IllustrationINTERMITTENTLY ALL DASH LIGHTS STAY ON WHEN STARTING THE CAR. ALSO THE RADIO/ CLOCK DOES NOT COME ON FOR APPROX. 60 SEC'S. DEALER WANTS TO REPLACE IGNITION SWITCH AND PASSLOCK SENSOR. THIS SEEMS TO BE A COMMON PROBLEM WITH THIS CAR. MANUFACTURER SHOULD BE RESPONSIBLE FOR REPAIRS. *NM
2001 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2001 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
430–25K
7125–50K
11850–75K
7675–100K
101100–150K
36150K+
445 reports with mileage · 276 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 285 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports1 fire reports22 injury reports
What owners actually said
721 reportsENGINE STOPS RUNNING, INSTRUMENTS DO NOT LIGHT UP, BOTH GAS AND TEMP GAUGE NEEDLES FALL BACK TO OFF POSITION. CAR CAN BE RESTARTED BY MOVING GEAR SELECTOR LEVER AND TWISTING IGNITION KEY TO ENGAGE STARTER. CAR ALSO IS AT TIMES HARD TO START. IF THE IGNITION KEY IS INSERTED AND TWISTED TO ON, SOMETIMES ICONS DO NOT LIGHT UP, NOR …
Read full complaint
ENGINE STOPS RUNNING, INSTRUMENTS DO NOT LIGHT UP, BOTH GAS AND TEMP GAUGE NEEDLES FALL BACK TO OFF POSITION. CAR CAN BE RESTARTED BY MOVING GEAR SELECTOR LEVER AND TWISTING IGNITION KEY TO ENGAGE STARTER. CAR ALSO IS AT TIMES HARD TO START. IF THE IGNITION KEY IS INSERTED AND TWISTED TO ON, SOMETIMES ICONS DO NOT LIGHT UP, NOR WILL THE GAUGES REGISTER,THE ENGINE WILL CRANK BUT NOT START. IF THE KEY IS TWISTED BACK TO THE OFF POSITION,THEN TWISTED BACK TO THE ON POSITION AND THE NEEDLES OF THE GAS AND TEMP GAUGES MOVE, THE ENGINE WILL START. THIS CAR IS 5 YEARS. OLD AND HAS 45,000 MI. ON THE SPEEDOMETER HAS HAPPENED SEVERAL TIMES,BUT SINCE THE ENGINE RESTARTS,IT HAS NOT BEEN TAKEN FOR REPAIRS. THE PCV VALVE HAS BEEN REPLACED, AND CAR HAS BEEN SUBJECTED TO THE STATE MANDATED TESTING,WHICH REQUIRES USE OF THE OBD PORT. THIS WAS LAST FALL. *JB
DT*: THE CONTACT STATED WITHOUT WARNING THE TURN SIGNALS HAVE BECOME INOPERABLE. THERE WAS A RECALL, #03V327000, CONCERNING THE HAZARD LIGHT SWITCH; HOWEVER, THE COMPONENT HAS FAILED AGAIN. THE DEALERSHIP HAS BEEN NOTIFIED, BUT THE VEHICLE WAS NOT SUBJECT TO THE RECALL ANY LONGER AND NO REPAIRS WERE MADE. UPDATED 03/28/06. …
Read full complaint
DT*: THE CONTACT STATED WITHOUT WARNING THE TURN SIGNALS HAVE BECOME INOPERABLE. THERE WAS A RECALL, #03V327000, CONCERNING THE HAZARD LIGHT SWITCH; HOWEVER, THE COMPONENT HAS FAILED AGAIN. THE DEALERSHIP HAS BEEN NOTIFIED, BUT THE VEHICLE WAS NOT SUBJECT TO THE RECALL ANY LONGER AND NO REPAIRS WERE MADE. UPDATED 03/28/06. *JB
I BOUGHT MY CAR WHEN IT WAS A YEAR OLD, SINCE BUYING THE CAR, I HAVE HAD TO PAY 800 DOLLARS TO HAVE THE IGNITION SWITCH CHANGED, WHICH I FOUND OUT LATER THE DEALERSHIP SHOULD HAVE ONLY CHARGED 400. I HAVE ALSO RESPONDED TO THE TURN SIGNAL RECALL TO HAVE THE HAZARD SWITCH FIXED ONLY TO HAVE THE SAME SWITCH GO OUT AGAIN, NOT EVEN …
Read full complaint
I BOUGHT MY CAR WHEN IT WAS A YEAR OLD, SINCE BUYING THE CAR, I HAVE HAD TO PAY 800 DOLLARS TO HAVE THE IGNITION SWITCH CHANGED, WHICH I FOUND OUT LATER THE DEALERSHIP SHOULD HAVE ONLY CHARGED 400. I HAVE ALSO RESPONDED TO THE TURN SIGNAL RECALL TO HAVE THE HAZARD SWITCH FIXED ONLY TO HAVE THE SAME SWITCH GO OUT AGAIN, NOT EVEN 2 YEARS LATER. I AM BEING TOLD THAT IT WILL COST AT LEAST 200.00 TO FIX. INSTEAD OF THE TURN SIGNALS NOT WORKING NOW THERE IS A CONSTANT CLICKING IN THE DASH, WHICH THEY SAID IS CAUSED BY THE HAZARD SWITCH BEING DEFECTIVE...IF THAT IS THE CASE THEN WHY WOULD THEY REPLACE THE ORIGINAL SWITCH WITH A DEFECTIVE ONE AND NOT REPLACE THE DEFECTIVE ONE? *NM
I TOOK MY 2001 CHEVY MALIBU LS IN TO GET THE OIL CHANGED. THE MECHANIC TOLD ME THAT A COMMON PROBLEM FOR THE GM ENGINES OF MY YEAR AND OTHERS WAS THE INTAKE MANIFOLD GASKET LEAKING COOLANT, AND THAT IF LEFT UN-FIXED, THE ENGINE WOULD EVENTUALLY SEIZE UP. I WAS TOLD THAT THE MATERIAL THAT THE GASKETS WERE MADE OUT OF HAS SINCE …
Read full complaint
I TOOK MY 2001 CHEVY MALIBU LS IN TO GET THE OIL CHANGED. THE MECHANIC TOLD ME THAT A COMMON PROBLEM FOR THE GM ENGINES OF MY YEAR AND OTHERS WAS THE INTAKE MANIFOLD GASKET LEAKING COOLANT, AND THAT IF LEFT UN-FIXED, THE ENGINE WOULD EVENTUALLY SEIZE UP. I WAS TOLD THAT THE MATERIAL THAT THE GASKETS WERE MADE OUT OF HAS SINCE BEEN CHANGED, WHICH WOULD IMPLY THAT THEY KNOW IT TO BE FAULTY. I CONTACTED GM AND TOOK IT INTO THE DEALER WHERE THEY CONFIRMED THE PROBLEM. I DON'T KNOW IF THIS ISSUE MAKES THE CAR UNSAFE TO DRIVE, BUT I HAD HEARD THAT THERE WAS A RECALL IN PLACE FOR FAULTY ALTERNATORS AND FIGURED THIS PROBLEM WAS ABOUT EQUAL TO THAT IN POTENTIAL DANGER. OUT OF CURIOSITY, I LOOKED ON THE INTERNET AND THERE ARE PLENTY OF WEBSITES WITH PEOPLE THAT HAVE THE SAME ISSUE. *JB
ON TWO OCCASIONS 2001 CHEVROLET MALIBU HAS FAILED TO START. *TS ***NO ANSWER REQUIRED*** THE VEHICLE WAS TAKEN TO THE DEALER TWICE. DIAGNOSTIC TEST WERE RUN BUT THE DEALER WAS UNABLE TO FIND A CAUSE FOR THE PROBLEM EITHER TIME. *NM
I HAVE HAD TO REPLACE MY 2001 CHEVY MALIBU'S MANIFOLD TWICE, AND I HAVE NOTICE THAT I AM NOT THE ONLY ONE. THIS IS NOT NORMAL WEAR AND TEAR THIS IS A MANUFACTURER DEFECT. *JB
THE VEHICLES HEAT GAUGE STOPPED WORKING AND LOW COOLANT LIGHT CAME ON. CHECKED COOLANT LEVEL AND DISCOVERED SLUDGE IN EXPANSION CHAMBER ( COOLANT RECOVERY TANK). FLUSHED SYSTEM OF SLUDGE AND TROUBLE SHOT REASON FOR COOLANT LOSS. FOUND INTAKE MANIFOLD GASKET LEAKING. VEHICLE WILL REQUIRE NEW INTAKE MANIFOLD GASKET SET, THERMOSTAT…
Read full complaint
THE VEHICLES HEAT GAUGE STOPPED WORKING AND LOW COOLANT LIGHT CAME ON. CHECKED COOLANT LEVEL AND DISCOVERED SLUDGE IN EXPANSION CHAMBER ( COOLANT RECOVERY TANK). FLUSHED SYSTEM OF SLUDGE AND TROUBLE SHOT REASON FOR COOLANT LOSS. FOUND INTAKE MANIFOLD GASKET LEAKING. VEHICLE WILL REQUIRE NEW INTAKE MANIFOLD GASKET SET, THERMOSTAT, HOSES, WATER PUMP AND POSSIBLY RADIATOR. TRIED TO FLUSH SYSTEM COMPLETELY BUT FOUND SECONDARY PLUMBING SUCH AS HEATER CORE, RADIATOR,COOLANT CROSSOVER AND COOLANT BLEED HOSING GUMMED UP WITH OILY WAXY TYPE SUBSTANCE RESEMBLING GUMBALLS (DEX-COOL?). I THINK GM SHOULD STEP UP TO THE PLATE AND TAKE RESPONSIBILITY FOR THE SO CALLED "WONDER COOLANT". AFTER ALL THE STICKER ON THE EXPANSION CHAMBER DOES SAY ANYTHING ABOUT CHANGING EVERY 5 YEARS OR 150000 MILES. *JB
(1) COOLANT LEAKING IMMEDIATELY AFTER PUTTING IT INTO MY VEHICLE. (2) MY CAR HAS OVERHEATED THREE TIMES ON THE FREEWAY. IT WILL NOT ACCELERATE, STARTS VIOLENTLY VIBRATING, THEN SMOKE BELLOWS OUT OF MY HOOD WHEN I FINALLY STOP. I HAVE BEEN STRANDED ON THE FREEWAY THREE TIMES WITH MY TWO-YEAR-OLD IN THE CAR, AS WELL AS MY UNBOR…
Read full complaint
(1) COOLANT LEAKING IMMEDIATELY AFTER PUTTING IT INTO MY VEHICLE. (2) MY CAR HAS OVERHEATED THREE TIMES ON THE FREEWAY. IT WILL NOT ACCELERATE, STARTS VIOLENTLY VIBRATING, THEN SMOKE BELLOWS OUT OF MY HOOD WHEN I FINALLY STOP. I HAVE BEEN STRANDED ON THE FREEWAY THREE TIMES WITH MY TWO-YEAR-OLD IN THE CAR, AS WELL AS MY UNBORN CHILD. (3) I HAVE TAKEN MY VEHICLE TO A CHEVROLET REPAIR MAN WHO FOUND A TECHNICAL SERVICE BULLETIN ON THE PROBLEM ISSUED BY CHEVROLET. HE EXPLAINED THE INTAKE MANIFOLD WAS MANUFACTURED CROOKED CAUSING COOLANT TO LEAK INTO MY ENGINE AND DILUTE MY OIL WHICH WILL EVENTUALLY BURN MY MOTOR AND RUIN IT COMPLETELY. WHEN I CONTACTED CHEVROLET, THEY WERE VERY UNHELPFUL BOTH TIMES STATING I HAD TO PAY A CHEVY DEALERSHIP TO DIAGNOSE THE PROBLEM AND THAT THEY MIGHT HELP ME WITH A LITTLE COST ASSISTANCE BUT NOT MUCH. IT IS ABOUT $600 TO FIX THIS PROBLEM THAT IS NOT NORMAL MAINTENANCE OR WEAR-AND-TEAR. IT IS A MANUFACTURING DEFECT. I HAVE HAD SEVERAL PEOPLE E-MAIL ME ABOUT THE SAME PROBLEM AFTER POSTING A COMMENT ABOUT IT ON A WEBSITE. *NM
I WENT OUT TO START MY CAR AND IT WOULD NOT START. HAD IT TOWED AND WAS INFORMED IT WAS THE ANTI-THEFT SYSTEM AGAIN. THE SAME THING HAPPENED BACK IN APRIL OF 2005 AND THE WHOLE SYSTEM HAD TO BE REPLACED WHICH WAS $300.00. THEY ARE HAVING TO REPLACING THE WHOLE SYSTEM AGAIN FOR $500.00. *NM
Official recalls
214V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V327000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available