NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
721 reports132,000 miles · Jul 22, 2010
Electrical System
I HAVE A 2001 MALIBU I BOUGHT BRAND NEW. IT WENT TO THE POINT WHERE IT JUST WONT START. WHAT'S HAPPENING IS THE THEFT SYSTEM LIGHT STARTS FLASHING. SO I HAVE TO SET 10 MINUTES WITH THE IGNITION LIGHTS ON AND THEN IT WILL START. BUT IT KEEPS HAPPENING, I WAS TOLD THE ONLY WAY TO FIX IT IS BY TAKING IT TO THE DEALER TO HAVE EXPEN…
Read full complaint
I HAVE A 2001 MALIBU I BOUGHT BRAND NEW. IT WENT TO THE POINT WHERE IT JUST WONT START. WHAT'S HAPPENING IS THE THEFT SYSTEM LIGHT STARTS FLASHING. SO I HAVE TO SET 10 MINUTES WITH THE IGNITION LIGHTS ON AND THEN IT WILL START. BUT IT KEEPS HAPPENING, I WAS TOLD THE ONLY WAY TO FIX IT IS BY TAKING IT TO THE DEALER TO HAVE EXPENSIVE WORK DONE ON IT, WHY WOULD CHEVROLET PUT A SYSTEM IN THAT IS THAT FAULTY. I SEEN ON LINE ITS ABOUT THE THEFT PASS OVER SYSTEM. THERE'S ALOT OF PEOPLE HAVING PROBLEMS WITH IT, IS THIS WHAT I GET TRUSTING CHEVROLET. *TR
NHTSA ODI #10344784
131,000 miles · Jul 11, 2010
Electrical System
2001 CHEVY MALIBU - PASSLOCK SYSTEM ENGAGES AT RANDOM TIMES CAUSING VEHICLE TO NOT START. LEAVING IGNITION KEY IN "ON" POSITION FOR TEN MINUTES WILL ALLOW THE VEHICLE TO START, BUT INCIDENT OCCURS REPEATEDLY. DEALER CANNOT DETERMINE CAUSE, SAYS THIS IS RATHER COMMON. *TR
NHTSA ODI #10342522
28,500 miles · Jun 23, 2010
Power Train
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THE VEHICLE WAS PARKED IN THE DRIVEWAY WITH THE KEY IN THE IGNITION AND THE VEHICLE TURNED OFF. HER THREE YEAR OLD CHILD WAS ABLE TO MOVE THE SHIFTER FROM PARK TO NEUTRAL AND THE VEHICLE PROCEEDED TO ROLL AWAY INTO HEAVY TRAFFIC. A CRASH DID NOT OCCUR. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THE VEHICLE WAS PARKED IN THE DRIVEWAY WITH THE KEY IN THE IGNITION AND THE VEHICLE TURNED OFF. HER THREE YEAR OLD CHILD WAS ABLE TO MOVE THE SHIFTER FROM PARK TO NEUTRAL AND THE VEHICLE PROCEEDED TO ROLL AWAY INTO HEAVY TRAFFIC. A CRASH DID NOT OCCUR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 28,500.
NHTSA ODI #10339763
103,957 miles · Jun 21, 2010
Electrical SystemVehicle Speed Control
INTERMITTENT ISSUE AT START WITH VEHICLE RPMS ELEVATING TO 3500, IF PUT INTO DRIVE THE VEHICLE SPEEDS TO 45 MPH. HAPPENS AT DIFFERENT TIMES (COLD, WARM, HOT). HAVE HAD IAC AND TPS SENSORS REPLACED (2 TIMES) AND MOST RECENTLY THE POWER CONTROL MODULE. EACH FIX WORKS FOR A FEW WEEKS, THEN ISSUE BEGINS AGAIN. MOST RECENTLY FREMONT …
Read full complaint
INTERMITTENT ISSUE AT START WITH VEHICLE RPMS ELEVATING TO 3500, IF PUT INTO DRIVE THE VEHICLE SPEEDS TO 45 MPH. HAPPENS AT DIFFERENT TIMES (COLD, WARM, HOT). HAVE HAD IAC AND TPS SENSORS REPLACED (2 TIMES) AND MOST RECENTLY THE POWER CONTROL MODULE. EACH FIX WORKS FOR A FEW WEEKS, THEN ISSUE BEGINS AGAIN. MOST RECENTLY FREMONT CHEVROLET HAD VEHICLE FOR 10 DAYS AND COULD NOT GET IT TO REPEAT; THEREFORE, COULD NOT HAVE COMPUTER READ OR PROVIDE PROBLEM AND REPAIR. NO SERVICE COMPLETED. *TR
NHTSA ODI #10339383
89,000 miles · Jun 20, 2010
Electrical System
2001 MALIBU SECURITY SYSTEM - FAILED TO ALLOW OWNER TO START THE CAR. REQUIRED 10 MINUTE WAIT TO RE-SET. ALSO FAILED. OWNER UNABLE TO DRIVE VEHICLE HOME FROM WORK LATE AT NITE. VERY DANGEROUS SITUATION. HAS OCCURRED NUMEROUS TIMES IN PAST SEVERAL MONTHS. DEALERS ONLY ABLE TO TEMPORARILY FIX PROBLEM AT HUGE COST. THERE ARE MANY, …
Read full complaint
2001 MALIBU SECURITY SYSTEM - FAILED TO ALLOW OWNER TO START THE CAR. REQUIRED 10 MINUTE WAIT TO RE-SET. ALSO FAILED. OWNER UNABLE TO DRIVE VEHICLE HOME FROM WORK LATE AT NITE. VERY DANGEROUS SITUATION. HAS OCCURRED NUMEROUS TIMES IN PAST SEVERAL MONTHS. DEALERS ONLY ABLE TO TEMPORARILY FIX PROBLEM AT HUGE COST. THERE ARE MANY, MANY PROBLEMS REPORTED ON THIS "SECURITY" SYSTEM. WHY ISN'T GM ORDERED TO RECALL AND REPAIR? *TR
NHTSA ODI #10339196
29,000 miles · Jun 10, 2010
Electrical System
MY 2001 CHEVY MALIBU HAS AN ANTI-THEFT SYSTEM FEATURE ON IT. HOWEVER IT DOESN'T READ MY KEY RIGHT AND MOST OF THE TIME WON'T START. AND WHEN IT DOES START IT WILL OUT OF NOWHERE SHUT OFF WHILE IM DRIVING. THIS IS REALLY DANGEROUS BECAUSE IF THIS HAPPENED ON THE HIGHWAY OR ON ANY ROAD REALLY, IT COULD CAUSE A SERIOUS ACCIDENT OR…
Read full complaint
MY 2001 CHEVY MALIBU HAS AN ANTI-THEFT SYSTEM FEATURE ON IT. HOWEVER IT DOESN'T READ MY KEY RIGHT AND MOST OF THE TIME WON'T START. AND WHEN IT DOES START IT WILL OUT OF NOWHERE SHUT OFF WHILE IM DRIVING. THIS IS REALLY DANGEROUS BECAUSE IF THIS HAPPENED ON THE HIGHWAY OR ON ANY ROAD REALLY, IT COULD CAUSE A SERIOUS ACCIDENT OR EVEN A FATALITY. THIS IS A SERIOUS MATTER AND THERE NEEDS TO BE A RECALL ON THIS VEHICLE. I HAVE DONE A LOT OF RESEARCH AND APPARENTLY EVERY OTHER MALIBU OWNER HAS THE EXACT SAME PASS-LOCK THEFT SYSTEM PROBLEM. IT ONLY TAKES A MATTER OF TIME. PLEASE INVESTIGATE THIS PROBLEM BECAUSE IT REALLY NEEDS TO BE FIXED THIS IS MY ONLY CAR AND I CANT AFFORD THIS THANK YOU. *TR
NHTSA ODI #10335748
73,300 miles · May 19, 2010
Electrical System
TL*THE CONTACT OWNS A 2001 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE LIGHTS ON THE INSTRUMENT PANEL TURNED OFF SUDDENLY. THE LIGHTS TURNED BACK ON AFTER A MINUTE. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 73,300. THE …
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE LIGHTS ON THE INSTRUMENT PANEL TURNED OFF SUDDENLY. THE LIGHTS TURNED BACK ON AFTER A MINUTE. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 73,300. THE CURRENT MILEAGE WAS 74,217.
NHTSA ODI #10331232
Mileage unknown · May 19, 2010
Electrical System
I HAVE A 2001 CHEVROLET MALIBU AND I HAVE BEEN CHECKING ONLINE FOR A REMEDY FOR THE THEFT SYSTEM THE THEFT SYSTEM COMES ON WHEN IT WANTS TO CAUSING ME TO BE STUCKON THE FREEWAY OFF RAMP FOR 10 MIN UNTIL IT STOPPED FLASHING AND BECAME SOLID, THE THEFT SYSTEM HAS PUT MY FAMILIES WELL BEING IN DANGER BELIEVE ME I LOVE THE CAR BUT I…
Read full complaint
I HAVE A 2001 CHEVROLET MALIBU AND I HAVE BEEN CHECKING ONLINE FOR A REMEDY FOR THE THEFT SYSTEM THE THEFT SYSTEM COMES ON WHEN IT WANTS TO CAUSING ME TO BE STUCKON THE FREEWAY OFF RAMP FOR 10 MIN UNTIL IT STOPPED FLASHING AND BECAME SOLID, THE THEFT SYSTEM HAS PUT MY FAMILIES WELL BEING IN DANGER BELIEVE ME I LOVE THE CAR BUT IT'S THEFT SYSTEM HAS BECOME A SAFETY HAZARD I HAVE HAD EMERGENCY'S AND HAD TO WAIT UNTIL THE THEFT SYSTEM STOPPED FLASHING IF YOU COULD HELP RESOLVE THE PROBLEM IT WOULD BE GREAT I DON'T WANT CHEVY TO LOSE A LIFETIME CUSTOMER I HAVE A 2YR OLD DAUGHTER TO WORRY ABOUT AND MY CAR STOPPING AND LOCKING UP IS A DANGER THANK YOU *TR
NHTSA ODI #10331214
161,000 miles · May 3, 2010
Electrical System
GM VATS 2001 CHEVY MALIBU THEFT LIGHT COMES ON AND CAR IS UNABLE TO START REPLACED THE IGNITION SWITCH AND THE PASSLOCK SENSOR WHICH IS SUPPOSE TO CORRECT THE PROBLEM WELL IT DID FOR ONLY A FEW MONTHS NOW I'M HAVING THE SAME PROBLEMS AGAIN. I DON'T HAVE THE MONEY NOR THE TIME TO KEEP REPEATING THIS FIX. AFTER READING NUMER…
Read full complaint
GM VATS 2001 CHEVY MALIBU THEFT LIGHT COMES ON AND CAR IS UNABLE TO START REPLACED THE IGNITION SWITCH AND THE PASSLOCK SENSOR WHICH IS SUPPOSE TO CORRECT THE PROBLEM WELL IT DID FOR ONLY A FEW MONTHS NOW I'M HAVING THE SAME PROBLEMS AGAIN. I DON'T HAVE THE MONEY NOR THE TIME TO KEEP REPEATING THIS FIX. AFTER READING NUMEROUS COMPLAINTS ONLINE ABOUT THIS PARTICULAR PROBLEM WHY HASN'T GM HAD A RECALL ON THIS PROBLEM. THIS IS BEYOND RIDICULOUS! *TR
NHTSA ODI #10328550
Mileage unknown · Mar 31, 2010
Unknown Or Other
REOCCURING ABS WARNING LIGHT ON DASHBOARD. THIS IS THE 3RD TIME WITH THE ABS LIGHT DISPLAYING. WE HAVE REPLACED THE BRAKES AND PADS, ROTOR AND HUB KIT TWICE FOR THIS ISSUE. THIS WILL BE THE THIRD TIME WE WILL HAVE TO REPLACE AND ALSO REPLACE THE WIRING HARNESS. DEALER UNABLE TO DEFINE IF THERE IS A SAFETY ISSUE OR TARGET THE…
Read full complaint
REOCCURING ABS WARNING LIGHT ON DASHBOARD. THIS IS THE 3RD TIME WITH THE ABS LIGHT DISPLAYING. WE HAVE REPLACED THE BRAKES AND PADS, ROTOR AND HUB KIT TWICE FOR THIS ISSUE. THIS WILL BE THE THIRD TIME WE WILL HAVE TO REPLACE AND ALSO REPLACE THE WIRING HARNESS. DEALER UNABLE TO DEFINE IF THERE IS A SAFETY ISSUE OR TARGET THE SPECIFIC PROBLEM OR WHAT THE POTENTIAL PROBLEM COULD BE. GENERAL MOTORS WILL NOT OFFER ANY ASSISTANCE EVEN TO INVESTIGATE THE ISSUE FOR POSSIBLE RECALL. THEY HAVE PLACED THE BURDEN OF RESPONSIBILITY ON THE OWNER.
NHTSA ODI #10322974
Official recalls
2Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration