IllustrationShift to park error, No power to car, reduced engine power, camshaft positioning error, brakes failed (completely went hard unable to press) almost causing crash.
2020 Chevrolet Malibu
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Chevrolet Malibu do not stand out strongly from the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 45 of 198 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports0 fire reports5 injury reports
Power Train complaints
58 reportsThe contact owns a 2020 Chevrolet Malibu. The contact stated while driving 25 MPH, the odometer and tachometer readings were incorrect. The Services ESC, power steering, power steering assist, and check engine warning light illuminated. The vehicle was turned off and restated and operated normally; however, the check engine warn…
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated while driving 25 MPH, the odometer and tachometer readings were incorrect. The Services ESC, power steering, power steering assist, and check engine warning light illuminated. The vehicle was turned off and restated and operated normally; however, the check engine warning light remained illuminated. The contact stated that the steering wheel became stiff and the vehicle lost power brakes functionality. The vehicle was taken to an independent mechanic however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle needed to be diagnosed by an authorized dealer. The failure mileage was 65,000.
A few days ago, when I put the car in park and turned it off, there was a message on the screen saying "Shift to Park." It was in park. I could not get out of the car because it was still getting power. If I tried to lock the doors, it sounded the alarm. I had to turn the car on and off multiple times to get it to go away. It w…
Read full complaint
A few days ago, when I put the car in park and turned it off, there was a message on the screen saying "Shift to Park." It was in park. I could not get out of the car because it was still getting power. If I tried to lock the doors, it sounded the alarm. I had to turn the car on and off multiple times to get it to go away. It would've drained the battery if I'd left it. Who knows if it was really in park either. It's been doing it ever since. I called the dealer and they want $350 to fix it. The guy told me they've been seeing this on Malibu's and "now it's happening on the Traverse models, too." I've been reading online how this has been happening since at least 2016, but there is no recall. Why NOT?? This is dangerous and they're aware of the problem. They've issued service bulletins on how to fix it!
The shifter gear control/ shifter assembly keeps failing on and off. It’ll give me a warning shift to park. It did this while drive on a major highway then my car loss all power as I was in the second lane causing so much safety concerns. It is also alerting me when I’m in park now that I need to shift to park more frequently. E…
Read full complaint
The shifter gear control/ shifter assembly keeps failing on and off. It’ll give me a warning shift to park. It did this while drive on a major highway then my car loss all power as I was in the second lane causing so much safety concerns. It is also alerting me when I’m in park now that I need to shift to park more frequently. Extreme issue.
The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle would intermittently hesitate and stall with the traction control and check engine warning lights illuminated. Once the vehicle stalled, the contact had to wait a few minutes before successfully restarting the vehicle. …
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle would intermittently hesitate and stall with the traction control and check engine warning lights illuminated. Once the vehicle stalled, the contact had to wait a few minutes before successfully restarting the vehicle. The vehicle had been taken to the dealer on multiple occasions however, the mechanic was unable to duplicate or determine the cause of the failure. The contact had the pistons, battery terminal, transmission, and wiring harness replaced; however, the failure persisted after each repair. The manufacturer was notified of the failure and referred her to the NHTSA for assistance. The vehicle had yet to be repaired. The failure mileage was unknown.
I need my pistons and rings replaced. My car only has 57,000 miles. My car has been diagnosed with excessive piston blowby from 2 different independent service centers. Both times I have been to Chevy to get it fixed under warranty, they’ve charged me $200 for diagnostics each time and told me it is my PCV valve that needs fixed…
Read full complaint
I need my pistons and rings replaced. My car only has 57,000 miles. My car has been diagnosed with excessive piston blowby from 2 different independent service centers. Both times I have been to Chevy to get it fixed under warranty, they’ve charged me $200 for diagnostics each time and told me it is my PCV valve that needs fixed. I had them fix my PCV valve and I still have excessive piston blowby. Chevy just wants to keep bringing my car back in for more diagnostics. I have spoken with GM customer service 2 times and somehow every single time I give them my VIN they hang up. My car is a 2020 with only 57,000 miles on it. There’s absolutely no reason why I should need all new pistons and rings and why Chevy service centers won’t just get it done! I have diagnostic reports, receipts, and videos of everything.
1. Something under the car hood is making a whistle type noise. Is available for inspection. 2. I don't know if it is a safety risk. 3. The problem has not been confirmed by the dealer. 4. The vehicle was inspected by the dealership. 5. There were no warning lamps on or anything. The whistling appeared under the hoo…
Read full complaint
1. Something under the car hood is making a whistle type noise. Is available for inspection. 2. I don't know if it is a safety risk. 3. The problem has not been confirmed by the dealer. 4. The vehicle was inspected by the dealership. 5. There were no warning lamps on or anything. The whistling appeared under the hood around May 23,2021. 6. The whistling appears under the hood of the car after driving it approximately 30mins with the air conditioner on. 7. I took it to the dealership and they seem resistant to fix the problem!
The vehicle will randomly shut off while driving. All warning lights light up on the dash and notification of "reduced steering" pops up. Taken to the dealership and has been there for 19 business days. They will fix a component, I have picked it up twice and it has shut off before I could even get home forcing me to tow it back…
Read full complaint
The vehicle will randomly shut off while driving. All warning lights light up on the dash and notification of "reduced steering" pops up. Taken to the dealership and has been there for 19 business days. They will fix a component, I have picked it up twice and it has shut off before I could even get home forcing me to tow it back. This last time they were bringing the car around and it shut off in their own parking lot before they could even give me the keys. Every time they run diagnostics it's a new code. Vehicle is unsafe to drive due to shut-off and loss of steering.
Official recalls
121V649000 · Seat Belts:critical Fasteners; Seat Belts:rear/other:retractor
Aug 20, 2021
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA25005 · Dtn Air Bag Inflator Rupture
Opened Oct 21, 2025 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these crashes sustained serious or fatal injuries that appear linked to the ruptures. Six of those drivers sustained fatal injuries and two sustained severe injuries. In all eight incidents, the subject inflators had been installed as replacement equipment after the vehicle was involved in a previous crash. Information gathered during NHTSA’s initial analysis of these incidents indicates that the inflators were potentially imported illegally into the United States. In conjunction with this safety investigation, NHTSA is also working with appropriate authorities to address any illegal activities associated with the importation of these inflators. As a result of the significant safety concerns relating to these inflators, as well as extensive information already obtained by ODI relating to their field ruptures, ODI is moving directly to the Engineering Analysis (EA) stage of its investigative process rather than first opening a Preliminary Evaluation. NHTSA has taken a variety of actions to address the risks posed by the importation of substandard or counterfeit air bag components. However, until recently, these risks appeared spread across a variety of components and manufacturers. As part of ODI’s continuous monitoring of this issue, the agency has obtained information to suggest that at least eight incidents involve ruptures of inflators manufactured by DTN. In parallel with this dedicated investigation into DTN inflators, ODI will continue to monitor reports of field incidents to evaluate risks from other substandard imported air bag components. In 2012, ODI first became aware of substandard or counterfeit air bag modules sold through online marketplaces, such as auction sites. NHTSA obtained examples of these air bag modules and conducted testing. None of the inflators equipped in these modules were manufactured by DTN. This testing revealed that the inflators consistently malfunctioned during deployments, such as by failing to deploy the air bag or expelling metal shrapnel due to a rupture. This led NHTSA to release a consumer advisory in October 2012 to alert the public and repair professionals to the potential dangers of substandard or counterfeit air bag modules. ODI also worked with major vehicle manufacturers, who released advisories and notifications concerning the use of such air bag modules. Since then, NHTSA has continuously monitored for reports of malfunctioning air bags that may be associated with substandard or counterfeit components. These monitoring efforts have been supported by the increased visibility the advisories have brought to the issue, and by several standing general orders in place as part of separate investigations into Takata and ARC inflators, which require certain manufacturers to report any alleged or suspected inflator field ruptures to NHTSA. Until 2017, ODI was not aware of any field incidents involving an abnormal deployment of an imported substandard or counterfeit air bag module. In September 2017, ODI became aware of a crash involving a model year (MY) 2009 Honda Civic where the air bag ruptured during deployment, killing the driver. After inspecting the vehicle and air bag parts, ODI determined that the air bag inflator was not original equipment and that the air bag module was likely a substandard import. Insufficient information existed to determine the manufacturer of the inflator in this incident, however, it does not appear to resemble those manufactured by DTN. On June 16, 2023, ODI received a Vehicle Owner Questionnaire (VOQ #11527380) alleging that the rupture of a driver side air bag caused fatal injuries to the driver of a MY 2020 Chevrolet Malibu. ODI’s assessment of the rupture indicated that the air bag inflator was not original equipment but was instead manufactured by DTN, a Chinese company (also known as Yoshibayashi Toku theanol Automotive Safety Systems Co. Ltd.). From June 2023 to July 2024, ODI became aware of four additional ruptures involving substandard air bag modules equipped on Chevrolet Malibu vehicles. At the time, insufficient information existed for these crashes to determine who manufactured the ruptured inflators. As a result, NHTSA released a consumer advisory on July 10, 2024, alerting car buyers and owners to be aware of cheap, substandard replacement air bag inflators that can cause death or serious injury in a crash. The advisory urged consumers who own or are considering the purchase of a used vehicle to learn the vehicle’s history and ensure the vehicle has genuine air bag inflators. In March 2025, NHTSA learned about another rupture involving a suspected substandard, aftermarket inflator that was equipped in a MY 2017 Hyundai Sonata. The driver of this vehicle sustained fatal injuries that appeared related to the rupture. In August 2025, NHTSA received a similar report of a fatal air bag rupture in a MY 2019 Hyundai Sonata. Most recently, in October 2025, ODI received a report of a fatal air bag rupture in a MY 2020 Chevrolet Malibu. Photographs of the air bag components in these three crashes indicated that the ruptures all involved inflators manufactured by DTN. Further investigation of the inflator fragments in three of the prior incidents confirmed that they also involved DTN inflators. Photographs of the components involved in one of the other incidents also strongly suggest that the ruptured inflator was manufactured by DTN. This opening resume exceeded space limitations and is continued in an attachment uploaded to the investigation.