IllustrationLug studs repeatedly snap at wheel no matter how installed.
2010 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2010 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1190–25K
12225–50K
22050–75K
24475–100K
256100–150K
110150K+
1,071 reports with mileage · 289 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 454 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 294 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports14 fire reports35 injury reports
Suspension complaints
13 reportsPower steering and yes it is. Not safe to drive because of the steering. The dealership has changed the part under the recall as well as the warranty Yes by several people No warning lights or anything came on to show that there was a issue
The ESC and engine light came on and then the stability track light came on for a matter of a min and then all the lights just went off. I seen there are recalls on these issues but not for my vin number.
I PURCHASED THE CAR FROM CREST AUTO MALL AND 1 WEEK LATER THE SUSPENSIONS GETS MESSED UP AND THEN 1 MONTH LATER THE ENGINE BLOWS UP NOW MY CAR IS PARKED IN THE DRIVEWAY!
TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. WHILE THE CONTACT WAS PARALLEL PARKING, AN ABNORMAL NOISE WAS DETECTED COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO SHARRETT BUICK GMC (10312 AUTO PL, HAGERSTOWN, MD 21740, (800) 495-9755) WHERE THE FRONT STRUTS, INNER TIE ROD, AND PASSENGER SIDE AXLE WERE REPLACED. THE C…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET MALIBU. WHILE THE CONTACT WAS PARALLEL PARKING, AN ABNORMAL NOISE WAS DETECTED COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO SHARRETT BUICK GMC (10312 AUTO PL, HAGERSTOWN, MD 21740, (800) 495-9755) WHERE THE FRONT STRUTS, INNER TIE ROD, AND PASSENGER SIDE AXLE WERE REPLACED. THE CONTACT MENTIONED THAT THE PASSENGER SIDE AXLE SEAL WAS REPLACED TWO YEARS AGO. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 98,869. *TT
2010 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO VEHICLE STEERING AND AIR BAG DEFECTS. *SMD THE CONSUER STATED THE STEERING WOULD SQUEAL AND GROWL, WHICH CREATED A VIBRATION MAKING STEERING DIFFICULT. THE AIRBAG WARNING LIGHT WAS ILLUMINATED.*JS
ONE OF MY NEW TIRES CONTINUALLY DEFLATE. AFTER TAKING TO TIRE CO. 6OF8WKS TO GET AIR, I WAS TOLD I HAVE A CRACKED WHEEL AND WILL PAY $500 FOR A USED WHEEL OR UP TO $1000 FOR AUTHORIZED DEALER TO REPLACE IT. I PAY $50 EXTRA F/PLATINUM WARRANTY AND HAD TO PAY FOR AIRBAG SVC'ING TO GET INSPECTION--AND $100 DEDUCTIBLE FROM WARRANT…
Read full complaint
ONE OF MY NEW TIRES CONTINUALLY DEFLATE. AFTER TAKING TO TIRE CO. 6OF8WKS TO GET AIR, I WAS TOLD I HAVE A CRACKED WHEEL AND WILL PAY $500 FOR A USED WHEEL OR UP TO $1000 FOR AUTHORIZED DEALER TO REPLACE IT. I PAY $50 EXTRA F/PLATINUM WARRANTY AND HAD TO PAY FOR AIRBAG SVC'ING TO GET INSPECTION--AND $100 DEDUCTIBLE FROM WARRANTY COMPANY. IN 2YRS, I'VE PAID $1200 F/WARRANTY PLUS $150 DEDUCTIBLE@AUTHORIZED SERVICE CTR-PINKERTON CHEV IN LYNCHBURG, VA-AND IT TOOK 3 WEEKS THAT I HAD TO BUM A RIDE TO WORK OR PAY A CAB. NOW, I'M RIDING ON A "DONUT" AND MY GAS MILEAGE IS <8MPG........W/A $389 CAR NOTE AND $200 CAR INSURANCE NOTE.
I HAD TO HAVE OVER $2500 WORTH OF WORK DONE TO MY CAR, WHICH HAD SOMETHING TO DO WITH SOME TORQUE SENSOR AND OTHER PARTS - I SEE THAT THERE WAS A RECALL ON OTHER CHEVY MALIBU'S IN PREVIOUS MODEL YEARS. I AM WONDERING HOW LONG THIS RECALL WILL TAKE, MY YEAR IS 2010 AND NOT CURRENTLY ON THE RECALL LIST. PRIOR TO THAT, I HAD JUST P…
Read full complaint
I HAD TO HAVE OVER $2500 WORTH OF WORK DONE TO MY CAR, WHICH HAD SOMETHING TO DO WITH SOME TORQUE SENSOR AND OTHER PARTS - I SEE THAT THERE WAS A RECALL ON OTHER CHEVY MALIBU'S IN PREVIOUS MODEL YEARS. I AM WONDERING HOW LONG THIS RECALL WILL TAKE, MY YEAR IS 2010 AND NOT CURRENTLY ON THE RECALL LIST. PRIOR TO THAT, I HAD JUST PAID $2000 FOR OTHER WORK NEEDED ON THIS VEHICLE THAT WAS OUT OF WARRANTY. I'VE HAD SO MANY ISSUES W/THIS CAR. I HAVE RECEIPTS BUT THEY ARE CURRENTLY IN STORAGE - I AM UNABLE TO UPLOAD THEM RIGHT NOW.
THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL WAS EXTREMELY ROUGH TO TURN. ADDITIONALLY, THE AIR BAG WARNING LIGHT WOULD ILLUMINATE INTERMITTENTLY AND THE BATTERY CONTINUED TO DRAIN PREMATURELY. THE CONTACT ALSO STATED THAT THE REAR SUSPENSION WAS UNSTABLE. THE VEHICLE WAS TAKEN TO THE DEAL…
Read full complaint
THE CONTACT OWNS A 2010 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL WAS EXTREMELY ROUGH TO TURN. ADDITIONALLY, THE AIR BAG WARNING LIGHT WOULD ILLUMINATE INTERMITTENTLY AND THE BATTERY CONTINUED TO DRAIN PREMATURELY. THE CONTACT ALSO STATED THAT THE REAR SUSPENSION WAS UNSTABLE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS TRAVELING ON THE HIGHWAY WHEN THE REAR SUSPENSION FAILURE RECURRED AND THE VEHICLE SWAYED VIOLENTLY TOWARD THE DRIVER'S SIDE OF THE VEHICLE. THE STEERING WHEEL SEIZED AND AS THE CONTACT APPLIED FORCE TO THE STEERING WHEEL, THE STEERING WHEEL SEIZED AND THE CONTACT CRASHED INTO A TREE. THE AIR BAGS ONLY PARTIALLY DEPLOYED. THE DRIVER SUSTAINED SEVERE INJURIES AND THE JAWS OF LIFE WERE USED TO REMOVE AN INJURED PASSENGER FROM THE VEHICLE. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V460000 (POWER TRAIN). THE CONTACT RECEIVED THE RECALL NOTIFICATION AFTER THE CRASH OCCURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES SEVERAL TIMES BUT TO NO AVAIL. THE APPROXIMATE FAILURE MILEAGE WAS 1,000. *TR UPDATED 3/3/15*CN UPDATED 07/06/2017 *CT
THE RACK AND PINION ON DRIVERS SIDE END RATTLES AT SLOW SPEED. I HAVE TRIED 3 DIFFERENT BRAND FRONT BRAKES AND ALL HAVE SQUEAKED,THE TRANSMISSION COOLER LINE STARTED LEAKING.THE CAR HAS 69,000 ON IT AS OF NOW 1/26/2013. DEALER WANT FIX ANY OF THE PROBLEM UNDER THE DRIVE TRAIN WARRANTY. ALSO HAS COLD START ENGINE KNOCK. *TR
Official recalls
319V019000 · Air Bags:frontal:driver Side:inflator Module
Jan 16, 2019
General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.
Consequence & remedy
Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.
Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.