND ROTORS, BUT IF THERE IS NO DEFECT THE PART WOULD NOT BE REPLACED." I RESTATED ABOUT THE SCORE MARK ON THE NEW ROTOR AND WAS TOLD SORRY NOTHING THEY COULD DO AT THIS POINT. 9/2/03 WHILE OIL WAS BEING CHANGED TWO BOLTS WHERE NOTICED MISSING FROM THE TRANSMISSION PAN. WILL BE SERVICED ON 9/4/03 REPAIR PENDING. 9/3/03 VEHICLE HAVING TROUBLE STARTING AGAIN. ENGINE HESITATES FOR 10-20 SEC. WILL BE ADDRESSED ON 9/4/03 THIS VEHICLE ONLY HAS 24,000 MILES ON IT. I NEED NEW BRAKE PADS AND NEW ROTORS DUE TO DEFECTS IN PARTS. VEHICLE HAS 7YR/100,000 MILE WARRANTY. DO I HAVE A LEMON?
MONTE CARLO SS 2002. CAR UNDER 12000 MILES NEEDED NEW BRAKE PADS, AND ROTORS RESURFACED. PREVIOUSLY HAD MALIBU 2000 THAT WAS BOUGHT BACK BY DEALER AFTER 2 YEARS OF ROTOR AND BRAKE PROBLEMS THAT CAUSED 2 CRASHES. WHEN IS SOMEBODY GOING TO LOOK AT THE DESIGN OF EQUIPMENT IN THESE VEHICLES TO SEE THERE IS A DEFECT. DEALERSHIP E…
Read full complaint
MONTE CARLO SS 2002. CAR UNDER 12000 MILES NEEDED NEW BRAKE PADS, AND ROTORS RESURFACED. PREVIOUSLY HAD MALIBU 2000 THAT WAS BOUGHT BACK BY DEALER AFTER 2 YEARS OF ROTOR AND BRAKE PROBLEMS THAT CAUSED 2 CRASHES. WHEN IS SOMEBODY GOING TO LOOK AT THE DESIGN OF EQUIPMENT IN THESE VEHICLES TO SEE THERE IS A DEFECT. DEALERSHIP EVEN ADMITTED TO FLAW. *NLM
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.