IllustrationVehicle will say shift to park and also can't use the limp mode and manually shift gears and also can't be used outside of 1st and 2nd gear
2020 Chevrolet Malibu
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Chevrolet Malibu do not stand out strongly from the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 45 of 198 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports0 fire reports5 injury reports
Power Train complaints
58 reportsMy vehicle will not shut off. It states "shift to park". Sometimes it takes 30 minutes of trying to get the car to shut off. Since this began, we were on a road trip, it's causing issues with accelerating on the highway & I believe it's damaging the transmission. 2020 Chevy Malibu had other models under recall for this same rea…
Read full complaint
My vehicle will not shut off. It states "shift to park". Sometimes it takes 30 minutes of trying to get the car to shut off. Since this began, we were on a road trip, it's causing issues with accelerating on the highway & I believe it's damaging the transmission. 2020 Chevy Malibu had other models under recall for this same reason. I called Chevy dealership & they said they cannot help me. They told me to contact General Motors. I have a [XXX] baby, I'm [XXX] & lost my job after maternity leave. This should be resolved as it's causing me anxiety to drive it with my child in the car. Please help me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the vehicle stalled prior to accelerating. Additionally, the check engine warning light was illuminated. The v…
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the vehicle stalled prior to accelerating. Additionally, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed with power train control module failure. The contact was informed that the power train control module needed to be replaced. The contact was advised to contact the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall campaign; however, the VIN was not included. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 77,765.
The contact owns a 2020 Chevrolet Malibu. The contact stated while the vehicle was parked, the shift to park error message was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but did not assist. The contact was advised to contact the NH…
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated while the vehicle was parked, the shift to park error message was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but did not assist. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 68,000.
The contact owns a 2020 Chevrolet Malibu. The contact stated while driving at approximately 25 MPH, the vehicle stalled. The contact stated no warning light was illuminated. Additionally, the contact stated that while shifting into park(P), the vehicle rolled backward before the contact could shift the vehicle into park(P). The …
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated while driving at approximately 25 MPH, the vehicle stalled. The contact stated no warning light was illuminated. Additionally, the contact stated that while shifting into park(P), the vehicle rolled backward before the contact could shift the vehicle into park(P). The contact had taken the vehicle to a local dealer, where it was diagnosed; however, the contact stated that she was not notified of what had been repaired. The contact stated that the failure reoccurred. The contact drove the vehicle back to the same dealer. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.
Car is indicating "Shift to Park" after placing in park and turning off. Unable to lock vehicle. Lights remain on. Took vehicle to dealer though it's a widely known issue I will be required to pay? Transmission was replaced at 35K due to manufacturing defect. Every 20k miles I'm going to have more transmission issues? It's…
Read full complaint
Car is indicating "Shift to Park" after placing in park and turning off. Unable to lock vehicle. Lights remain on. Took vehicle to dealer though it's a widely known issue I will be required to pay? Transmission was replaced at 35K due to manufacturing defect. Every 20k miles I'm going to have more transmission issues? It's just not right!
I was driving down the road and the car started slowing down and even when I would give it gas wouldn’t accelerate. After pullling over and allowing the cars behind me to pass I tried to pull back out into traffic and the car would not engage into gear. When giving the car gas it didn’t move. I shifted the transmission into park…
Read full complaint
I was driving down the road and the car started slowing down and even when I would give it gas wouldn’t accelerate. After pullling over and allowing the cars behind me to pass I tried to pull back out into traffic and the car would not engage into gear. When giving the car gas it didn’t move. I shifted the transmission into park and tried shifting into every gear including reverse and the car wouldn’t go anywhere I had to sit in the road for about 20 minutes then the car shift very hard into drive and began accelerating. Now when trying to drive it every time it stalls out either when first trying to back up or take off or decelerates while driving down the road making me fearful for my life due to being hit from behind sue to no notice or warning before the car decelerates
The contact owns a 2020 Chevrolet Malibu. The contact stated while the vehicle was parked, the contact attempted to exit the vehicle; however, the shift to park message was displayed on the instrument panel. The Push to Start button was illuminated. The vehicle was driven back to the residence. A dealer was not contacted. The ve…
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated while the vehicle was parked, the contact attempted to exit the vehicle; however, the shift to park message was displayed on the instrument panel. The Push to Start button was illuminated. The vehicle was driven back to the residence. A dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not under recall and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 51,000.
engine misfire, shift to park and transmission
The contact owns a 2020 Chevrolet Malibu. The contact stated that the vehicle was parked and while attempting to turn off the vehicle, the message "Shift to Park" was displayed. The contact shifted out of park(P) and shifted back to park(P) several times until vehicle responded as needed. Additionally, the contact stated that th…
Read full complaint
The contact owns a 2020 Chevrolet Malibu. The contact stated that the vehicle was parked and while attempting to turn off the vehicle, the message "Shift to Park" was displayed. The contact shifted out of park(P) and shifted back to park(P) several times until vehicle responded as needed. Additionally, the contact stated that the failure recurred while her daughter had attempted to turn off the vehicle while the vehicle was parked. The contact's daughter was unable to successfully shift to park(P) and allowed the vehicle to turn off independently after a while. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 56,000.
Official recalls
121V649000 · Seat Belts:critical Fasteners; Seat Belts:rear/other:retractor
Aug 20, 2021
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence & remedy
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Additional source detail variants (2)
Seat Belts:rear/other:retractor
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
Consequence: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA25005 · Dtn Air Bag Inflator Rupture
Opened Oct 21, 2025 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these crashes sustained serious or fatal injuries that appear linked to the ruptures. Six of those drivers sustained fatal injuries and two sustained severe injuries. In all eight incidents, the subject inflators had been installed as replacement equipment after the vehicle was involved in a previous crash. Information gathered during NHTSA’s initial analysis of these incidents indicates that the inflators were potentially imported illegally into the United States. In conjunction with this safety investigation, NHTSA is also working with appropriate authorities to address any illegal activities associated with the importation of these inflators. As a result of the significant safety concerns relating to these inflators, as well as extensive information already obtained by ODI relating to their field ruptures, ODI is moving directly to the Engineering Analysis (EA) stage of its investigative process rather than first opening a Preliminary Evaluation. NHTSA has taken a variety of actions to address the risks posed by the importation of substandard or counterfeit air bag components. However, until recently, these risks appeared spread across a variety of components and manufacturers. As part of ODI’s continuous monitoring of this issue, the agency has obtained information to suggest that at least eight incidents involve ruptures of inflators manufactured by DTN. In parallel with this dedicated investigation into DTN inflators, ODI will continue to monitor reports of field incidents to evaluate risks from other substandard imported air bag components. In 2012, ODI first became aware of substandard or counterfeit air bag modules sold through online marketplaces, such as auction sites. NHTSA obtained examples of these air bag modules and conducted testing. None of the inflators equipped in these modules were manufactured by DTN. This testing revealed that the inflators consistently malfunctioned during deployments, such as by failing to deploy the air bag or expelling metal shrapnel due to a rupture. This led NHTSA to release a consumer advisory in October 2012 to alert the public and repair professionals to the potential dangers of substandard or counterfeit air bag modules. ODI also worked with major vehicle manufacturers, who released advisories and notifications concerning the use of such air bag modules. Since then, NHTSA has continuously monitored for reports of malfunctioning air bags that may be associated with substandard or counterfeit components. These monitoring efforts have been supported by the increased visibility the advisories have brought to the issue, and by several standing general orders in place as part of separate investigations into Takata and ARC inflators, which require certain manufacturers to report any alleged or suspected inflator field ruptures to NHTSA. Until 2017, ODI was not aware of any field incidents involving an abnormal deployment of an imported substandard or counterfeit air bag module. In September 2017, ODI became aware of a crash involving a model year (MY) 2009 Honda Civic where the air bag ruptured during deployment, killing the driver. After inspecting the vehicle and air bag parts, ODI determined that the air bag inflator was not original equipment and that the air bag module was likely a substandard import. Insufficient information existed to determine the manufacturer of the inflator in this incident, however, it does not appear to resemble those manufactured by DTN. On June 16, 2023, ODI received a Vehicle Owner Questionnaire (VOQ #11527380) alleging that the rupture of a driver side air bag caused fatal injuries to the driver of a MY 2020 Chevrolet Malibu. ODI’s assessment of the rupture indicated that the air bag inflator was not original equipment but was instead manufactured by DTN, a Chinese company (also known as Yoshibayashi Toku theanol Automotive Safety Systems Co. Ltd.). From June 2023 to July 2024, ODI became aware of four additional ruptures involving substandard air bag modules equipped on Chevrolet Malibu vehicles. At the time, insufficient information existed for these crashes to determine who manufactured the ruptured inflators. As a result, NHTSA released a consumer advisory on July 10, 2024, alerting car buyers and owners to be aware of cheap, substandard replacement air bag inflators that can cause death or serious injury in a crash. The advisory urged consumers who own or are considering the purchase of a used vehicle to learn the vehicle’s history and ensure the vehicle has genuine air bag inflators. In March 2025, NHTSA learned about another rupture involving a suspected substandard, aftermarket inflator that was equipped in a MY 2017 Hyundai Sonata. The driver of this vehicle sustained fatal injuries that appeared related to the rupture. In August 2025, NHTSA received a similar report of a fatal air bag rupture in a MY 2019 Hyundai Sonata. Most recently, in October 2025, ODI received a report of a fatal air bag rupture in a MY 2020 Chevrolet Malibu. Photographs of the air bag components in these three crashes indicated that the ruptures all involved inflators manufactured by DTN. Further investigation of the inflator fragments in three of the prior incidents confirmed that they also involved DTN inflators. Photographs of the components involved in one of the other incidents also strongly suggest that the ruptured inflator was manufactured by DTN. This opening resume exceeded space limitations and is continued in an attachment uploaded to the investigation.