IllustrationPASSENGER LOW BEAM LIGHT KEEPS GOING OUT HAVE REPLACED 3 TIME WORKS FOR A COUPLE DAYS THEN GOES OUT AGAIN. VERY COSTLY WHEN YOU HAVE TO TAKE WHOLE BUMPER OFF TO REPLACE. HAVE SEEN MANY OTHER COMPLAINTS ON MALIBU'S WITH SAME ISSUES.
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Exterior Lighting complaints
202 reportsPASSENGER LOW BEAM HEADLIGHT KEEPS FAILING EVERY COUPLE OF MONTHS THIS IS A BIG PROBLEM WITH ALL CHEVY MALIBUS. DRIVER SEAT BACK BREAKS AND CAUSES THE SEAT TO BE UNSAFE.
HEADLIGHTS CONTINUE TO BURN OUT REGULARLY (REQUIRING REPLACEMENT OF BULTS MULTIPLE TIMES PER YEAR) AND THE WIRING HARNESS CONTINUES TO MELT. BECAUSE OF THE DESIGN OF THE CAR, THE WHOLE FRONT BUMPER HAS TO BE PULLED OFF TO GET ACCESS TO LIGHT TO REPLACE--OFTEN AT A HIGH COST AT THE REPAIR SHOP. THIS IS UNSAFE,AS THE FREQUENCY OF …
Read full complaint
HEADLIGHTS CONTINUE TO BURN OUT REGULARLY (REQUIRING REPLACEMENT OF BULTS MULTIPLE TIMES PER YEAR) AND THE WIRING HARNESS CONTINUES TO MELT. BECAUSE OF THE DESIGN OF THE CAR, THE WHOLE FRONT BUMPER HAS TO BE PULLED OFF TO GET ACCESS TO LIGHT TO REPLACE--OFTEN AT A HIGH COST AT THE REPAIR SHOP. THIS IS UNSAFE,AS THE FREQUENCY OF THE BURNOUTS RESULT IN HAVING TO DRIVE WITH BRIGHTS ON AT NIGHT WHEN BOTH LIGHTS UNEXPECTEDLY GO OUT. READING THE MANUAL, THE DRL REDUCES THE VOLTAGE TO THE LOW BEAMS, WHICH DRIVES UP THE AMPS CAUSING THE EXTRA HEAT TO MELT THE WIRING HARNESS. THIS IS A DESIGN FLAW THAT NEEDS TO BE REMEDIATED BY A RECALL.
PASSENGER SIDE HEADLIGHT( LOW BEAM) CONTINUES TO GO OUT AFTER BEING REPLACED SEVERAL TIMES IN A SHORT AMOUNT OF TIME, 2-3 WEEKS.
CFDL7KTJ TNN YNYBYNYMBYRCRCRCRCRCRYVNUJYCDDEYHYBDEVGYVTU62O6AFNTSJTANTAJATNRHDHRJRMSTMZVSG NO RAHSFJSYKTASGKYSKYWJWYJGSNTABRAGARHYSKTAJTANTKSYJFSMYSKTAJFANTQHETQRKYWKTANSGKYWHSGNFAHTWK6SRJTAJTSJWTJTWJ51U5WJTWJTWJTWJWTNWTNWTNTW
MY 2012 CHEVY MALIBU PASSENGER HEADLIGHT HAS GONE OUT 4 TIMES IN A YEAR AND A HALF. IT IS REDICULOUS THAT IT COSTS A MINIMUM OF 80.00 TO HAVE THIS WORK DONE AND IT IS A SAFETY HAZARD BECAUSE THE OWNER CANNOT PERFORM THE BULB REPLACEMENT WITHOUT REMOVING THE ENTIRE FRONT OF THE CAR.
AT 1ST MY CAR WOULDN'T CRANK EVERY SO OFTEN THEN STARTED GOING DRAG WHILE DRIVING I GOOGLED IT AND HAD TO BEAT ON FUSEBOX IN TRUNK OR WIGGLE WIRES SO HAD TO RUN WIRE STRAIGHT TO BATTERY TO FUEL PUMP. MY HEADLIGHTS ON DIM KEEP SHOOTING AND MY SPEAKERS WILL GO OUT SOMETIMES
TAKATA RECALL WHEN I'M DRIVING MY VEHICLE, THE HEADLIGHTS FLICKER AS IF I'M THE POLICE. I TOOK IT TO FIRESTONE AND THEY TOLD ME TO TAKE IT TO A DEALER THE CAR ONLY HAS 160,000+ AND IT JUST STARTED EVERY TIME I ACCELERATE OR DRIVE IT DOES THIS AND I'M AFRAID THAT I WILL EITHER GET PULLED OVER BY THE POLICE, HIT SOMEONE OR SOM…
Read full complaint
TAKATA RECALL WHEN I'M DRIVING MY VEHICLE, THE HEADLIGHTS FLICKER AS IF I'M THE POLICE. I TOOK IT TO FIRESTONE AND THEY TOLD ME TO TAKE IT TO A DEALER THE CAR ONLY HAS 160,000+ AND IT JUST STARTED EVERY TIME I ACCELERATE OR DRIVE IT DOES THIS AND I'M AFRAID THAT I WILL EITHER GET PULLED OVER BY THE POLICE, HIT SOMEONE OR SOMEONE HITS ME OR/AND THE LIGHTS GO COMPLETELY OUT WHILE DRIVING AT NIGHT. IS THIS DUE BECAUSE WHENEVER YOU HAVE TO CHANGE THE BUILD, THE WHOLE BUMPER HAS TO COME OFF TO REPLACE IT? I LIKE MY CAR BUT THIS IS A SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED. I SEE A LOT OF COMPLAINTS REGARDING THIS
I HAVE A 2012 CHEVY MALIBU. THUS IS MY EVERYDAY VEHICLE AND WHEN I HAVE HEADLIGHT PROBLEMS IT IS VERY FRUSTRATING. WE HAVE HAD THE BUMPER OFF THIS CAR MULTIPLE TIMES WHICH IS A REAL PAIN. WE HAVE CHANGED HEADLIGHTS, WIRING HARNESS AND EVEN UNDOING THE BATTERY. THE PASSENGER LIGHT COMES ON FOR A BIT THEM WILL GO OFF AND NOT COME …
Read full complaint
I HAVE A 2012 CHEVY MALIBU. THUS IS MY EVERYDAY VEHICLE AND WHEN I HAVE HEADLIGHT PROBLEMS IT IS VERY FRUSTRATING. WE HAVE HAD THE BUMPER OFF THIS CAR MULTIPLE TIMES WHICH IS A REAL PAIN. WE HAVE CHANGED HEADLIGHTS, WIRING HARNESS AND EVEN UNDOING THE BATTERY. THE PASSENGER LIGHT COMES ON FOR A BIT THEM WILL GO OFF AND NOT COME BACK ON. I HAVE A LOAN ON THIS CAR AND CAN'T EVEN GET RID OF IT CAUSE I CAN'T KEEP THE LIGHTS ON. WORSE CHEVY CAR I HAVE EVER OWNED. I HAVE BEEN PULLED OVER FOR IT BEING OUT AND HOW AM I SUPPOSED TO EXPLAIN IT. READING THE REVIEWS OF THIS CAR ONLINE I AM NOT THE ONLY PERSON THAT HAS HEADLIGHT PROBLEMS.
PASSENGER HEAD LIGHT HAS BEEN REPLACED SEVERAL TIMES IT KEEPS TURNING OFF. LIGHT BULB IS NOT BURNED. WHEN TAPING ON OR MOVING WIRES LIGHT GOES ON REPLACED WIRES AND STILL HAVING SAME ISSUE. VEHICLE CAN NOT BE DRIVEN AT NIGHT TIME. ALL THIS HAPPENS WHEN VEHICLE IS TURNED ON.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.