NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
12 reportsClear category filter59,148 miles · Oct 7, 2014
Electrical SystemEquipmentVisibility
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BLOWER FOR THE AIR CONDITIONING SYSTEM MALFUNCTIONED AND THE POWER WINDOWS FAILED TO GO BACK UP AFTER BEING ROLLED DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEA…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BLOWER FOR THE AIR CONDITIONING SYSTEM MALFUNCTIONED AND THE POWER WINDOWS FAILED TO GO BACK UP AFTER BEING ROLLED DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,148. UPDATED 11/20/14*LJ *JS
NHTSA ODI #10641970
100,000 miles · May 22, 2014
Visibility
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW COULD NOT BE CLOSED. THE WINDOW WAS MANUALLY PULLED INTO THE CLOSED POSITION WHERE IT COULD NOT BE REOPENED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE PASSENGER SIDE WINDOW MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW COULD NOT BE CLOSED. THE WINDOW WAS MANUALLY PULLED INTO THE CLOSED POSITION WHERE IT COULD NOT BE REOPENED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE PASSENGER SIDE WINDOW MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10593471
120,000 miles · May 17, 2014
Visibility
DRIVING AT NIGHT WHEN IT STARTED RAINING. THE DRIVER'S WINDOW WAS DOWN. TRIED TO PUT IT UP WITH ELECTRONIC WINDOW BUTTON BUT IT WOULDN'T WORK. HAD TO GET OUT OF CAR AND MANUALLY GRAB ONTO THE WINDOW AND PULL IT UP. THE WINDOW CONTROL QUIT WORKING ALL OF A SUDDEN. THE MAIN CONTROL PANEL FOR THE WINDOW STILL WORKS FOR OTHER WINDOW…
Read full complaint
DRIVING AT NIGHT WHEN IT STARTED RAINING. THE DRIVER'S WINDOW WAS DOWN. TRIED TO PUT IT UP WITH ELECTRONIC WINDOW BUTTON BUT IT WOULDN'T WORK. HAD TO GET OUT OF CAR AND MANUALLY GRAB ONTO THE WINDOW AND PULL IT UP. THE WINDOW CONTROL QUIT WORKING ALL OF A SUDDEN. THE MAIN CONTROL PANEL FOR THE WINDOW STILL WORKS FOR OTHER WINDOWS IN CAR.. GM HAS PREVIOUSLY BEEN TOLD ABOUT THIS PROBLEM WITH MY CAR AND OTHERS. *JS
NHTSA ODI #10592159
88,000 miles · Sep 27, 2013
Electrical SystemVisibility
ALL ELECTRICAL WENT OUT INCLUDING RADIO,AIR CONDITIONER,POWER WINDOWS ...I HAD TO STOP AND PULL OFF ROAD AND CALL FOR HELP. THIS HAS HAPPENED OVER 5 TIMES AND DEALERS WILL NOT DO ANYTHING BUT LOOK AT ME. ALSO THE SECURITY SYSTEM WENT OUT AND I COULD NOT CRANK CAR AND SPENT $500 TO GET IT FIXED. *TR
NHTSA ODI #10545710
34,000 miles · Oct 7, 2005
Electrical SystemExterior LightingSeat Belts
DRIVER'S SIDE WINDOW SWITCH STALLS BEFORE ROLLING UP. TURN SIGNALS DO NOT WORK ALL THE TIME. INTERNAL FAN SWITCH ONLY WORKS ON 5. IF I TURN THE FAN SWITCH ON OR OFF, TURN SIGNALS WILL START WORKING INSTANTLY. TURN SIGNAL PROBLEM STARTED RIGHT AFTER THE BLOWER WENT OUT. I CANNOT LISTEN TO THE RADIO AND RUN THE REAR DEFROSTER AT T…
Read full complaint
DRIVER'S SIDE WINDOW SWITCH STALLS BEFORE ROLLING UP. TURN SIGNALS DO NOT WORK ALL THE TIME. INTERNAL FAN SWITCH ONLY WORKS ON 5. IF I TURN THE FAN SWITCH ON OR OFF, TURN SIGNALS WILL START WORKING INSTANTLY. TURN SIGNAL PROBLEM STARTED RIGHT AFTER THE BLOWER WENT OUT. I CANNOT LISTEN TO THE RADIO AND RUN THE REAR DEFROSTER AT THE SAME TIME. THE DRIVER'S SIDE SEAT BELT WILL NOT RELEASE ALL THE TIME WHEN I TRY TO PUT IT ON. THE CAR HAS DIED AS I TRIED TO TURN LEFT AT A STOP LIGHT. THIS WAS A USED CAR WITH LESS THAN 30K MILES WHEN I BOUGHT IT IN MARCH 2005, NO PROBLEMS UNTIL ABOUT MAY. NOW A PROBLEM A DAY SEEMS TO APPEAR. THE CAR NOW HAS 39K MILES ON IT AND MY HUSBAND WANTS ME TO TRADE IT IN ALREADY BECAUSE HE SAYS IT IS GOING TO "NICKEL AND DIME US TO DEATH". I HAVE SEEN SEVERAL OF THESE PROBLEMS ON RECALL SITES, BUT THE DEALER SAID THAT MY VIN WAS NOT INCLUDED IN THE RECALL. *JB
NHTSA ODI #10139046
55,003 miles · Mar 25, 2005
Visibility
MY 2001 CHEVROLET MALIBU DRIVER SIDE WINDOW SWITCH IS BAD. I WENT TO THE CHEVY PLACE IN MY AREA TO PRICE THE PART FOR IT AND THE GUY INDICATED TO ME THAT HE HAD MANY CHEVROLET MALIBU WINDOW SWITCHES THAT DID NOT WORK. *AK
NHTSA ODI #10114749
28,000 miles · Mar 18, 2005
Engine And Engine CoolingService Brakes, HydraulicVisibility
AT 36,370 MILES HAD TO REPLACE THE INTAKE MANIFOLD AND GASKET ON 2001 CHEVROLET MALIBU. *BF THE FRONT ROTORS WERE REPLACED AT 28,000 AND THE BLOWER ONLY WORKED ON HIGH SPEED. *JB
NHTSA ODI #10115753
Mileage unknown · Jan 15, 2004
EquipmentService Brakes, HydraulicStructure
** I DON'T HAVE ALL THE ABOVE INFO AVAILABLE AT THIS TIME. BOUGHT 11/01- HIT POTHOLE 12/01, REPLACED TWO PASSENGER WHEELS(BENT) AND COMPLAINED OF "THUMPING" NOISE. DEALER 2X CLAIMED NOT TO HEAR NOISE. CAR WOULD NOT START ON NUMEROUS OCCASSIONS STARTING 5/02. PAID 111.00 FOR RENTAL WHILE DEALER INSPECTED. DEALER FOUND …
Read full complaint
** I DON'T HAVE ALL THE ABOVE INFO AVAILABLE AT THIS TIME. BOUGHT 11/01- HIT POTHOLE 12/01, REPLACED TWO PASSENGER WHEELS(BENT) AND COMPLAINED OF "THUMPING" NOISE. DEALER 2X CLAIMED NOT TO HEAR NOISE. CAR WOULD NOT START ON NUMEROUS OCCASSIONS STARTING 5/02. PAID 111.00 FOR RENTAL WHILE DEALER INSPECTED. DEALER FOUND NOTHING. NEXT WEEK, FAILED TO START AGAIN, 800# TECH ADVICE TOLD ME ABOUT "ANTI-THEFT" WAS ACTING UP AND GAVE ME PROCEDURES TO START CAR. "ANTI-THEFT" SYSTEM HAS SINCE QUIT WORKING. AUTO IN "VERY MINOR" FENDER BENDER" IN 10/02, THAT WEEK DRIVER DOOR HINGE STARTED "CRACKLING", HANGING UP. INSURANCE COMPANY BODY SHOP SAID "NO RELATION" TO MINOR ACCIDENT. HINGE HAS COMPLETELY BROKEN AND NOT WORKING AT ALL SINCE THEN. 7/03 DRIVER POWER WINDOW "FELL DOWN" UPON ATTEMPT TO OPEN AS NORMAL WITH POWER BUTTON. OTHER PROBLEMS HAVE BEEN/ARE: REAR PASSENGER SPEAKER DOESN'T WORK, INTERIOR LIGHT DOESN'T ALWAYS WORK, "" BLINKERS/EMER. FLASHERS"" HAVE QUIT WORKING PROPERLY ABOUT 4 TO 6 MONTHS AGO. (THIS IS VERY DANGEROUS SINCE I LIVE 'UP' A BLIND DRIVEWAY ON A HIGH SPEED ROAD)?!! 1ST WEEK I HAD THE CAR I NOTICED MOTOR RATTLED PRETTY LOUDLY UPON START UP. QUESTIONED DEALER AND WAS TOLD THIS WAS "LIFTER BLEED DOWN" AND DEALER WAS WAITING ON GM FOR REMEDY, IF AVAILABLE. I BOUGHT THIS CAR AS USED WITH NEW WARRANTY IN PLACE, ABOUT 23,300 MILES ON 36/36000 NEW CAR WARRANTY AS WELL AS BOUGHT A 1500.00 EXTENDED 5YR/100000 WARR. ANY SUGGESTIONS, VERY TICKED OFF AND DON'T KNOW WHERE TO TURN.
NHTSA ODI #10070982
Mileage unknown · Apr 15, 2003
Engine And Engine CoolingPower TrainSeats
AFTER RESEARCHING THE SERVICE BULLETINS SECTION OF THIS WEBSITE, I HAVE COME TO REALIZE THAT I HAVE COMPLAINED/HAD SERVICED ABOUT 85% OF THE SAME PROBLEMS THAT ARE LISTED ON YOUR DATABASE. I PURCHASED THIS CAR NEW, FROM EVERETT CHEVROLET, WA IN 2000. SINCE THE PURCHASE. DATE, I HAD CHEVY DO THE FOLLOWING: NEW BRAKES (ALL THE W…
Read full complaint
AFTER RESEARCHING THE SERVICE BULLETINS SECTION OF THIS WEBSITE, I HAVE COME TO REALIZE THAT I HAVE COMPLAINED/HAD SERVICED ABOUT 85% OF THE SAME PROBLEMS THAT ARE LISTED ON YOUR DATABASE. I PURCHASED THIS CAR NEW, FROM EVERETT CHEVROLET, WA IN 2000. SINCE THE PURCHASE. DATE, I HAD CHEVY DO THE FOLLOWING: NEW BRAKES (ALL THE WAY AROUND - ONCE, FRONT ROTORS/PADS - TWICE), ALL NEW PISTONS, TRANSMISSION REPLACED, MISS ON #1 CYLINDER - REPLACED 1 FAILED SPARK PLUG, LEFT REAR DOOR SQUEAKS WHEN OPEN/SHUT - LUBED (HAS HAPPENED 3 TIMES NOW), FRONT LEFT NOISE FROM STRUTS/BRAKES - NOT ABLE TO VERIFY AS OF YET (POSSIBLE STRUT PROBLEM/LUBE), FAN IN DASHBOARD HAS A SOUND IN THE MIDDLE (JUST ABOVE THE CD PLAYER/RADIO) LIKE THERE IS A PIECE OF PAPER CAUGHT IN THE HOUSING (CONFIRMED AFTER 4 COMPLAINTS, FAULTY FAN MOTOR), PASSENGER FRONT SEAT SQUEAKS WHEN OCCUPIED (DEALERSHIPS HAVE NOT BEEN ABLE TO DUPLICATE./FIX), REARVIEW MIRROR RATTLES WHILE DRIVING AT HIGHWAY SPEEDS (TIGHTENED, STILL DOES IT IN HOT WEATHER). BOTTOM LINE, THIS IS MY FIRST NEW CAR PURCHASE AND I AM HAVING SERIOUS DOUBTS ABOUT KEEPING THE CAR - AS IT ONLY HAS 21,405 MILES ON IT. WITH THE 3/30 WARRANTY. COMING UP IN OCT. 2003, I AM VERY MUCH AFRAID THAT I HAVE PURCHASED A LEMON AND NOT LOOKING FORWARD TO SPENDING ANYMORE TIME/$$$ ON THIS VEHICLE. ANY SUGGESTIONS? *JB
NHTSA ODI #10014436
Mileage unknown · Dec 31, 2001
Engine And Engine CoolingSeatsService Brakes, Hydraulic
VEHICLE STALLS WHILE DRIVING, DEALER CAN NOT REMEDY THE PROBLEM, OIL PAN EXPERIENCED A LEAK, SERVICE ENGINE LIGHT AND CHECK ENGINE LIGHT ILLUMINATED. *SLC
NHTSA ODI #563879
Official recalls
2Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration