Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

Electrical System complaints

290 reports

Clear category filter

Mileage unknown · Jun 28, 2022

Electrical SystemEngineFuel/propulsion System

Read full complaint

To Whom It May Concern: My 2012 Chevrolet Malibu LS HASN'T been involved in an accident but I feel it necessary to report it! Due to issues involving my electrical system and other components of the vehicle that aren't working properly, the vehicle is inoperable! Beginning in April 2022, I have experienced issues with the vehicle starting (one day it will start and drive normally, another day it might not). Then it started stalling unexpectedly. Granted, I've had the car 10 years but I've never had these problems! It's been serviced and the problems still exist! These problems could easily cause an accident; I'm grateful I've been spared from tragedy! These issues need to be addressed and I'd greatly appreciate hearing from NHTSA!

NHTSA ODI #11471426

107,089 miles · Jun 7, 2022

Electrical SystemPower Train

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated while driving 65 MPH, the vehicle started losing motive power and was shuddering while shifting gear. There was no warning light illuminated. The contact was able to pull over to the side of the roadway, turn off, and restart the vehicle, and drove to the residence safely. The vehicle was then taken to the local dealer to be diagnosed. The contact was informed that as fuse box needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 107,089.

NHTSA ODI #11467948

Mileage unknown · Mar 30, 2022

Electrical SystemSteeringVehicle Speed Control

The electric power steering and ESC systems. It is or was under recall for this type of vehicle. The steering becomes hard and vehicle shakes the tire rotation is being read wrong by computer. It doesn't want to stay 9n the road...the stability of vehicle is compromised.

NHTSA ODI #11458969

Mileage unknown · Mar 15, 2022

Electrical SystemExterior LightingUnknown Or Other

Passenger as well as driver side headlight continuously pop on and off, not blowing the bulbs but assuming there is a wiring issue

NHTSA ODI #11456718

Mileage unknown · Mar 11, 2022

Electrical System

Read full complaint

Each time I try to start my car it only starts up for 2 seconds and cut it off. I have changed fuel pump relay switch. It’s still causing the same problem. If I knock on the fuse box in the trunk then start the car the car will eventually start up. My car will randomly cut off on me causing me to be stuck. My rpm stopped moving at times I feel like I’m losing power. This car has serious electrical issues definitely a recall needs to be put in place. Let’s not forget my headlights not working even though they’ve been changed still only my driver side high beams work

NHTSA ODI #11456327

Mileage unknown · Mar 4, 2022

Electrical SystemSteeringWheels

Read full complaint

I'm a single parent and I can't afford to take my car to the dealership I love my car I have had my 2012 chevy malibu for over 6 years n I hate to just have it park at home knowing that, that's car was my everything. It started having problem with esc . When I would come to a stop then taking off it would break on its one I was told it could be my throttle body so I went n buy one n now the idle is too high now I can't get it to fix. Pls help me out I'm my car that I love so much.

NHTSA ODI #11455265

Mileage unknown · Feb 23, 2022

Electrical System

Read full complaint

The fuse box in the trunk (Body Control Module or BCM) has completely melted the rear defrost fuse into the block. A central piece of the fuse was removed once the issue was identified preventing the system from continuing to send electrical current through the fuse and possibly sparking or shorting out other essential systems (such as the fuel pump which seems to be a common problem). I have not taken this to be seen by a dealer, but intend to replace the BCM so as to prevent the fuses from completely melting. Overall, there was no indication of the issue until I realized that the rear defrost wasn't working when there was a light frost on the windows. This is when I checked the fuses and found the issue.

NHTSA ODI #11453716

Mileage unknown · Feb 10, 2022

Electrical SystemPower TrainSteering

Read full complaint

My electric steering motor and torque sensor is going out. I first noticed it starting to go out about 2 months ago in November. I was turning to pull into a parking spot at the grocery store and all of a sudden my wheel locked up and check ESC flashed across my dashboard. I almost side grazed the car on side of me on my way turning in. I had to turn the wheel really hard to straighten it up..so when I got into the parking spot and turned the car off and turned it back on it was working again and didn’t do it for a while. So fast forward 2 months later in January it started back doing it again. I was backing out of my driveway and all of a sudden the steering got really hard and again service ESC flashed on the dashboard and I almost backed up into a car that’s parked on the street behind my driveway. I had to turn really had and in the middle of the street I had to turn the car off and back on to reset itself . The next day was driving and and when I stopped at a stop sign my steering wheel started shaking left to right uncontrollably and ever since the the steering wheel just shakes even while sitting still so I made an appointment with the dealership that I got the car for checked it out and did a diagnostic test and the mechanic told me I needed a torque sensor and steering motor. I have the papers saying that’s what’s wrong with it and after doing research I found that that car model had a recall with the exact same thing my car is doing but when I put in my vin number it’s not listed as a recall and my car isn’t drivable and I think it should be recalled .As of now it has only been looked at by the dealership. And it’s available for inspection upon request.

NHTSA ODI #11451342

Mileage unknown · Feb 9, 2022

Electrical SystemSteeringCrash

ESC traction control /Power Sterering light turned on my wheel was hard to steer. Lost control . If I turn off it works for a few minutes but then goes back to hard.. unable to steer

NHTSA ODI #11451269

Mileage unknown · Jan 29, 2022

Electrical System

Read full complaint

Several electrical problems have occurred with my 2012 Chevy malibu. First the horn would not stop beeping which caused me to jump and almost run into a telephone pole. I parked the car and the horns kept beeping I got home and the horn cap beeping. My husband cleaned off the battery cables and that seemed to stop the problem for a while then they started beeping again. Then my door lock started unlocking and locking by itself causing me to lock my keys in my car. So I disconnected the horn I disconnected the locks. Now my trunk is popping open by itself. Even when the trunk is open the electrical supply keeps going to it and making a clicking sound trying to open it. I have had many electrical problems with this car.

NHTSA ODI #11449419

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)