IllustrationHEADLIGHTS AND HIGH BEAMS KEEP GOING OUT GOT THE CHANGED 6 TIMES IN LESS THAN 4 MONTHS CAME BACK ON ONE TIME WHEN I HAD THE ANTI THEFT PROBLEM AND HAD TO JUMP MY CAR BUT THEN BACK TO BEING OUT AGAIN
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Exterior Lighting complaints
202 reportsTHE LOW-BEAM HEADLIGHTS KEEP BURNING OUT. A MELTED SOCKET WAS THE FIRST ISSUE. IT WAS REPAIRED A MONTH AGO AND NOW THE SAME PROBLEM IS AGAIN AT PLAY. THERE MUST BE AN ELECTRICAL SHORT. THIS IS A COMMON PROBLEM WITH THESE VEHICLES THAT MANY HAVE REPORTED. IT COSTS DEARLY TO HAVE A MECHANIC TAKE APART THE FRONT OF THE VEHICLE …
Read full complaint
THE LOW-BEAM HEADLIGHTS KEEP BURNING OUT. A MELTED SOCKET WAS THE FIRST ISSUE. IT WAS REPAIRED A MONTH AGO AND NOW THE SAME PROBLEM IS AGAIN AT PLAY. THERE MUST BE AN ELECTRICAL SHORT. THIS IS A COMMON PROBLEM WITH THESE VEHICLES THAT MANY HAVE REPORTED. IT COSTS DEARLY TO HAVE A MECHANIC TAKE APART THE FRONT OF THE VEHICLE AND WORK ON THE LIGHTS SINCE YOU MUST TAKE OFF THE WHOLE FRONT BUMPER TO ACCESS THE HEADLIGHTS. I HAVE PAID FOR REPAIR AND BULB REPLACEMENT ALREADY IN THE PAST 2 MONTHS. TO SEE IT HAPPENING AGAIN IS VERY DISCOURAGING.
MY 2012 CHEVY MALIBU PASSENGER SIDE LOW BEAM HAS GONE OUT FOR THE SECOND TIME IN LESS THAN A YEAR. AFTER DOING SOME RESEARCH, I FOUND THIS IS A COMMON ISSUE FOR THE CHEVY MALIBU. ENTRIES STATING SIMILAR ISSUES SPECIFICALLY EFFECTING THE SAME PASSENGER SIDE LOW BEAM, TOTALED MORE THAN 300 ON CARPROBLEMZOO.COM THIS IS NOT ONLY A…
Read full complaint
MY 2012 CHEVY MALIBU PASSENGER SIDE LOW BEAM HAS GONE OUT FOR THE SECOND TIME IN LESS THAN A YEAR. AFTER DOING SOME RESEARCH, I FOUND THIS IS A COMMON ISSUE FOR THE CHEVY MALIBU. ENTRIES STATING SIMILAR ISSUES SPECIFICALLY EFFECTING THE SAME PASSENGER SIDE LOW BEAM, TOTALED MORE THAN 300 ON CARPROBLEMZOO.COM THIS IS NOT ONLY A MONETARY ISSUE, NOT ONLY A RESOURCE ISSUE, BUT A SIGNIFICANT RISK TO OPERATOR AND BYSTANDER SAFETY. IF GM DOES NOT ACKNOWLEDGE THEY HAVE SUPPLIED A FAULTY PRODUCT, AS DESCRIBED BY THE HUNDREDS OF COMPLAINTS LISTED ONLINE, THEY ARE COMPLICIT TO ANY ACCIDENTS OR INJURY CAUSED BY THEIR LACK OF ACTION AND CONCERN. MY OWN EXPERIENCE HAS BEEN FRIGHTENING, NOTICING A LACK OF POWER AFTER I'M ALREADY ON THE ROAD, ONLY SEEING ONE LIGHT FROM MY CAR REFLECTING ON ANOTHER CAR OR SURFACE. THE GENERAL PUBLIC TAKES GREAT CARE TO MAKE SURE THEIR VEHICLES CAN BOTH SAFELY OPERATE AND TRANSPORT THEMSELVES AND OTHERS. WITH THIS DAMAGED PART IN CHEVY'S MALIBU, MAKING GREAT STRIDES FOR A SAFE VEHICLE COULD BE FOR NOTHING IF THE LIGHT DOES NOT DO ITS JOB. WITH THIS IN MIND, PLEASE CONSIDER THE CLIMATE WE LIVE IN TODAY. THE DIFFERENCE BETWEEN A FAULTY HEADLIGHT, AND A RELIABLE LIGHT, COULD MEAN LIFE OR DEATH NOT ONLY FOR THOSE ON THE ROAD, BUT FOR POC, TARGETED BY POLICE, FOR A FAULTY HEADLIGHT. IN 2015, DARRIUS STEWART WAS A PASSENGER IN A 2009 CHEVY MALIBU. HE UNJUSTLY LOST HIS LIFE TO A POLICE OFFICER AFTER THE DRIVER WAS PULLED OVER FOR WHAT DO YOU ASK? A HEADLIGHT OUT. DARRIUS STEWART. GENERAL MOTORS- RECALL. HTTP://CHNG.IT/RPXWYMBW9V
HEADLIGHTS REPEATEDLY GO OUT, EVEN AFTER CHANGING THE LOW BEAM LIGHTS ALMOST EVERY MONTH. LOW BEAMS WILL RANDOMLY GO ON AND OFF, STATIONARY OR IN MOVEMENT. I LIVE IN THE CITY, MOST TIMES DRIVING IN DARKNESS. VERY DANGEROUS.
THE LEFT HEADLIGHT DOESN'T GET POWER. THE LOW BEAMS TO BE EXACT. BUT NOW BOTH LOW BEAMS AREN'T GETTING POWER. THE RADIO DOESN'T GET POWER EITHER. I BELIEVE IT'S A FAULTY WIRE HARNESS. PLEASE RECALL THIS VEHICLE. THE LIGHTS GO OUT AT RANDOM TIMES BOTH MOVING AND STATIONARY. IT'S UNCONTROLLABLE, ALSO VERY UNSAFE FOR WHO EVER IS IN…
Read full complaint
THE LEFT HEADLIGHT DOESN'T GET POWER. THE LOW BEAMS TO BE EXACT. BUT NOW BOTH LOW BEAMS AREN'T GETTING POWER. THE RADIO DOESN'T GET POWER EITHER. I BELIEVE IT'S A FAULTY WIRE HARNESS. PLEASE RECALL THIS VEHICLE. THE LIGHTS GO OUT AT RANDOM TIMES BOTH MOVING AND STATIONARY. IT'S UNCONTROLLABLE, ALSO VERY UNSAFE FOR WHO EVER IS IN THE VEHICLE. *TR
UPON STARTING MY VEHICLE, THE LEFT LOWBEAM HEADLIGHT WAS OUT, I TAPPED ON THE CAR NEXT TO THE LIGHT AND IT CAME BACK ON, THE NEXT DAY I STARTED MY VEHICLE IT WAS OUT AGAIN BUT WOULDN'T WORK AFTER TAPPING, GOT IT REPAIRED BUT LESS THAN A MONTH IT WENT OUT AGAIN ALONG WITH THE RIGHT SIDE, THEY REPAIRED IT BY INSTALLING MULTI PURPO…
Read full complaint
UPON STARTING MY VEHICLE, THE LEFT LOWBEAM HEADLIGHT WAS OUT, I TAPPED ON THE CAR NEXT TO THE LIGHT AND IT CAME BACK ON, THE NEXT DAY I STARTED MY VEHICLE IT WAS OUT AGAIN BUT WOULDN'T WORK AFTER TAPPING, GOT IT REPAIRED BUT LESS THAN A MONTH IT WENT OUT AGAIN ALONG WITH THE RIGHT SIDE, THEY REPAIRED IT BY INSTALLING MULTI PURPOSE CONNECTORS AND NOW THE LEFT LOW BEAM HEADLIGHT IS OUT AGAIN, THIS IS GETTING WAY TOO PRICEY AND TIME CONSUMING. *TR
REPEATEDLY FIXING LOW BEAM HEADLIGHT. PASSENGER SIDE FIRST NOW BOTH LOW BEAM HEADLIGHTS. SWITCHED TO LOW BEAM ON SECONDARY ROAD TO HAVE NO LIGHTS. PITCH DARK. *TR
PASSENGER SIDE HEADLIGHT INTERMITTENTLY GOES OUT FOR NO APPARENT REASON. THE VEHICLE COULD BE STATIONARY OR IN MOTION AND IT DOES NOT MATTER. SOMETIMES THE LIGHT WILL GO OUT AND BACK ON WHEN MOVING OVER A BUMPY ROAD. *TR
PASSENGER SIDE LOW BEAM HEADLIGHT GOES OUT INTERMITTENTLY. BULB IS NOT BURNT OUT. HAVE REPLACED COMPLETE HARNESS, USUALLY SOLVES PROBLEM FOR A MONTH OR SO AND THEN LIGHT GOES OUT AGAIN. HAVE CHANGED GROUNDING ALSO BUT PROBLEM STILL PERSISTS. THIS IS A DANGEROUS PROBLEM AND HAVE BEEN PULLED OVER BY POLICE FOR 'BURNT OUT' HEADLIGH…
Read full complaint
PASSENGER SIDE LOW BEAM HEADLIGHT GOES OUT INTERMITTENTLY. BULB IS NOT BURNT OUT. HAVE REPLACED COMPLETE HARNESS, USUALLY SOLVES PROBLEM FOR A MONTH OR SO AND THEN LIGHT GOES OUT AGAIN. HAVE CHANGED GROUNDING ALSO BUT PROBLEM STILL PERSISTS. THIS IS A DANGEROUS PROBLEM AND HAVE BEEN PULLED OVER BY POLICE FOR 'BURNT OUT' HEADLIGHT SEVERAL TIMES NOW AND HAVE TO EXPLAIN HOW IT IS A VEHICLE FLAW, NOT A BAD BULB. I KNOW I'M NOT THE ONLY ONE EXPERIENCING THIS ISSUE, IT IS ALL OVER THE INTERNET WITH OTHERS HAVING THE SAME EXACT PROBLEM.
I HAVE HAD THE SAME PROBLEM FOR MONTHS NOW. MY HEADLIGHT (BOTH SIDES AT DIFFERENT TIMES) KEEP GOING OUT. I'VE PROBABLY CHANGED MY HEADLIGHTS AT LEAST 6 TIMES IN THE PAST 6 MONTHS. I'VE HAD THE HEADLIGHT HARNESS CHANGED AS WELL BECAUSE THAT BURNED OUT. 2 MONTHS LATER THE NEW ONE BURNED OUT!!! I'VE READ SO MANY COMPLAINTS ABOUT…
Read full complaint
I HAVE HAD THE SAME PROBLEM FOR MONTHS NOW. MY HEADLIGHT (BOTH SIDES AT DIFFERENT TIMES) KEEP GOING OUT. I'VE PROBABLY CHANGED MY HEADLIGHTS AT LEAST 6 TIMES IN THE PAST 6 MONTHS. I'VE HAD THE HEADLIGHT HARNESS CHANGED AS WELL BECAUSE THAT BURNED OUT. 2 MONTHS LATER THE NEW ONE BURNED OUT!!! I'VE READ SO MANY COMPLAINTS ABOUT THE SAME ISSUE, CHEVY NEEDS TO DO SOMETHING ABOUT THIS. I'M SO SICK OF BUYING HEADLIGHTS, HARNESSES, AND PAYING FOR SERVICE!! ITS NOT LIKE YOU JUST POP THE HEADLIGHT IN ON THIS STUPID CAR.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.