Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

Exterior Lighting complaints

202 reports

Clear category filter

55,000 miles · Mar 19, 2019

Exterior Lighting

Read full complaint

MY DIM HEADLIGHT KEEPS BURNING OUT AND I KEPT HAVING TO CHANGE MY BULBS. TO COME TO FIND OUT IT WAS MY WIRING HARNESS AND I'VE HAD TO CHANGE IT TWICE. MY BRIGHT LIGHTS DO GOOD. IT'S JUST THE DIM LIGHTS. PLEASE RECALL THIS. IT'S A HEADACHE TRYING TO FIX THIS PROBLEM ONCE OR TWICE A MONTH. I'VE ALSO READ THAT SEVERAL OTHER PEOPLE'S CHEVY MALIBUS HEADLIGHTS ARE MESSING UP TOO. EVERYTIME I PASS A MALIBU ONE OF THE HEADLIGHTS ARE BURNED OUT. PLEASE FIX THIS PROBLEM. THANK YOU.

NHTSA ODI #11190133

90,000 miles · Mar 14, 2019

Electrical SystemExterior LightingVisibility/wiper

DRIVER SIDE HEADLIGHT MALFUNCTIONING MULTIPLE TIMES IN PAST YEAR. HEAD LIGHT WILL GO OUT, AT FIRST COULD TAP ON HEAD LIGHT AND IT WOULD COME BACK ON. HAVE CHANGED PIGTAIL AND BULBS ONLY TO HAVE IT WORK FOR A SHORT PERIOD OF TIME.

NHTSA ODI #11186955

123,000 miles · Mar 12, 2019

Exterior Lighting

PASSENGER SIDE LOW BEAM GOES OUT EVERY COUPLE DAYS TO 2 WEEKS. BULB AND WIRE HARNESS HAS BEEN REPLACED AND ONLY CORRECTED THE ISSUE FOR A SHORT TIME.

NHTSA ODI #11186224

Mileage unknown · Mar 6, 2019

Electrical SystemExterior Lighting

Read full complaint

LOW BEAM HEADLIGHT GOING OUT. I PURCHASED THIS VEHICLE IN 2014 AND MY LOW BEAM HEADLIGHTS HAVE GONE OUT A TOTAL OF 6 TIMES. CHANGED THE PIGTAILS LAST TIME AND IAM NOW HAVING TO CHANGE THE WIRING HARNESS COMPLETELY AND HOPEFULLY THAT WILL HELP. MY CARS LIGHTS ARE ALWAYS ON AUTO AND ALWAYS BEGINS WITH MY PASSANGER LOW BEAM LIGHT GOING OUT FIRST THEN THE DRIVER SIDE A COUPLE MONTHS AFTER, HAS HAPPENED WHEN TURNING ON THE VEHICLE AND DURING DRIVING. MY HIGH BEAMS WORK FINE WITH NO PROBLEMS AT ALL. THE FIRST TWO TIMES I HAVE HAD A PROFFESIONAL MECHANIC CHANGE THEM AND THE LAST COUPLE TIMES I'VE CHANGED THEM MYSELF NOW DUE TO COST. REMOVING THE WHOLE BUMPER REALLY MAKES THIS EVEN MORE DIFFICULT TO CHANGE. I HAVE READ MANY FORUMS AND THEY HAVE ALSO THE SAME PROBLEM, ITS ACTUALLY BECOME VERY COMMON TO SEE MANY CHEVY'S WITH A HEAD LIGHT OUT. I JUST WANT TO MAKE SURE THIS IS NOTED CAUSE IT APPEARS TO BE A COMMON PROBLEM WITH THIS VEHICLE COMPANY. PLEASE HELP!

NHTSA ODI #11184485

Mileage unknown · Mar 2, 2019

Electronic Stability Control (esc)Exterior LightingService Brakes

WARNING ON DASHBOARD SERVICE TRACTION CONTROL WHEN APPLYING THE BRAKES. BRAKE LIGHTS DOES NOT COME ON WHEN THE SERVICE TRACTION CONTROL COME ON. THERE HAS BEEN A RECALL ON THIS ISSUE PREVIOUSLY AND ISSUE STILL OCCURRING.

NHTSA ODI #11183608

Mileage unknown · Mar 1, 2019

Electrical SystemExterior Lighting

MY LOW BEAM HEADLIGHTS WILL NOT WORK. I HAVE CHANGED BULBS ONLY TO FIND OUT IT WASNT THE BULBS...THEY STILL WORK. I HAVE CHANGED ONE OF THE PIGTAILS AND IT WORKED FOR A WHILE AND STOPPED WITHIN A MONTH. IT STARTED WITH ONLY THE RIGHT HEADLIGHT AND NOW IT IS BOTH.

NHTSA ODI #11183556

87,000 miles · Feb 28, 2019

Electrical SystemExterior Lighting

TAMARA RECALL MY LOW BEAMS LIGHTS KEEP GOING OUT AND ON, IT DOES THIS WHEN PARK, AND DRIVING THEY WORK SOMETIMES ONE OR THE OTHER SOMETIMES THEY WON’T COME ON AT ALL.

NHTSA ODI #11183282

180,000 miles · Feb 25, 2019

Exterior Lighting

Read full complaint

ON APPROXIMATELY WEDNESDAY 2/20/2019 AND AT 3 POINTS IN 2018 A HEADLIGHT WENT OUT ON MY 2012 CHEVY MALIBU. ON 2/24/18 I RECEIVED A TICKET FOR IT. BUT THE ONLY REASON I DID AND THE 0NLY REASON A KEY SAFETY FEATURE WAS DISABLED FOR SO LONG IS DUE TO A DESIGN FLAW BY CHEVY. YOU HAVE TO REMOVE APPROX 30 BOLTS AND THE ENTIRE FRONT CLIP OF THE VEHICLE TO CHANGE A HEADLIGHT. THIS DESIGN FLAW NOT ONLY DISENFRANCHISES PEOPLE BUT ALSO MAKES THE ROAD LESS SAFE DUE TO THE FACT THE AVERAGE NON MECHANICALLY INCLINED PERSON WOULD LIKELY GO TO A MECHANIC AND USUALLY WAIT TO DO THAT BECAUSE OF THE COSTS. I THINK RATHER THAN FINE THEM. ISSUE A RECALL FOR THE TICKETS PEOPLE HAVE GOTTEN BECAUSE OF THEM IN ADDITION TO MAKING THEM OFFER FREE SERVICE ON HEADLIGHT CHANGES. MAYBE THEY WON'T DO STUPID STUFF THAT ENDANGERS THE ROAD AGAIN IF THEY HAVE TO PAY EVERY SINGLE PETTY LITTLE TICKET.

NHTSA ODI #11182393

Mileage unknown · Feb 23, 2019

Exterior Lighting

BOTH HEADLIGHT GO OUT. REPLACED THE BULB 5 TIMES LAST YEAR AND 1 TIME THIS YEAR. IF I AM DRIVING MY CAR AND HIT A BUMP THE LIGHT WILL TURN OFF OR IF IT IS OFF IT WILL TURN ON.

NHTSA ODI #11182165

36,000 miles · Feb 19, 2019

Electrical SystemExterior Lighting

THE LOW BEAM HEADLIGHTS ON BOTH SIDES OF THE CAR ARE CONSTANTLY GOING OUT. I HAVE TO REPLACE THEM 3-4 TIMES A YEAR. I SPEND HUNDREDS OF DOLLARS ON HEADLAMPS, EVEN THOUGH I INSTALL THEM MYSELF. INSTALLING NEW HEADLAMPS REQUIRES YOU TO REMOVE THE FRONT BUMPER. THERE IS AN OBVIOUS DESIGN FLAW WITH THE HUNDREDS OF COMPLAINTS I …

Read full complaint

NHTSA ODI #11181043

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)