IllustrationWHEN HOOKED UP TO THE COMPUTER IT THREW THE CODE TRANSMISSION CONTROL MODULE. THE CAR IS STUCK IN ONE GEAR, SOMETIMES IT IS 1ST GEAR SOMETIMES IT IS 5TH GEAR. YOU NEVER KNOW WHEN YOU START THE CAR ANDEALERS TAKE OFF WHAT GEAR IT WILL BE IN.
2009 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2009 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
9825–50K
19350–75K
21775–100K
373100–150K
232150K+
1,200 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 768 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 368 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports9 fire reports31 injury reports
Power Train complaints
121 reportsTL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE TRANSMISSION FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WAVE PLATE IN THE TRANSMISSION HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE TRANSMISSION FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WAVE PLATE IN THE TRANSMISSION HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,399. UPDATED 04/11/16 *BF
HARD SHIFT DEVELOPING BETWEEN 4TH & 5TH GEAR AS WELL AS REVERSE BEGINNING TO SLIP. THERE IS A 10 YEAR/120,000 MILE CAMPAIGN ISSUED BY GM CONCERNING THE 6T45 AS WELL AS THE 6T70 / 75 TRANSMISSIONS CONCERNING DEFECTIVE 3-5-R WAVE PLATES, BUT DOES NOT INCLUDE THE 6T40 TRANSMISSION WHICH MY VEHICLE HAS. THE DEFECTIVE INTERNAL PARTS …
Read full complaint
HARD SHIFT DEVELOPING BETWEEN 4TH & 5TH GEAR AS WELL AS REVERSE BEGINNING TO SLIP. THERE IS A 10 YEAR/120,000 MILE CAMPAIGN ISSUED BY GM CONCERNING THE 6T45 AS WELL AS THE 6T70 / 75 TRANSMISSIONS CONCERNING DEFECTIVE 3-5-R WAVE PLATES, BUT DOES NOT INCLUDE THE 6T40 TRANSMISSION WHICH MY VEHICLE HAS. THE DEFECTIVE INTERNAL PARTS IN QUESTION ARE SHARED BETWEEN THE 6T40 AS WELL AS THE 6T45 SO I DONT UNDERSTAND HOW MY MODEL TRANSMISSION IS NOT INCLUDED IN THIS CAMPAIGN TO SOLVE THIS KNOWN ISSUE.
TRANSMISSION BELL HOUSING AND TORQUE CONVERTER SEALS. WHY WAS THE TRANSMISSION NOT UNDER WARRANTY FOR THIS REPAIR. I PURCHASED THE CAR AT 36,045 MILES, AT 78,798 MILES THIS TRANSMISSION PAN LEAKAGE OCCURS. THIS RESULT IN 3RD GEAR SHIFT SLIPPING. RENDERING ME TO PAY A TOTAL TO ROGER DEAN OF 1,234.15, MIND YOU THE SEALS WERE 30.0…
Read full complaint
TRANSMISSION BELL HOUSING AND TORQUE CONVERTER SEALS. WHY WAS THE TRANSMISSION NOT UNDER WARRANTY FOR THIS REPAIR. I PURCHASED THE CAR AT 36,045 MILES, AT 78,798 MILES THIS TRANSMISSION PAN LEAKAGE OCCURS. THIS RESULT IN 3RD GEAR SHIFT SLIPPING. RENDERING ME TO PAY A TOTAL TO ROGER DEAN OF 1,234.15, MIND YOU THE SEALS WERE 30.00 AND THE LABOR 1086.40. THERE MUST HAVE BEEN A DEFECT IN THE SEALS FOR THAT SITUATION TO OCCUR IN THE TRANSMISSION. PLEASE INVESTIGATE. PURCHASE CAR FROM ROGER DEAN ON 7/30/11 AT 36,045 MILES. HAD REPAIRS DONE ON 1/28/14 AT 78,798 MILES.
OCTOBER 23, 2015, MY WIFE WAS DRIVING THE 2009 MALIBU TO WORK WHEN, ALL OF A SUDDEN, THE TRANSMISSION WOULD NOT SHIFT. SHE WAS ABLE TO GET TO THE SIDE OF THE ROAD AND STOPPED. SHE TRIED TO GO FORWARD AND THE CAR STAYED IN FIRST GEAR. SHE STOPPED TRIED TO BACK UP AND IT WOULD NOT GO. SHE CALLED ME AND, I WAS ABLE TO GET THE CAR H…
Read full complaint
OCTOBER 23, 2015, MY WIFE WAS DRIVING THE 2009 MALIBU TO WORK WHEN, ALL OF A SUDDEN, THE TRANSMISSION WOULD NOT SHIFT. SHE WAS ABLE TO GET TO THE SIDE OF THE ROAD AND STOPPED. SHE TRIED TO GO FORWARD AND THE CAR STAYED IN FIRST GEAR. SHE STOPPED TRIED TO BACK UP AND IT WOULD NOT GO. SHE CALLED ME AND, I WAS ABLE TO GET THE CAR HOME SLOWLY IN FIRST GEAR. WE KNEW THE WARRANTY WAS DONE AS OF THE 5 YEARS BUT ONLY HAD 65,000 MILES ON IT. SO, AFTER READING ON LINE ABOUT DEALERSHIPS USING USED PARTS TO FIX THE TRANSMISSION, WE CHOSE ATLAS TRANSMISSION TO DO THE WORK. WE WERE TOLD THE WAVE PLATE BROKE BASICALLY TAKING OUT THE TRANS AND NEEDED A NEW TRANS. $2808 LATER WE HAD THE CAR FIXED. I CONTACTED CHEVROLET ANF GM ABOUT THIS SINCE I READ THE COVERAGE ON THE 6 SPEED AUTOMATIC WAS EXTENDED TO 10 YEARS OR 120,000 MILES. I WAS TOLD MY CAR WAS NOT IN THAT RECALL AND THEY COULDNT DO ANYTHING TO HELP ME SINCE IT WAS A GOVERNMENT MANDATED COVERAGE BECAUSE IT WAS A SAFETY ISSUE. REALLY?-- MY WIFE BREAKING DOWN IN TRAFFIC ON THE HIGHWAY WAS NOT A SAFETY ISSUE? --REALLY?-- I AM VERY DISSAPPOINTED IN CHEVROLET AND GENERAL MOTORS. I HAVE DRIVEN THEIR CARS FOR 40 YEARS! --A KNOWN PROBLEM WITH THE WAVE PLATE, A TRANSMISSION REPLACED AT 65,000 MILES BECAUSE OF THE KNOWN PROBLEM. $2808 CASH OUT OF MY POCKET BECAUSE OF A KNOWN PROBLEM AND THEY CANT DO ANYTHING FOR ME ? I THINK THAT SUCKS! I WAS OFFERED A GIFT CARD FOR THE SERVICE DEPARTMENT OR TO BUY ACCESSORIES FOR MY CAR AS COMPENSATION FOR THE PROBLEM. --REALLY?--- WOW, I THOUGHT GM WOULD STEP UP TO THE PLATE ON THIS ONE, ESPECIALLY BECAUSE THEY WERE COVERING OTHER TRANSMISSIONS WITH THE SAME PROBLEM. --WELL, THEY DEFINATELY LOST ME AS A FUTURE CUSTOMER. I TRADED IT IN OM A NEW FORD ESCAPE FOR MY WIFE. A MUCH BETTER CHOICE AS I SEE IT. IM SURE THEY WILL TAKE BETTER CARE OF THEIR CUSTOMERS,---AS THEY DID IN THE PAST.
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHEN THE CONTACT PLACED THE VEHICLE INTO PARK AND THEN BACK INTO DRIVE, THE SHIFTER MOVED BUT THE TRANSMISSION DID NOT CHANGE GEARS. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V460000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFT CABLE N…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHEN THE CONTACT PLACED THE VEHICLE INTO PARK AND THEN BACK INTO DRIVE, THE SHIFTER MOVED BUT THE TRANSMISSION DID NOT CHANGE GEARS. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V460000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFT CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
WHILE DRIVING THE CAR AT 55 MPH IT STARTED JUMPING/SKIPPING WHILE I WAS DRIVING ON A 3 LANE HIGHWAY AND THEN IT JUST DIED. I COULDN'T GET IT IN REVERSE AND IT WOULDN'T SHIFT AT ALL. THE ELECTRICAL INFORMATION ON THE DASH WENT OUT AS WELL. I HAD TO ARRANGE A TOW. I'M BEING TOLD IT NEEDS A NEW TRANSMISSION AND THERE IS ELECTRI…
Read full complaint
WHILE DRIVING THE CAR AT 55 MPH IT STARTED JUMPING/SKIPPING WHILE I WAS DRIVING ON A 3 LANE HIGHWAY AND THEN IT JUST DIED. I COULDN'T GET IT IN REVERSE AND IT WOULDN'T SHIFT AT ALL. THE ELECTRICAL INFORMATION ON THE DASH WENT OUT AS WELL. I HAD TO ARRANGE A TOW. I'M BEING TOLD IT NEEDS A NEW TRANSMISSION AND THERE IS ELECTRICAL FAILURE AS WELL. THE CAR HAS 86,000 MILES ON IT AND HAS BEEN SERVICED ROUTINELY. HOW DOES A TRANSMISSION GO FROM WORKING TO DEAD IN SECONDS?
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE BEGAN TO SLOW DOWN INDEPENDENTLY AND CAME TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A WAVE PLATE WITHIN THE TRANSMISSION HAD DISINTEGRATED. AS A RESULT, THE TRA…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE BEGAN TO SLOW DOWN INDEPENDENTLY AND CAME TO A COMPLETE STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A WAVE PLATE WITHIN THE TRANSMISSION HAD DISINTEGRATED. AS A RESULT, THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 117,500.
ONE OCTOBER 5, 2015 OWNER WAS DRIVING AT OR AROUND 35MPH WHEN THE VEHICLES, ESC, CHECK ENGINE LIGHT, AND BRAKE DASHBOARD ICONS CAME ON. THEN CAR THEN LOST ENGINE POWER, AND WOULD NOT ACCELERATE. OWNER THEN CRUISED THE CAR TO THE SIDE OF THE ROAD, WHERE TURNED THE KEY TO THE OFF POSITION AND THEN TRIED TO RESTART IT. OWNER TRIED …
Read full complaint
ONE OCTOBER 5, 2015 OWNER WAS DRIVING AT OR AROUND 35MPH WHEN THE VEHICLES, ESC, CHECK ENGINE LIGHT, AND BRAKE DASHBOARD ICONS CAME ON. THEN CAR THEN LOST ENGINE POWER, AND WOULD NOT ACCELERATE. OWNER THEN CRUISED THE CAR TO THE SIDE OF THE ROAD, WHERE TURNED THE KEY TO THE OFF POSITION AND THEN TRIED TO RESTART IT. OWNER TRIED TURNING THE KEY TO RESTART THE VEHICLE MULTIPLE TIMES OVER THE COURSE OF 15 MINUTES AND THE VEHICLE WOULD NOT START. FINALLY, THE VEHICLE RESTARTED AND THE OWNER WAS ABLE TO DRIVE OFF THE FREEWAY AND CONTACTED THE GM CUSTOMER SERVICE NUMBER TO REPORT THE INCIDENT.
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE SLIPPED GEARS AND STALLED. THE CONTACT ACTIVATED THE EMERGENCY BRAKES IN ORDER TO STOP THE VEHICLE SAFELY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SHIFT CABLE FRACTURED. THE VEHICLE WAS REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE VEHICLE SLIPPED GEARS AND STALLED. THE CONTACT ACTIVATED THE EMERGENCY BRAKES IN ORDER TO STOP THE VEHICLE SAFELY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SHIFT CABLE FRACTURED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 123, 000.
Official recalls
514V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
08V634000 · Visibility:defroster/defogger/hvac System
Dec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
Consequence & remedy
Consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.