Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
430–25K
7125–50K
11850–75K
7675–100K
101100–150K
36150K+
445 reports with mileage · 276 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 285 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports1 fire reports22 injury reports
What owners actually said
721 reports
213,000 miles · Jun 27, 2016
Electrical System
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT MADE A STARTING SOUND, BUT FAILED TO START. THE CONTACT HAD TO MAKE NUMEROUS ATTEMPTS TO START THE VEHICLE. ON SEVERAL OCCASIONS, THE CONTACT HAD TO WAIT FIVE MINUTES OR MORE BEFORE THE VEHICLE WOULD START. THE VEHICLE WAS NOT DIAGNOSED OR RE…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT MADE A STARTING SOUND, BUT FAILED TO START. THE CONTACT HAD TO MAKE NUMEROUS ATTEMPTS TO START THE VEHICLE. ON SEVERAL OCCASIONS, THE CONTACT HAD TO WAIT FIVE MINUTES OR MORE BEFORE THE VEHICLE WOULD START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 213,000.
NHTSA ODI #10876966
191 miles · Jun 13, 2016
Unknown Or Other
EVERYTIME I GO TO START MY CAR MY ANTI-THEFT SYSTEM KICKS ON AND I HAVE TO WAIT 15 XTRA MINS TO GET ANYWHERE
NHTSA ODI #10873830
156,000 miles · May 8, 2016
Electrical System
I OWN THE CHEVY MALIBU 2001- THE CAR SHUTS OFF WHILE IT IS DRIVING-THE THEFT LIGHT GOES ON AND THE CAR SHUTS DOWN. THERE WAS A RECALL FOR THE IGNITION PROBLEM WITH THIS CAR. I PAID $500 TO HAVE THE IGNITION MODULE REPLACED. ALSO, GM SENT ME A RECALL 14350-THE NEW CAR WORKED FOR A LITTLE BIT OF TIME BUT WITHIN THE LAST MONTH-TH…
Read full complaint
I OWN THE CHEVY MALIBU 2001- THE CAR SHUTS OFF WHILE IT IS DRIVING-THE THEFT LIGHT GOES ON AND THE CAR SHUTS DOWN. THERE WAS A RECALL FOR THE IGNITION PROBLEM WITH THIS CAR. I PAID $500 TO HAVE THE IGNITION MODULE REPLACED. ALSO, GM SENT ME A RECALL 14350-THE NEW CAR WORKED FOR A LITTLE BIT OF TIME BUT WITHIN THE LAST MONTH-THE PROBLEM IS WORSE THAN EVER.
NHTSA ODI #10863837
Mileage unknown · Apr 22, 2016
Exterior LightingUnknown Or OtherVehicle Speed Control
THEFT SYSTEM KEEPS COMING ON CAN'T START CAR COMES ON WHILE I DRIVE, TURN SIGNAL HAS A MIND OF ITS OWN WORKS WHEN IT WANTS TO,RPMS GO UP REAL HIGH WHILE I DRIVE AND WHEN IT PARK, TAKE FOOT OFF GAS PEDAL BUT CAR SEEMS TO SPEED UP KIND OF HARD TO STOP A CAR THAT SPEEDS UP WHEN NOT GIVING GAS TO IT, BREAK LIGHTS DON'T WORK WHEN TUR…
Read full complaint
THEFT SYSTEM KEEPS COMING ON CAN'T START CAR COMES ON WHILE I DRIVE, TURN SIGNAL HAS A MIND OF ITS OWN WORKS WHEN IT WANTS TO,RPMS GO UP REAL HIGH WHILE I DRIVE AND WHEN IT PARK, TAKE FOOT OFF GAS PEDAL BUT CAR SEEMS TO SPEED UP KIND OF HARD TO STOP A CAR THAT SPEEDS UP WHEN NOT GIVING GAS TO IT, BREAK LIGHTS DON'T WORK WHEN TURN SIGNAL DOESN'T WORK ALL THIS HAPPENS AS I AM DRIVING DOWN THE ROAD WITH MY TO SMALL CHILDREN AND OF COURSE IN MY DRIVEWAY WHEN THE CAR DOESN'T WANT TO START AS IT THINKS I'M STEALING MY CAR WITH THE KEY THEFT SYSTEM BREAK LIGHTS DON'T WORK WHEN TURN SIGNAL WON'T WORK EXCELS IN SPEED ON ITS OWN ALL STARTED IN MARCH 2016 AS I JUST BOUGHT IN FEBRUARY 2016.
NHTSA ODI #10861025
70,000 miles · Mar 14, 2016
Unknown Or Other
I HAVE A 2001 CHEVY MALIBU AND I HAVE BEEN HAVING A PROBLEM WITH MY TURN SIGNALS PERIODICALLY NOT WORKING. SOME DAYS THE SIGNAL WILL NOT WORK ONE TIME AND THEN THE VERY NEXT TIME IT WORKS. OTHER DAYS THE SIGNALS WILL NOT WORK AT ALL'BOTH THE RIGHT AND LEFT. I TURN THEM "ON" AND THEY JUST DON'T WORK. SOMETIMES IT WILL CLICK A FEW…
Read full complaint
I HAVE A 2001 CHEVY MALIBU AND I HAVE BEEN HAVING A PROBLEM WITH MY TURN SIGNALS PERIODICALLY NOT WORKING. SOME DAYS THE SIGNAL WILL NOT WORK ONE TIME AND THEN THE VERY NEXT TIME IT WORKS. OTHER DAYS THE SIGNALS WILL NOT WORK AT ALL'BOTH THE RIGHT AND LEFT. I TURN THEM "ON" AND THEY JUST DON'T WORK. SOMETIMES IT WILL CLICK A FEW TIMES AND THEN TURN OFF. THIS WILL LAST FOR ABOUT A DAY OR SO AND THEN THEY WORK OK FOR ABOUT A MONTH SOMETIMES LONGER. I CAN'T SEEM TO FIND A CORRELATION BETWEEN ANYTHING SUCH AS RAIN, USING IT A LOT, ETC. IT CAN'T BE THE BULB OR THE FUSE BECAUSE WHEN THEY DO WORK THEY BLINK AT THE NORMAL SPEED. ALSO THIS HAS BEEN GOING ON FOR YEARS. THE FIRST TIME IT HAPPENED I MADE AN APPOINTMENT TO HAVE IT LOOKED AT AND BEFORE THE APPOINTMENT THE BLINKER STARTED WORKING AGAIN, SO I CANCELED. I STARTED RESEARCHING ONLINE AND FOUND OUT THERE IS A RECALL FOR CARS MANUFACTURED IN 2001 WITH THIS SAME PROBLEM, THE RECALL NOTICE SAID THE HAZARD SWITCH NEEDS TO BE REPLACED. IT WAS SUGGESTED IN ONE ARTICLE WHEN THE SIGNALS STOP WORKING TO PUSH THE HAZARDS AND THE SIGNAL WILL START WORKING AND THAT'S EXACTLY WHAT HAPPENED FOR ME. I CAN FIDDLE WITH THE HAZARD AND GET THEM TO START WORKING. I CALLED MY LOCAL DEALER EXPLAINING THE PROBLEM WITH MY BLINKERS ONLY TO FIND OUT THAT MY VIN NUMBER FALLS OUTSIDE THAT RANGE. THIS IS A TRAVESTY. WHY IS IT ONLY SOME ARE BEING RECALLED AND REPAIRED WITH THE PROBLEM, BUT NOT ALL? HOW IS THIS DECIDED WHICH WILL BE RECALLED AND WHICH WILL NOT? I AM NOT SURE OF THE ACTUAL DATE THIS STARTED.
NHTSA ODI #10849667
Mileage unknown · Mar 14, 2016
Electrical System
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO TURN, THE VEHICLE STALLED AS SEVERAL UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT IT WAS THE FIRST OCCURRENCE OF THE FAILURE. THE CONTACT STATED THAT SHORTLY AFTER THE FAILURE, THE VEHICLE WO…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO TURN, THE VEHICLE STALLED AS SEVERAL UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT IT WAS THE FIRST OCCURRENCE OF THE FAILURE. THE CONTACT STATED THAT SHORTLY AFTER THE FAILURE, THE VEHICLE WOULD NO LONGER START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10846440
33,340 miles · Dec 11, 2015
Electrical System
FOR SOME REASON WHEN I, THE OWNER, GO TO START THE CAR IT GOES INTO A THEFT LOSS MODE AND THE CAR IS INOPERABLE FOR TEN MINUTES. THE CAR WAS MY PARENTS FOR 14 YEARS AND I FIRST HEARD ABOUT THE PROBLEM IN JULY 2014. THEN THE GARAGE CHANGED OUT FUEL PUMPS FOR MY MOTHER. I INHERITED THE CAR THIS SUMMER AND AM HAVING THIS THEFT LOSS…
Read full complaint
FOR SOME REASON WHEN I, THE OWNER, GO TO START THE CAR IT GOES INTO A THEFT LOSS MODE AND THE CAR IS INOPERABLE FOR TEN MINUTES. THE CAR WAS MY PARENTS FOR 14 YEARS AND I FIRST HEARD ABOUT THE PROBLEM IN JULY 2014. THEN THE GARAGE CHANGED OUT FUEL PUMPS FOR MY MOTHER. I INHERITED THE CAR THIS SUMMER AND AM HAVING THIS THEFT LOSS TRIGGERED SEVERAL TIMES A DAY. IT REQUIRES WAITING AT LEAST 10 MINUTES TILL ATTEMPTING A RESTART. THE VEHICLE WAS PARKED AND NOT BEING JOSTLED OR BUMPED, SO IT IS UNKNOWN WHEN OR WHY THIS "LOCK UP"OCCURS. INCREDIBLY ANNOYING!
NHTSA ODI #10809629
200,000 miles · Dec 7, 2015
Electrical System
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING AT ANY SPEED. THE FAILURE HAPPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBE…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING AT ANY SPEED. THE FAILURE HAPPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE FAILURE OCCURRED APPROXIMATELY FOUR TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10808787
Mileage unknown · Dec 5, 2015
Fuel/propulsion System
TAKATA RECALL. WHEN STARTING THE 2001 CHEVROLET MALIBU SOMETIMES THE ANTITHEFT SYSTEM PREVENTS IT FROM STARTING AND YOU HAVE TO TURN THE THE KEY OFF AND ON A FEW TIMES TO GET IT TO START. ALSO WHILE DRIVING THE CAR WILL TURN ITSELF OFF. THE CAR HAS TURNED ITSELF OF WHILE CROSSING A FOUR LANE SEVERAL TIMES AND JUST GOING DOWN TH…
Read full complaint
TAKATA RECALL. WHEN STARTING THE 2001 CHEVROLET MALIBU SOMETIMES THE ANTITHEFT SYSTEM PREVENTS IT FROM STARTING AND YOU HAVE TO TURN THE THE KEY OFF AND ON A FEW TIMES TO GET IT TO START. ALSO WHILE DRIVING THE CAR WILL TURN ITSELF OFF. THE CAR HAS TURNED ITSELF OF WHILE CROSSING A FOUR LANE SEVERAL TIMES AND JUST GOING DOWN THE ROAD. ONCE IT IS COASTED OFF THE ROAD IF ITS PUT IN PARK AND RESTARTED IT USUALLY STARTS BACK UP.
NHTSA ODI #10808595
Mileage unknown · Oct 20, 2015
Electrical System
2001 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEMS. *SMD THE CONSUMER STATED THE TUMBLER BECAME LOOSE AND TRIGGERED THE ANIT-THEFT AND THE VEHICLE WOULD NOT START. THE CONSUMER HAD TO WAIT SEVERAL MINUTES, BEFORE THE VEHICLE WOULD START. THE VEHICLE WAS TOWED TO A REPAIR SHOP, WHERE THE IGNITION S…
Read full complaint
2001 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEMS. *SMD THE CONSUMER STATED THE TUMBLER BECAME LOOSE AND TRIGGERED THE ANIT-THEFT AND THE VEHICLE WOULD NOT START. THE CONSUMER HAD TO WAIT SEVERAL MINUTES, BEFORE THE VEHICLE WOULD START. THE VEHICLE WAS TOWED TO A REPAIR SHOP, WHERE THE IGNITION SWITCH WAS REPLACED. THE CONSUMER RECEIVED A RECALL NOTICE. HOWEVER, THE DEALER STATED IT WAS FOR THE KEYS ONLY. *JB
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2001 Chevrolet Malibu Problems, Complaints & Recalls | Skip That Year
Illustration