IllustrationDRIVING ON THE ROAD AND ALL OF A SUDDEN LOST POWER STEERING ASSIST
2009 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2009 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
9825–50K
19350–75K
21775–100K
373100–150K
232150K+
1,200 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 768 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 368 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports9 fire reports31 injury reports
Steering complaints
768 reportsVEHICLE HAS HAD POWER STEERING ASSIST QUIT TWICE ON TWO SEPARATE OCCASIONS WHILE IN A TURN ON COUNTY ROADS. COMPLETE LOSS OF POWER STEERING MID TURN. MOTOR HAS BEEN REPLACED ONCE AND IS HAVING THE SAME PROBLEM AGAIN.
THE SERVICE ESC LIGHT COMES ON AND THE LOW TRACTION LIGHT(CAR ICON) COMES ON AND I LOSE POWER STEERING. WHEN I START THE CAR THESE SENSORS COME ON AND I LOSE POWER STEERING. SOMETIMES I'LL START IT AND THE SENSORS ARE OFF THEN I HAVE POWER STEERING THEN I'LL START DRIVING AND SOMETHING TRIPS THOSE SENSORS TO COME ON AND I LOSE P…
Read full complaint
THE SERVICE ESC LIGHT COMES ON AND THE LOW TRACTION LIGHT(CAR ICON) COMES ON AND I LOSE POWER STEERING. WHEN I START THE CAR THESE SENSORS COME ON AND I LOSE POWER STEERING. SOMETIMES I'LL START IT AND THE SENSORS ARE OFF THEN I HAVE POWER STEERING THEN I'LL START DRIVING AND SOMETHING TRIPS THOSE SENSORS TO COME ON AND I LOSE POWER STEERING. THIS STARRED IN JANUARY 2020.
ELECTRIC POWER STEERING WENT OUT ON MY CHEVY MALIBU 2009, 2.4 LITER ENGINE. THE CAR CAN BE TURNED ON AND THE POWER STEERING WILL SHUT OFF AND I AM UNABLE TO MOVE THE STEERING WHEEL WHEN DRIVING. THE SENSOR WILL PICK UP AN ERROR AND IT WILL DISPLAY 'POWER STEERING' ON THE DASH. THEN I WILL TURN THE CAR OFF AND THE POWER STEERING …
Read full complaint
ELECTRIC POWER STEERING WENT OUT ON MY CHEVY MALIBU 2009, 2.4 LITER ENGINE. THE CAR CAN BE TURNED ON AND THE POWER STEERING WILL SHUT OFF AND I AM UNABLE TO MOVE THE STEERING WHEEL WHEN DRIVING. THE SENSOR WILL PICK UP AN ERROR AND IT WILL DISPLAY 'POWER STEERING' ON THE DASH. THEN I WILL TURN THE CAR OFF AND THE POWER STEERING WILL TURN BACK ON. TURNING WHEN THE POWER STEERING IS STILL WORKING CAUSES IT TO HAVE A WEIRD TWITCH OR JERK WHEN DRIVING WHERE IT MOVES THE STEERING WHEEL BY ITSELF WHEN TURNING AND DRIVING STRAIGHT. GM HAD A RECALL FOR THIS ISSUE WITH MY EXACT MODEL BUT I CALLED THE DEALERSHIP AND THEY SAID THEY WERE UNABLE TO HELP ME AND THAT MY CAR WASN'T ON THE RECALL BULLETIN YET MY CAR IS THE SAME MODEL AND YEAR THAT ON THE BULLETIN HAVING THE EXACT SAME PROBLEM. IT IS ALSO NOT ME, I SEE OTHERS HAVING THE SAME PROBLEM AND THAT GM IS NOT DOING ANYTHING ABOUT THIS DANGEROUS ISSUE. I JUST PURCHASED THIS VEHICLE AND IT HAS 160,000 MILES ON IT. THIS NEEDS TO BE ADDRESSED BECAUSE POWER STEERING IS ESSENTIAL TO DRIVER SAFETY. THIS HAPPENS ANYWHERE AT ANYTIME THE POWER STEERING DECIDES TO JUST SHUT ITSELF OFF.
MY VEHICLE HAS LOST STEERING AFTER STARTING SEVERAL TIMES OVER THE LAST WEEK. MY INFO SCREEN DISPLAYS AN ESC AND POWER STEERING MESSAGE AND MY STEERING WHEEL IS LOCKED IN PLACE. ONCE THE CAR IS SHUT OFF AND RESTARTED THE MESSAGES GO AWAY AND STEERING IS BACK TO NORMAL. I HAVE FOUND A RECALL RELATED TO THIS ON CERTAIN VEHICLES…
Read full complaint
MY VEHICLE HAS LOST STEERING AFTER STARTING SEVERAL TIMES OVER THE LAST WEEK. MY INFO SCREEN DISPLAYS AN ESC AND POWER STEERING MESSAGE AND MY STEERING WHEEL IS LOCKED IN PLACE. ONCE THE CAR IS SHUT OFF AND RESTARTED THE MESSAGES GO AWAY AND STEERING IS BACK TO NORMAL. I HAVE FOUND A RECALL RELATED TO THIS ON CERTAIN VEHICLES OF MY YEAR/MAKE/MODEL AND ALSO MANY FORUMS OF PEOPLE HAVING THE SAME ISSUES. HOWEVER, WHEN SEARCHING BY VIN IT SAYS MY VEHICLE HAS 0 RECALLS. I HAVE ALSO NOTICED WHEN MY VEHICLE IS STOPPED, OR IN PARK MY STEERING WHEEL WILL SHAKE FOR A MOMENT AND THEN STOP.
I WAS DRIVING AND THE POWER STEERING LIGHT CAME ON AND STEERING GOT REAL HARD TO TURN AND NOW I HAVE NO STEERING POWER TO DRIVE AND I'M SCARED TO DRIVE AND ALSO MY CAR BE IN REVERSE AND IT WENT FORWARD
MY VEHICLE IS HAVING EXACT SYMPTOMS AS OTHER VEHICLES IN THE SAME YEAR RANGE WITH THE EXACT ENGINE SIZE AND POWER TRAIN. I HAVE A 4 - CYL ECO TEC ENGINE AND I HAVE FOUND THAT GM RECALLED LOTS OF UNITS FOR THIS EXACT PROBLEM YET MINE IS NOT IN THE DATABASE. MY ELECTROINC STEERING SHUTS ON AND OFF ALL WINTER!
THE ELECTRIC POWER STEERING SUDDENLY STOPPED WORKING, AND I WAS IN DANGER OF CRASHING THE VEHICLE. THE CHEVY DEALERSHIP SAYS ITS A PROBLEM WITH THE STEERING COLUMN TORQUE SENSOR, AND THAT GM HAD A MILLION CAR RECALL ON THIS ISSUE. HOWEVER, THEY STATED THIS SAFETY CONCERN HAD AN EXPIRATION DATE AND FOR MY VEHICLE, IT EXPIRED MA…
Read full complaint
THE ELECTRIC POWER STEERING SUDDENLY STOPPED WORKING, AND I WAS IN DANGER OF CRASHING THE VEHICLE. THE CHEVY DEALERSHIP SAYS ITS A PROBLEM WITH THE STEERING COLUMN TORQUE SENSOR, AND THAT GM HAD A MILLION CAR RECALL ON THIS ISSUE. HOWEVER, THEY STATED THIS SAFETY CONCERN HAD AN EXPIRATION DATE AND FOR MY VEHICLE, IT EXPIRED MAY 2019. IT APPEARS TO BE HAVING EXACTLY THE SAME SYMPTOMS, WITH THE SAME DANGEROUS CONSEQUENCES, AS THOSE RECALLED VEHICLES, AND YET GM WILL NOT TAKE RESPONSIBILITY FOR THIS SAFETY MATTER. THIS CONDITION OCCURRED INTERMITTENTLY, AND THEN ALL OF THE TIME. IT OCCURS WHEN IN REVERSE, AND FORWARD GEARS, WHEN TURNING AND WHEN TRAVELING STRAIGHT. IT OCCURS AT ALL SPEEDS. AGAIN, THE GM MECHANICS STATE THE PROBLEM IS THE STEERING COLUMN TORQUE SENSOR.
POWER STEERING GOES OUT AND THE TRACTION CONTROL LIGHT COMES ON AND SERVICE ESC MESSAGE COMES ACROSS THE MESSAGE CENTER. TURN THE CAR OFF AND BACK ON AND THE LIGHT GOES OUT, POWER STEERING COMES BACK FOR A SECOND THEN THE LIGHT TRIPS AGAIN AND IT'S OUT AGAIN. I HAVE LOST POWER STEERING WHILE DRIVING DOWN A HIGHWAY AND ALSO WHIL…
Read full complaint
POWER STEERING GOES OUT AND THE TRACTION CONTROL LIGHT COMES ON AND SERVICE ESC MESSAGE COMES ACROSS THE MESSAGE CENTER. TURN THE CAR OFF AND BACK ON AND THE LIGHT GOES OUT, POWER STEERING COMES BACK FOR A SECOND THEN THE LIGHT TRIPS AGAIN AND IT'S OUT AGAIN. I HAVE LOST POWER STEERING WHILE DRIVING DOWN A HIGHWAY AND ALSO WHILE BACKING OUT OF MY DRIVEWAY. IT IS NOT SAFE TO DRIVE THIS CAR. IF I AM IN THE MIDDLE OF A TURN AND I LOOSING POWER STEERING, I HAVE TO SLOW DOWN AND PULL OVER TO TURN OFF THE CAR AND HOPE THAT POWER STEERING TURNS BACK ON.
WHILE DRIVING ESC LIGHT CAME ON, STEERING WHEEL JERKS/SHAKES UNABLE TO FULL STEER OR CONTROL VEHICLE. CUTS ON AND OFF WHILE DRIVING
Official recalls
514V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
08V634000 · Visibility:defroster/defogger/hvac System
Dec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
Consequence & remedy
Consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.