IllustrationI HAVE HAD TO CHANGE MY HEADLIGHT OVER 10 TIMES THIS YEAR. EVERY MODEL OF THIS CAR I SEE DRIVING HAS THE SAME ISSUE.
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
What owners actually said
906 reportsI KEEP HAVING TO CHANGE MY HEADLIGHTS ON BOTH SIDES WAY TOO FREQUENTLY AND IT'S WAY TOO EXPENSIVE TO KEEP REPLACING THEM IT HAS GOT TO BE SOMETHING WRONG HERE!!!!
WHILE IN MOTION CAR JERKS AND ALMOST STALLS. ROUGH IDLE AGAIN JERKING AND ALMOST STALLING. SERVICE ESC / SERVICE TRACTION /ENGINE LIGHT COME ON. IF CAR IS NOT USED FOR A FEW DAYS, WARNING LIGHT WILL NOT COME ON. THEN ABOUT 30 MILES INTO DRIVE LIGHTS COME ON AND CONDITION DESCRIBED ABOVE OCCUR. THIS IS A VERY DANGEROUS CONDITIO…
Read full complaint
WHILE IN MOTION CAR JERKS AND ALMOST STALLS. ROUGH IDLE AGAIN JERKING AND ALMOST STALLING. SERVICE ESC / SERVICE TRACTION /ENGINE LIGHT COME ON. IF CAR IS NOT USED FOR A FEW DAYS, WARNING LIGHT WILL NOT COME ON. THEN ABOUT 30 MILES INTO DRIVE LIGHTS COME ON AND CONDITION DESCRIBED ABOVE OCCUR. THIS IS A VERY DANGEROUS CONDITION.
THE FRONT PASSENGER SIDE LOW BEAM LIGHT KEEPS GOING OUT. I CHANGED THE LIGHT ABOUT 3 MONTHS AGO AND IT'S OUT AGAIN. NO BUMPS, ACCIDENTS, NOTHING. ITS JUST GOES OUT.
AS I WAS DRIVING IN IN CHICAGO INTERSTATE 94 DOING ABOUT 60MPH THE MOTOR JUST STOPPED RUNNING THE STEERING WAS HARD I HAD DIFFICULTY GOING TO THE SHOLDER THERE WAS NO WARNING LIGHTS LIKE IF I JUST TURNED THE SWITCH TO OFF AFTER I GOT TO THE SHOLDER THE CAR JUST DIDN'T WANT TO START..I CALLED MY MECHANIC HE SAID TRY TO REBOO…
Read full complaint
AS I WAS DRIVING IN IN CHICAGO INTERSTATE 94 DOING ABOUT 60MPH THE MOTOR JUST STOPPED RUNNING THE STEERING WAS HARD I HAD DIFFICULTY GOING TO THE SHOLDER THERE WAS NO WARNING LIGHTS LIKE IF I JUST TURNED THE SWITCH TO OFF AFTER I GOT TO THE SHOLDER THE CAR JUST DIDN'T WANT TO START..I CALLED MY MECHANIC HE SAID TRY TO REBOOT THE PC. UNPLUG THE BATTERY. I DID THE CAR STARTED BUT STARTED WITH A TICKING NOISE. IN THE ENGINE I CANCELLED MY PLAN TURNED AROUND STARTED TO GO HEME 20 MINUTES LATER ON THE SAME INTERSTATE 94 THE CAR DID IT AGAIN THIS TIME ALL THE WARNING LIGHTS CAME ON. BUT TJIS TIME IT WAS HARDER TO STEER THE CAR ...CAN YOU IMAGINE DRIVING IN THE FREEWAY WITH YOUR FAMILY ON BOARD NEXT TO SEMI TRUCKS AND YOUR CAR JUST STOPS RESPONDING.....I THING THIS PROBLEM SHOULD BE LOOKED AT BEFORE A DEADLY ACCIDENT HAPPENS.
WHILE DRIVING ON THE HIGHWAY AT 55 MPH, SERVICE ECS LIGHT CAME ON, REDUCED POWER WARNING LIGHT CAME ON AND CAR CAME TO A FULL STALL.
WHILE DRIVING I NOTICED MY LIGHTS SHOWING ENGINE POWER REDUCED FROM MY UNDERSTANDING THIS IS THE THROTTLE POSITION SENSOR.
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT SMOKE ENTERED THE VEHICLE NEAR THE FRONT OF THE DASHBOARD. THE CONTACT INSPECTED THE AREA AND NOTICED THAT THE FAILURE WAS NOT COMING FROM THE AREA OF THE ENGINE, BUT RATHER THERE WAS A STRONG ODOR OF BURNING WIRES. THE DEALER WAS NOT CONTACTED FOR DIAGNOSTIC …
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT SMOKE ENTERED THE VEHICLE NEAR THE FRONT OF THE DASHBOARD. THE CONTACT INSPECTED THE AREA AND NOTICED THAT THE FAILURE WAS NOT COMING FROM THE AREA OF THE ENGINE, BUT RATHER THERE WAS A STRONG ODOR OF BURNING WIRES. THE DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO SCHEDULE AN APPOINTMENT WITH OURISMAN CHEVROLET OF BOWIE (16610 GOVERNOR BRIDGE RD, BOWIE, MD 20716, (301) 262-7600) FOR DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
THE CAR TELLS ME TO SERVICE ESC AND TO SERVICE TRACTION. WHEN THE CAR IS IN CRUISE CONTROL THE BRAKE DOES NOT DISENGAGE CRUISE CONTROL.
WHILE DRIVING DOWN THE HIGHWAY THE CHIMES STARTED DINGING AND THE CABIN FILLED UP WITH SMOKE THE AIRBAG LIGHT CAME ON AFTER PULLING OVER IT WAS DISCOVERED THAT THE FRONT SEAT BELTS WERE LOCKED IN THE WEARING POSITION
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.