IllustrationI HAVE REPLACED MY HEADLIGHTS MULTIPLE TIMES THIS YEAR ALREADY AND NOTICED AND FEW TIMES A HEADLIGHT WOULD GO OUT THEN COME ON OCCASIONALLY THEN IT JUST GOES OUT PERMANENTLY UNTIL A REPAIR IS MADE
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Exterior Lighting complaints
202 reportsTL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE DRIVER SIDE HEADLIGHT SHUT OFF. THE FAILURE OCCURRED SEVERAL TIMES AND THE HEADLIGHT BULB WAS REPLACED ON SEVERAL DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE DRIVER SIDE HEADLIGHT SHUT OFF. THE FAILURE OCCURRED SEVERAL TIMES AND THE HEADLIGHT BULB WAS REPLACED ON SEVERAL DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 25,000.
TAKATA RECALL. PASSENGER HEADLIGHT HAS BEEN CHANGE 6 TIMES AND CONTINUES TO GO OUT. I WAS TOLD MY WIRES WERE FINE. I CAN'T SEEM TO FIND THE PROBLEM.
MISFIRE CYL #1 AND ENG LT. WITH MISFIRE CODE, ATTEMPTED CHEV DEALER WARRANTY REPAIR WITH REMOVAL OF CYL HEAD AND REPLACEMNT VALVES [THE CHEAP FIX INSTEAD OF REPLACING CYL HEAD, IN RETROSPECT I BELIEVE CHEV SHOULD HAVE REPLACED THE CYL HEAD FOR A PERMANENT REPAIR, NOW THE CAR IS OUT OF 100K POWERTRAIN WARRANTY] BUT RECURRENCE 22K…
Read full complaint
MISFIRE CYL #1 AND ENG LT. WITH MISFIRE CODE, ATTEMPTED CHEV DEALER WARRANTY REPAIR WITH REMOVAL OF CYL HEAD AND REPLACEMNT VALVES [THE CHEAP FIX INSTEAD OF REPLACING CYL HEAD, IN RETROSPECT I BELIEVE CHEV SHOULD HAVE REPLACED THE CYL HEAD FOR A PERMANENT REPAIR, NOW THE CAR IS OUT OF 100K POWERTRAIN WARRANTY] BUT RECURRENCE 22K MILES LATER. I SUSPECT A DESIGN FLAW. ITERNET SHOWS MANY OWNERS WITH SAME COMPLAINT. TRACTION CONTROL LIGHT CONTINUES TO COME OFF AND ON.
THE LOW BEAM AND RUNNING LIGHTS ON DRIVER'S SIDE KEEP GOING OUT THE WIRING HARNESS AND BULB HAS BEEN CHANGED 5 TIMES NOW AND STILL GOES OUT EVER OTHER WEEK . AND TO TOP IT OFF THIS CAR HAS THE MOST REDICULOUS WAY TO GET AT THE HEADLIGHTS. SO TIME CONSUMING
THE PASSENGER SIDE LOW BEAM LIGHT BURNS OUT OR STOPS WORKING FREQUENTLY. IT HAS BEEN CHANGED MORE THAN THREE TIMES. RECENTLY, IT WAS CHANGED ON FEBRUARY 17, 2018 AND STOPPED WORKING ON FEBRUARY 25, 2018.
HEADLIGHT LAMP CONSTANTLY GOES OUT DESPITE CHANGING OUT THE BULB AND/OR THE FUSE MULTIPLE TIMES. IT IS BECOMING A HAZARD WHEN DRIVING ON THE ROADS.
BOTH HEADLAMPS HAVE GONE OUT WITHIN A NINE MONTH PERIOD. THE DRIVER SIDE HAS BEEN CHANGED TWICE, THE PASSENGER SIDE ONCE. IT SEEMS EVERY THREE MONTHS A HEADLIGHT BURNS OUT ON MY CAR. AS FOR THE WIPERS, WHEN THEY ARE TURNED ON, THEY SWIPE HALFWAY AND STOP UNTIL I TURN THEM OFF AND BACK ON OR TO A HIGHER SWIPING SPEED. THIS HAS HA…
Read full complaint
BOTH HEADLAMPS HAVE GONE OUT WITHIN A NINE MONTH PERIOD. THE DRIVER SIDE HAS BEEN CHANGED TWICE, THE PASSENGER SIDE ONCE. IT SEEMS EVERY THREE MONTHS A HEADLIGHT BURNS OUT ON MY CAR. AS FOR THE WIPERS, WHEN THEY ARE TURNED ON, THEY SWIPE HALFWAY AND STOP UNTIL I TURN THEM OFF AND BACK ON OR TO A HIGHER SWIPING SPEED. THIS HAS HAPPENED AS THE VEHICLE WAS IN PARK AND DRIVE. ALSO, THE KEY FOB BATTERY HAS BEEN REPLACED TWICE AND WORKS SELDOMLY. THE LOCKS HAVE RECENTLY STARTING LOCKING ON THEIR OWN AFTER THE VEHICLE IS SHUT OFF AND THE DRIVER DOOR IS SHUT.
HEADLAMPS CONSTANTLY BURNING OUT FUZES BLOWN DANGEROUS WHEN LIGHTS GO OUT AT NIGHT. SAFETY HAZARD.
MY HEADLIGHTS KEEP GOING OUT, MY CAR WILL NOT ALIGN AND THE ELECTRICAL PLUG WILL NOT WORK
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.