IllustrationCHANGED MY HEADLIGHTS 4 TIMES WITHIN 2 YEARS
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Exterior Lighting complaints
202 reportsTHE PASSENGER SIDE HEADLIGHT KEEPS GOING OUT I'M CHANGING THESE OUT EVERY COUPLE MONTHS I'VE RESEARCHED AND FOUND SEVERAL OTHER DRIVERS ARE HAVING THIS SAME ISSUE
MY PASSENGER LOW BEAM KEEPS GOING OUT THIS IS THE THIRD TIME IN A YEAR AND A HALF
THE LOW BEAM HEADLIGHT ON THE PASSENGER CONTINUOUSLY GOES OUT AFTER REPAIRING. I HAD THE BULB REPLACED 3 TIMES, WITHIN A MONTHS TIME. I ENDED UP GETTING AN EXPENSIVE DIAGNOSTIC TEST, REPLACED THE SOCKET, AS SUGGESTED. SHORTLY THEREAFTER, THE BULB WENT OUT AGAIN. REPLACED, THEN IT WENT OUT AGAIN. I DROVE AROUND WITH MY HIGH BEAM …
Read full complaint
THE LOW BEAM HEADLIGHT ON THE PASSENGER CONTINUOUSLY GOES OUT AFTER REPAIRING. I HAD THE BULB REPLACED 3 TIMES, WITHIN A MONTHS TIME. I ENDED UP GETTING AN EXPENSIVE DIAGNOSTIC TEST, REPLACED THE SOCKET, AS SUGGESTED. SHORTLY THEREAFTER, THE BULB WENT OUT AGAIN. REPLACED, THEN IT WENT OUT AGAIN. I DROVE AROUND WITH MY HIGH BEAM ON (SO I CAN SEE) UNTIL I BURNT THAT OUT TOO. I JUST GOT IT REPLACED AND NOT EVEN A WEEK LATER IT'S OUT AGAIN. I CAN'T CONTINUE PAYING FOR THIS DEFECT. CAN SOMEONE PLEASE ADVISE OF RESOLUTION? I SEE THAT THIS IS A PROBLEM WITH A LOT OF THE OWNERS OF THIS VEHICLE. PLEASE HELP.
LOW BEAM HEADLIGHTS KEEP GOING OUT. THIS IS SEPT 18 AND I'VE REPLACED THE RIGHT SIDE 4 TIMES THIS YEAR AND THE LEFT 2 TIMES. AT THE MOMENT THE LEFT IS OUT. I'VE CONTACTED THE DEALERSHIP AND THE DIAGNOSTIC CHARGE IS $130. THE ONLY THING ABOUT IT IS PAYING $130 TO TELL ME WHAT'S WRONG AND GOING IN BLIND NOT KNOWING HOW MUCH IT WIL…
Read full complaint
LOW BEAM HEADLIGHTS KEEP GOING OUT. THIS IS SEPT 18 AND I'VE REPLACED THE RIGHT SIDE 4 TIMES THIS YEAR AND THE LEFT 2 TIMES. AT THE MOMENT THE LEFT IS OUT. I'VE CONTACTED THE DEALERSHIP AND THE DIAGNOSTIC CHARGE IS $130. THE ONLY THING ABOUT IT IS PAYING $130 TO TELL ME WHAT'S WRONG AND GOING IN BLIND NOT KNOWING HOW MUCH IT WILL COST TO REPAIR. I'VE BEEN WATCHING TO SEE IF THERE WILL BE A RECALL ISSUED ON THIS. I LOVE MY CAR AND DON'T WANT TO HAVE TO GET RID OF IT. IT'S PAID FOR AND I ONLY HAVE $118K MILES. THANK YOU
FREQUENTLY, MORE THAN 6 TIMES IN A YEAR HEADLIGHTS BURNOUT PT QUIT WORKING. SEE THERE ARE NUMEROUS OTHERS WITH SAME PROBLEM
FIRST MY PASSENGER SIDE HEADLIGHT WENT OUT SO I REPLACED THE BULB AND THE NEXT DAY IT WASN'T WORKING AGAIN. NOW MY DRIVER SIDE HEADLIGHT IS ALSO GOING IN AND OUT WITHOUT THE BULBS BURNING OUT. THE LIGHTS HAVE GONE OUT WHILE RIDING AND WHILE STATIONARY, SOMETIME THERE ON WHEN I PARK THE CAR AND OFF WHEN I CRANK IT BACK UP AGAIN.
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S LOW BEAM HEADLAMPS FAILED TO OPERATE. JEFF WYLER SPRINGFIELD CHEVROLET (2237 W FIRST STREET, SPRINGFIELD, OH) DIAGNOSED THAT THE WIRING HARNESS HAD MELTED AND RECOMMENDED IT BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S LOW BEAM HEADLAMPS FAILED TO OPERATE. JEFF WYLER SPRINGFIELD CHEVROLET (2237 W FIRST STREET, SPRINGFIELD, OH) DIAGNOSED THAT THE WIRING HARNESS HAD MELTED AND RECOMMENDED IT BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 93,000.
THE FRONT HEADLAMP CONSTANTLY GOES OUT. THIS IS THE 4TH REPLACEMENT IN A YEAR.
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHTS FAILED TO OPERATE EVERY THREE MONTHS. THE VEHICLE WAS TAKEN TO VALENTI AUTO SALES (399 N COLONY ST, WALLINGFORD, CT 06492, 203-774-4035) WHERE IT WAS DIAGNOSED, BUT NO FAILURE COULD BE FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHTS FAILED TO OPERATE EVERY THREE MONTHS. THE VEHICLE WAS TAKEN TO VALENTI AUTO SALES (399 N COLONY ST, WALLINGFORD, CT 06492, 203-774-4035) WHERE IT WAS DIAGNOSED, BUT NO FAILURE COULD BE FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.