Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

Electrical System complaints

290 reports

Clear category filter

60,000 miles · Jan 27, 2022

Electrical SystemExterior Lighting

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving, the brake light was illuminated. The contact stated that at the time she was not depressing the brake pedal. The contact stated that when she was switching gears from either drive or reverse the brake light only illuminates once in gear and does not turn off. The contact also stated that the traction control warning light also illuminates while driving, however the vehicle does not drive any differently. The vehicle was taken to an independent mechanic who advised her that there was a recall on the same year, make and model vehicle as her vehicle NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) . The contact said she was advised that her vehicle had to be taken to the dealer to have her vehicle reprogrammed. The contact stated that she has not yet contacted the dealer or the manufacturer at this time. The failure milage was 60,000.

NHTSA ODI #11449156

Mileage unknown · Dec 6, 2021

Electrical SystemExterior LightingService Brakes

Read full complaint

I bought the car a year ago from a used car lot. Replaced the cam shaft positioning sensor as per diagnostic reading for check engine light. Since then, svc air bag light has stayed on. Traction control light stays on and is disengaged. When braking ESC warning goes on and off and sliding occurs. The low beam headlights go on and off intermittently and no way of knowing when it will happen. When turning cruise control on or off, the car will accelerate on its own and will increase speed until brake is applied. Regardless of whether cruise control was turned on or off. I have had it looked at at my local Mr.Tire and they cannot figure out what is happening.

NHTSA ODI #11442865

Mileage unknown · Nov 3, 2021

Electrical SystemEngineSteering

Read full complaint

I been having the same problem for a year now.. constantly putting it in and out the shop and no one can find out what’s wrong with it.. the engine will loss it control and stop working in the middle of traffic which almost caused me a wreck several times. The Chevrolet dealership hasn’t done anything to help but charge me to look at it and they didn’t fix the problem. I have three kids and it has been a safety issue which is our only way to work and school. The car will skip constantly in the middle of traffic and several times someone almost ran into the back of my car. It will say engine power reduced, service traction and service sec I have spent ton of money trying to fix the issue and I have read several people have had the same problem.

NHTSA ODI #11439225

Mileage unknown · Sep 9, 2021

Electrical SystemFuel/propulsion System

The bcm and fuel pump relay over heats burns the wire causing stalls at traffic lights and normal driving then won’t start back up. If you’re lucky you can hit the bcm or take the fuel relay out and reinstall and it may start back up

NHTSA ODI #11432395

Mileage unknown · Aug 14, 2021

Electrical SystemExterior LightingService Brakes

Read full complaint

I have a 2012 Chevy Malibu i bought it in 2014. I have had the Esc light come on in 2016 but no problem with it untill now of this year in 2022. Not knowing the problem i have already put ALOT into it. I took it to a machanic they told me it was the rack and pinion. So got that done . Apparently it wasn't it took it to another machanic they told me it was struts got that done too n still nothing so i looked it up online got CV joint, inner ,tie rod, wheel alignment. All those done n still nothing fix it. I didn't know what else to do until i made more scratch on my vehicle and i found that it could be a recall .

NHTSA ODI #11429076

Mileage unknown · Aug 1, 2021

Electrical SystemEngineFuel/propulsion System

This car will not start!!!! It starts when it feels like it. I’ve been stranded after work so many times for unknown reasons. Multiple mechanics have inspected car and cannot find the issue. Go on YouTube and search for this year car and you’ll find so many people in the same situation as me. The car has battery but the engine w…

Read full complaint

NHTSA ODI #11427361

112,000 miles · Jul 26, 2021

Electrical SystemFire

Read full complaint

The contact owned a 2012 Chevrolet Malibu. The contact stated that while his wife was driving at 10 mph, other drivers alerted her that there was a fire underneath the vehicle. The contact's wife was able to safely exit the vehicle. There was no injury and no medical attention was necessary. The fire department was able to extinguish the fire. The contact's wife was informed that there might have been an electrical short that caused the fire. A fire department report was filed. The vehicle was towed to the residence. The contact left a voicemail for the dealer notifying them of the failure and was awaiting a callback from the dealer. The manufacturer was not made aware of the failure. The failure mileage was 112,000.

NHTSA ODI #11426474

Mileage unknown · Jul 10, 2021

Electrical SystemService BrakesUnknown Or Other

Read full complaint

GM Tech Bulletins say there is a Ghost Problem with Elect. Stability Controller. GM mentions there is no recall or known cure for this. .Components/contacts were cleaned at service shop but " Serv. ESC-ESC OFF" keeps appearing in "driver display" when hitting bumps -turning car.. i will mail service sheets. This option was available on 08-09-10 models of Malibu but Std. on my 2012 car. It is worthless when there is thick snow.. I will send , by mail, serv. records on this unsolvable problem... It continues to happen ,at slow speed - not just one time...I believe YOU can read the G.M.-TSBs, as it was shown to me.... Consumer stated it showed a bad steering column multi switch & Yaw sensor unit , part still available.. Unit fires off bad code when barely moving and turning to right... Unit gets damp and works for a while. Turns out: Plastic Yaw coil in steering column broke up against the shaft, and the multi reed switch is probably bad, in there. The consumer stated after a new multi switch was installed, the bracket of the plastic broke again.

NHTSA ODI #11424228

Mileage unknown · Jun 26, 2021

Electrical SystemFuel/propulsion System

While parked or driving this vehicle shuts down on its own, sometimes on the freeway going 65 mph. The fuse located in the trunk has a faulty connection and a wire that isn’t efficient for heat from fuel pump so it shuts down while driving and sometimes won’t start. This is gonna kill someone when it shuts off on the freeway in …

Read full complaint

NHTSA ODI #11422388

Mileage unknown · Jun 3, 2021

Electrical SystemEnginePower Train

Read full complaint

My vehicle fail to restart vehicle, but vehicle was running good before. Once I turn off the vehicle for couple of minutes when I returned back to my vehicle and tried to turn vehicle on it would not allow me to turn on lights on vehicle would stay on when taking key out of ignition. I kept trying couple of time until I open the hood to check battery move battery cables tried again until vehicle turn on. Once vehicle had turn on and put vehicle in reverse dashboard lights started turning on check engine a service warning message display and speed meter would go up and down. When going forward the steering wheel became hard to control while vehicle would go toward slowly then stop go fast and slowly again until I got home turn vehicle off. Didn't drive it anymore until two days later. The second time I was on the freeway when my vehicles speed started to significantly reduce speed very quickly. I became concern with my safety until I was able to pull over on the side of freeway car turned off. When trying to restart vehicle would fail to turn back on had to tow vehicle back home. I tried turning vehicle back on failed at first on the last try vehicle turned on but when putting on reverse or drive vehicle became undriveable thier was no movement on vehicle and speed meter would not move . I just purchased this vehicle only had 8 months with it I payed $5000 plus $600 on plates. I do make my vehicle available for inspection it is very dangerous going through this specially on highway. I checked my onstart vehicle report but it does not show that anything is wrong on the report. My insurance provider Geico car details only show it needs and oil change. I also notice that in the vehicle history shows it has an oil leak. I can not afford to pay for a mechanic at this moment my vehicle is just park at home now.

NHTSA ODI #11419565

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)