TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE ENGINE COMPARTMENT EXPLODED AND CAUGHT ON FIRE. THE CONTACT SUSTAINED INJURIES TO THE ACHILLES TENDON AFTER ATTEMPTING TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE VEHICLE WAS BEING DIAGNOSE…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE ENGINE COMPARTMENT EXPLODED AND CAUGHT ON FIRE. THE CONTACT SUSTAINED INJURIES TO THE ACHILLES TENDON AFTER ATTEMPTING TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE VEHICLE WAS BEING DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10583988
100,000 miles · Apr 1, 2014
EngineService BrakesSteering
I WAS DRIVING (WITH MY CHILDREN IN CAR) AND THE CAR JUST SHUT OFF. I HAD NO POWER BRAKES OR POWER STEERING. LUCKILY, ONE CHILD WAS IN DRIVERS ED & KNEW TO PUT CAR IN NEUTRAL & WE COASTED TO A STOP. ONCE I CALMED DOWN, I DROVE MY MONTE SS TO THE DEALER AND DESCRIBED WHAT HAPPENED. THE KEPT CAR FOR A WEEK AND INSISTED THERE WAS NO…
Read full complaint
I WAS DRIVING (WITH MY CHILDREN IN CAR) AND THE CAR JUST SHUT OFF. I HAD NO POWER BRAKES OR POWER STEERING. LUCKILY, ONE CHILD WAS IN DRIVERS ED & KNEW TO PUT CAR IN NEUTRAL & WE COASTED TO A STOP. ONCE I CALMED DOWN, I DROVE MY MONTE SS TO THE DEALER AND DESCRIBED WHAT HAPPENED. THE KEPT CAR FOR A WEEK AND INSISTED THERE WAS NOTHING WRONG! I DRIVE 1-3 HRS FOR WORK DAILY AND I DIDN'T TRUST THE VEHICLE ON INTERSTATE. I PURCHASED ANOTHER VEHICLE 6 DAYS LATER BUT GAVE THIS CAR TO MY CHILD FOR IN TOWN DRIVING. I WAS NEVER THE WISER UNTIL I HEARD ABOUT THE RECALL YESTERDAY & IT'S DESCRIPTION. THE MONTE SHOULD BE INVOLVED IN RECALL TOO. I WAS PREPARING TO PURCHASE A NEW IMPALA BUT NOW I BELIEVE GM IS STILL NOT BEING HONEST ABOUT ALL THE MAKES & MODELS INVOLVED WITH IGNITION PROBLEMS. *TR
NHTSA ODI #10576139
45,513 miles · Jan 31, 2014
EngineFuel System, GasolineFireInjury
WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS…
Read full complaint
WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS BLOW APART WITH MULTIPLE SENSORS DESTROYED. THANK GOD THIS HAPPENED AT HOME WITH AN EXTINGUISHER HANDY AND NOT DRIVING DOWN THE ROAD WITH NO TIME TO SLOW DOWN. *TR
NHTSA ODI #10562438
128,000 miles · Dec 27, 2013
Electrical SystemEngineExterior Lighting
MY 2002 CHEVY MONTE CARLO HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS SINCE I HAVE OWNED IT. THE CRUISE CONTROL COMES ON WITHOUT BEING SELECTED AND THEN THE HEATING/COOLING SYSTEMS GOES OFF AND ON BY ITSELF. THE TURN SIGNAL GOES ON AND OFF. SOMETIMES IT WILL WORK SOMETIMES IT WILL NOT. THE FUEL GAUGE DOES NOT REGISTER CORRECTLY G…
Read full complaint
MY 2002 CHEVY MONTE CARLO HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS SINCE I HAVE OWNED IT. THE CRUISE CONTROL COMES ON WITHOUT BEING SELECTED AND THEN THE HEATING/COOLING SYSTEMS GOES OFF AND ON BY ITSELF. THE TURN SIGNAL GOES ON AND OFF. SOMETIMES IT WILL WORK SOMETIMES IT WILL NOT. THE FUEL GAUGE DOES NOT REGISTER CORRECTLY GOES UP AND DOWN SO I AM NEVER SURE WHAT IS IN THE TANK. OCCASIONALLY THE CAR WILL NOT START AT ALL EVEN THOUGH THE LIGHTS WORK, THE RADIO PLAYS, AND EVERYTHING ELSE WILL OPERATE INSIDE THE CAR. I WILL SIT AND WAIT A WHILE. AFTER ABOUT 15-25 MINUTES I WILL TRY TO START IT AND THEN IT WILL START UP. THIS HAS BEEN HAPPENING MORE AND MORE. I HAVE TALKED TO OTHER CHEVY MONTE CARLO OWNER AND THEY HAVE HAD THE SAME PROBLEMS WITH THEIR CAR. *TR
NHTSA ODI #10557473
93,000 miles · Aug 10, 2013
Engine
THE PLASTIC INTAKE MANIFOLD CRACKED AND THE ANTIFREEZE WENT INTO THE OIL AND THE ENGINE BLEW UP IN THE MIDDLE OF RUSH HOUR TRAFFIC. *TR
NHTSA ODI #10534632
150,000 miles · Jun 5, 2013
Electrical SystemEngineFuel System, GasolineFire
I STARTED THE CAR UP AND I HEARD A POP AND SAW A BLUE FLAME. AFTER REPAIRING THE CAR COSTING $3240.74 IT ONCE AGAIN CAUGHT ANOTHER FIRE PLEASE HELP. *TR
NHTSA ODI #10515289
127,000 miles · Jan 23, 2013
EngineFire
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AS HE ATTEMPTED TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED WITHOUT WARNING. A FIRE ERUPTED AND THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS TOWED TO THE DEALER AND WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND LODGED A REPORT FO…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AS HE ATTEMPTED TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED WITHOUT WARNING. A FIRE ERUPTED AND THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS TOWED TO THE DEALER AND WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND LODGED A REPORT FOR THE FAILURE. THE FAILURE MILEAGE WAS 127,000.
NHTSA ODI #10494491
Mileage unknown · Sep 19, 2012
Electrical SystemEngine
I HAVE A 2002 MONTE CARLO SS I GO OUT TO START MY CAR AND IT WON'T START FOR ABOUT 15 MINUTES. THE SECURITY LIGHT COMES ON TO. WHEN I TURN THE KEY IT DOES NOTHING MY LIGHTS AND EVERYTHING WORK IT JUST WON'T START. IF THERE IS ANYWAY I COULD GET HELP PLEASE LET ME KNOW OR LET ME KNOW WHAT I CAN DO TO FIX THIS. THANK YOU! *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration