IllustrationPOWER STEERING WILL WORK WHEN IT WANTS TO SOME DAYS IT WORKS ALL DAY OTHER DAYS IT WONT WORK AT ALL AND SOME DAYS I LOOSE POWER STEERING WHILE DRIVING MY POWER STEERING LIGHT AND SERVICE ESC LIGHTS COME ON WHEN POWER STEERING FAILS THIS IS A SCARY PROBLEM TO HAVE WHEN TRANSPORTING MY 4 KIDS
2009 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2009 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
9825–50K
19350–75K
21775–100K
373100–150K
232150K+
1,200 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 768 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 368 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports9 fire reports31 injury reports
What owners actually said
1,509 reportsI HAVE A 2009 MALIBU 2.4 ENGINE WITH ELECTRIC POWER STEERING WHEN IT GOT COLD OUTSIDE POWER STEERING STARTED GOING OUT AND THE TRACTION CONTROL LIGHT COMES ON AND SERVICE ESC MESSAGE COMES ACROSS THE MESSAGE CENTER. TURN THE CAR OFF AND BACK ON AND THE LIGHT GOES OUT AND THE POWER STEERING WORKS AGAIN IT DOES IT WHEN THE CAR IS…
Read full complaint
I HAVE A 2009 MALIBU 2.4 ENGINE WITH ELECTRIC POWER STEERING WHEN IT GOT COLD OUTSIDE POWER STEERING STARTED GOING OUT AND THE TRACTION CONTROL LIGHT COMES ON AND SERVICE ESC MESSAGE COMES ACROSS THE MESSAGE CENTER. TURN THE CAR OFF AND BACK ON AND THE LIGHT GOES OUT AND THE POWER STEERING WORKS AGAIN IT DOES IT WHEN THE CAR IS MOVING OR EVEN IF THE CAR IS PARKED AND I TURN THE WHEEL IT HAS DONE 3 TIMES WHILE DOING 65 ON HIGHWAY LUCKILY I WAS ABLE TO PULL OVER TURN CAR OFF AND BACK ON SO THE STEERING CAN WORK AGAIN THE COLDER TEMPERATURES GET THE MORE OFTEN THE POWER STEERING GOES OUT I'M AFRAID I MIGHT HAVE A SERIOUS ACCIDENT
THE CAR WILL DISPLAY AN ESC SERVICE LIGHT AND THEN THE POWER STEERING WILL GO OUT ONCE THAT HAPPENS. WHEN YOU TURN THE CAR OFF THEN BACK ON THE LIGHT GOES AWAY AND THEN THE POWER STEERING WILL GO OUT AGAIN AND THE ESC SERVICE WILL DISPLAY AGAIN.
OVER A PERIOD OF 7 DAYS MID-NOV-2019, BRAKE LIGHTS WOULD WORK BACKWARDS. DEPRESSING PEDAL, BRAKE LIGHTS OFF. PRESSING GAS PEDAL BRAKE LIGHTS ON. WITHIN A FEW MINUTES, SERVICE ESC/TRACTION MSG. SHUT CAR OFF, RESTART, EVERYTHING WORKED FINE. STARTED AS WEATHER TURNED COLD/DAMP. HAPPENED BOTH STATIONARY AND MOVING. BROUGHT I…
Read full complaint
OVER A PERIOD OF 7 DAYS MID-NOV-2019, BRAKE LIGHTS WOULD WORK BACKWARDS. DEPRESSING PEDAL, BRAKE LIGHTS OFF. PRESSING GAS PEDAL BRAKE LIGHTS ON. WITHIN A FEW MINUTES, SERVICE ESC/TRACTION MSG. SHUT CAR OFF, RESTART, EVERYTHING WORKED FINE. STARTED AS WEATHER TURNED COLD/DAMP. HAPPENED BOTH STATIONARY AND MOVING. BROUGHT IT TO DEALER, "COULD NOT REPLICATE PROBLEM".
WHILE DRIVING, I NOTICED THE STEERING WHEEL WOULD PULSE, ESPECIALLY WHEN TURNING THE WHEEL LEFT. AFTER ABOUT 3 OR 4 DAYS, I LEFT WORK(12/17/19), AND "POWER STEERING SERVICE ESC" SHOWED ON THE DASH DISPLAY. SINCE THAT TIME, THE POWER STEERING HAS BEEN INTERMITTENT. MOST TIMES IT GOES OUT WHILE I'M DRIVING.
SUDDEN LOSS OF ELECTRONIC POWER STEERING. CAN HAPPEN WHILE DRIVING OR AT IDLE AND CAN CAUSE TOUGH STEERING OR LOSS OR VEHICLE CONTROL. FROM THE COMPLAINTS IVE READ THIS SEEMS TO BE MORE COMMON DURING COLDER TEMPERATURE DAYS. COULD HAPPEN WHILE DRIVING IN ICY CONDITIONS... MY DAUGHTER IS NOW TERRIFIED TO DRIVE HER VEHICLE. I HAV…
Read full complaint
SUDDEN LOSS OF ELECTRONIC POWER STEERING. CAN HAPPEN WHILE DRIVING OR AT IDLE AND CAN CAUSE TOUGH STEERING OR LOSS OR VEHICLE CONTROL. FROM THE COMPLAINTS IVE READ THIS SEEMS TO BE MORE COMMON DURING COLDER TEMPERATURE DAYS. COULD HAPPEN WHILE DRIVING IN ICY CONDITIONS... MY DAUGHTER IS NOW TERRIFIED TO DRIVE HER VEHICLE. I HAVE CONTACTED GM AND THEY REFUSE TO COVER ANY COSTS FOR THIS ISSUE EVEN THOUGH ITS A NATION WIDE KNOWN ISSUE WITH THESE VEHICLES.
TODAY I LOST POWER STEERING AGAIN (ALSO HAPPENED 2 TIMES ABOUT A MONTH AGO). I WAS DRIVING IN DOWNTOWN MADISON WI TODAY WHEN IT HAPPENED, VERY UNSAFE SITUATION. GM'S WEBSITE SAYS THERE WAS A RECALL FOR SOME 2009 MALIBUS IN 2014, BUT WHEN I JUST CALLED GM NOW THEY SAY MY VEHICLE WASN'T INCLUDED IN THE RECALL. BUT OBVIOUSLY, TH…
Read full complaint
TODAY I LOST POWER STEERING AGAIN (ALSO HAPPENED 2 TIMES ABOUT A MONTH AGO). I WAS DRIVING IN DOWNTOWN MADISON WI TODAY WHEN IT HAPPENED, VERY UNSAFE SITUATION. GM'S WEBSITE SAYS THERE WAS A RECALL FOR SOME 2009 MALIBUS IN 2014, BUT WHEN I JUST CALLED GM NOW THEY SAY MY VEHICLE WASN'T INCLUDED IN THE RECALL. BUT OBVIOUSLY, THERE IS AN ISSUE WITH MY VEHICLE. BASED ON ALL THE OTHER COMPLAINTS ON THE WEBSITE, GM SHOULD BE FORCED TO RECALL THESE VEHICLES AGAIN! THIS TIME, ALL OF THEM.
STOPPED BEHIND ANOTHER VEHICLE, WHEN I STARTED MOVING AGAIN THERE WAS A SEVERE SHUDDER OR VIBRATION. THEN MY CAR DID NOT WANT TO START MOVING AGAIN. ONCE IT DID START MOVING IT WOULD NOT SHIFT OUT OF FIRST GEAR.
I HAD A POWER STEERING LIGHT COME ONE, AND MY ESC LIGHT COME ON. THESE LIGHTS CAME ON WITH NO WARNING AND DISABLE THOSE FEATURES WHILE I WAS DRIVING DOWN THE HIGHWAY, GOING 57 MPH, AFTER A MAJOR ICE AND SNOW STORM. I AM UNABLE TO CONTROL MY VEHICLE WHILE IT IS ON THE ROAD.
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE MAKING A RIGHT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND FORCED THE CONTACT TO DRIVE FORWARD. IN ADDITION, THE ESC SERVICE NEEDED WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED INITIALLY TO AN INDEPENDENT MECHANICS AND THEN ANOTHER INDEPENDENT MECHANIC AT A DI…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE MAKING A RIGHT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND FORCED THE CONTACT TO DRIVE FORWARD. IN ADDITION, THE ESC SERVICE NEEDED WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED INITIALLY TO AN INDEPENDENT MECHANICS AND THEN ANOTHER INDEPENDENT MECHANIC AT A DIFFERENT LOCATION. THE CONTACT WAS INFORMED THAT THE STEERING GEAR SENSOR NEEDED TO BE REPAIRED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE CONTACT CALLED ALAN WEBB CHEVROLET (LOCATED AT 3712 NE 66TH AVE, VANCOUVER, WA 98661, (360) 574-1131) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 93,846.
Official recalls
514V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
08V634000 · Visibility:defroster/defogger/hvac System
Dec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
Consequence & remedy
Consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.