NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
25 reportsClear category filter82,000 miles · Dec 12, 2012
Vehicle Speed ControlFire
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED TO 80 MPH AS THE ENGINE RPMS INCREASED TO 4,000. THE CONTACT HAD TO COAST ONTO THE SHOULDER AND TURNED THE ENGINE OFF IN ORDER TO STOP THE VEHICLE. THE CONTACT THEN NOTICED SMOKE BEING EMITTED FROM THE ENGINE AREA. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED TO 80 MPH AS THE ENGINE RPMS INCREASED TO 4,000. THE CONTACT HAD TO COAST ONTO THE SHOULDER AND TURNED THE ENGINE OFF IN ORDER TO STOP THE VEHICLE. THE CONTACT THEN NOTICED SMOKE BEING EMITTED FROM THE ENGINE AREA. THE VEHICLE WAS TAKEN TO THE DEALER, WHO TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SEVERAL TIMES. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 82,000.
NHTSA ODI #10488136
40,000 miles · Nov 16, 2012
EngineService BrakesVehicle Speed Control
WHEN WE WOULD JUST START THE CAR IT WOULD REV UP TO BETWEEN 3000 TO 4000 RPM AND IT WOULD STAY THAT WAY. THIS WAS ONLY ONE WAY THAT IT WOULD ACT UP. THE OTHER WAYS WERE WHEN YOU WERE JUST DRIVING ALONG AND THE CAR WOULD START TO ACCELERATE ON IT'S OWN. BOTH WAYS YOU HAD TO RIDE THE BRAKE AND RIDE IT HARD IN ORDER NOT TO HIT THE…
Read full complaint
WHEN WE WOULD JUST START THE CAR IT WOULD REV UP TO BETWEEN 3000 TO 4000 RPM AND IT WOULD STAY THAT WAY. THIS WAS ONLY ONE WAY THAT IT WOULD ACT UP. THE OTHER WAYS WERE WHEN YOU WERE JUST DRIVING ALONG AND THE CAR WOULD START TO ACCELERATE ON IT'S OWN. BOTH WAYS YOU HAD TO RIDE THE BRAKE AND RIDE IT HARD IN ORDER NOT TO HIT THE PERSON IN FRONT OF US. WE HAD IT IN TO ONE DEALER TWICE WITH NOTHING GETTING FIXED. WE TOOK IT TO A DIFFERENT DEALER THREE TIMES, THEY RANDOMLY REPLACED DIFFERENT THINGS (GUESSING) AT OUR COST, BUT PROBLEM STILL PERSISTED. WE EVEN TOOK IT IN WHEN IT WAS REVVING UP TO 3000 RPM, WHILE THEY WERE UNDER THE HOOD IT EVEN WENT HIGHER! WE WERE TOLD TO TURN IT OFF BECAUSE THEY WERE AFRAID IT WOULD BLOW, BUT WHEN WE CAME BACK TO PICK IT UP THEY SAID THAT IT DIDN'T HAPPEN AGAIN AND THEY COULDN'T FIX IT IF IT DIDN'T DO IT FOR THEM AGAIN. THEY TOLD US THAT THE BEST THING FOR US TO DO WAS TO TRADE THE CAR IN ON A DIFFERENT VEHICLE, WE TOLD HIM THAT THIS THING IS A PROBLEM THAT SHOULD BE TAKEN CARE OF AND NOT JUST TRADED IN. WE CONTACTED GM AND TOLD THEM THAT THIS IS A PROBLEM THAT CAN CAUSE SERIOUS HARM NOT ONLY TO MY WIFE AND MYSELF BUT TO OTHERS. GM DID NOTHING TO ASSIST WITH THE PROBLEM. THEY SAID THAT IF THE DEALER COULDN'T FIX IT THAT THEY COULDN'T HELP US. THEY WOULDN'T EVEN CONTACT THE DEALERS TO SEE WHAT THE PROBLEMS WERE. WE HAVE APPROX. 116,000 MILES AND IT NOW HAS ADDITIONAL PROBLEMS WITH THE ACCELERATION. WE STILL HAVE THE CAR BECAUSE WE CAN'T AFFORD ANOTHER AT THIS TIME, BUT I FEEL LIKE I'M DRIVING A TIME BOMB. *TR
NHTSA ODI #10484980
118,000 miles · Jun 14, 2012
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER SHIFTING INTO PARK, TURNING OFF THE IGNITION AND EXITING THE VEHICLE, IT SUDDENLY ACCELERATED AND CRASHED INTO A BUILDING. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER SHIFTING INTO PARK, TURNING OFF THE IGNITION AND EXITING THE VEHICLE, IT SUDDENLY ACCELERATED AND CRASHED INTO A BUILDING. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT INSPECTED FOR THE CAUSE OF THE ACCELERATION FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 118,000.
NHTSA ODI #10461807
103,957 miles · Jun 21, 2010
Electrical SystemVehicle Speed Control
INTERMITTENT ISSUE AT START WITH VEHICLE RPMS ELEVATING TO 3500, IF PUT INTO DRIVE THE VEHICLE SPEEDS TO 45 MPH. HAPPENS AT DIFFERENT TIMES (COLD, WARM, HOT). HAVE HAD IAC AND TPS SENSORS REPLACED (2 TIMES) AND MOST RECENTLY THE POWER CONTROL MODULE. EACH FIX WORKS FOR A FEW WEEKS, THEN ISSUE BEGINS AGAIN. MOST RECENTLY FREMONT …
Read full complaint
INTERMITTENT ISSUE AT START WITH VEHICLE RPMS ELEVATING TO 3500, IF PUT INTO DRIVE THE VEHICLE SPEEDS TO 45 MPH. HAPPENS AT DIFFERENT TIMES (COLD, WARM, HOT). HAVE HAD IAC AND TPS SENSORS REPLACED (2 TIMES) AND MOST RECENTLY THE POWER CONTROL MODULE. EACH FIX WORKS FOR A FEW WEEKS, THEN ISSUE BEGINS AGAIN. MOST RECENTLY FREMONT CHEVROLET HAD VEHICLE FOR 10 DAYS AND COULD NOT GET IT TO REPEAT; THEREFORE, COULD NOT HAVE COMPUTER READ OR PROVIDE PROBLEM AND REPAIR. NO SERVICE COMPLETED. *TR
NHTSA ODI #10339383
158,214 miles · Mar 30, 2010
Vehicle Speed Control
WHEN I TAKE MY FOOT OFF THE GAS PEDAL MY CAR KEEPS ACCELERATING. FROM A STOP IT WILL ACCELERATE TO 45 MPH WITHOUT ME TOUCHING GAS PEDAL. ON THE FREEWAY IT KEEPS ACCELERATING UNTIL I BRAKE.THIS CONDITION IS INTERMITTENT AND CAN BE CANCELED BY ME TURNING OFF CAR AND RESTARTING THE ENGINE. I HAVE A 2001 CHEVY MALIBU
NHTSA ODI #10322922
65,676 miles · Feb 9, 2010
Vehicle Speed Control
APPROXIMATELY THE FIRST OF JULY 2007 OUR VEHICLE BEGAN ACCELERATING RAPIDLY. MY HUSBAND HAD TO APPLY THE BRAKES TO STOP THE SPEED. EVEN WITH HIS FOOT OFF THE GAS PEDAL, IT WOULD ACCELERATE UP TO 65 MPH AND HE HAD TO APPLY THE BRAKES VERY STRONGLY TO SLOW IT DOWN. WHEN HE WOULD TAKE HIS FOOT OFF THE BRAKES, IT WOULD CONTINUE TO A…
Read full complaint
APPROXIMATELY THE FIRST OF JULY 2007 OUR VEHICLE BEGAN ACCELERATING RAPIDLY. MY HUSBAND HAD TO APPLY THE BRAKES TO STOP THE SPEED. EVEN WITH HIS FOOT OFF THE GAS PEDAL, IT WOULD ACCELERATE UP TO 65 MPH AND HE HAD TO APPLY THE BRAKES VERY STRONGLY TO SLOW IT DOWN. WHEN HE WOULD TAKE HIS FOOT OFF THE BRAKES, IT WOULD CONTINUE TO ACCELERATE. THIS DID NOT HAPPEN 100% OF THE TIME, BUT WAS MORE APT TO HAPPEN AFTER THE VEHICLE HAD WARMED UP. IT DID NOT CAUSE AN ACCIDENT, DUE TO HIS CAREFUL DRIVING. WE TOOK IT IN TO THE REPAIR GARAGE ON 7-24-07 AND THEY DETERMINED THAT THE THROTTLE POSITION SENSOR WAS FAULTY AND NEEDED REPLACING WHICH THEY DID AND WE HAVE NOT HAD ANY PROBLEM WITH IT SINCE THEN. WE THOUGHT WE SHOULD REGISTER THIS COMPLAINT IN CASE OTHER LIKE VEHICLES HAVE HAD THIS SAME PROBLEM. *TR
NHTSA ODI #10308144
12,000 miles · Oct 26, 2007
EquipmentVehicle Speed Control
TL*THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE DRIVER SIDE FLOOR MAT SLIDES BACK AND FORTH. THE FLOOR MAT BLOCKS BOTH THE ACCELERATOR AND BRAKE PEDALS. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 41,000. UPDATED 3/5/08 *CN THE CONSUMER STATED THE PROBLEM PERSIST…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET MALIBU. THE DRIVER SIDE FLOOR MAT SLIDES BACK AND FORTH. THE FLOOR MAT BLOCKS BOTH THE ACCELERATOR AND BRAKE PEDALS. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 41,000. UPDATED 3/5/08 *CN THE CONSUMER STATED THE PROBLEM PERSISTS UNLESS MATS ARE REPOSITIONED WITH EACH ENTRY AND DEALER ADVISED CONSUMER NO OTHER COMPLAINTS ABOUT THE DEFECT. THE CONSUMER FURTHER STATED TO BUY NEW MATS AT THE TUNE OF $48.00 TO SOLVE THE PROBLEM. UPDATED 03/05/08 *TR
NHTSA ODI #10207010
77,450 miles · Aug 5, 2007
Vehicle Speed Control
WAS DRIVING CAR JUST PULLED OFF FROM A RED LIGHT MAKING A LEFT TURN AND CAR STARTED TO PULL FORWARD THEN COULD NOT STEER MYSELF WENT OFF ROAD ALMOST INTO TREES THEN JERKED ITSELF LEFT PULLING BACK TO ROAD AND ONTO ONCOMING TRAFFIC THEN STOPPED WAS ABLE TO DRIVE HOME SLOWLY W/ HAZARDS ON. 2ND INCIDENT WAS DRIVING AND CAR STARTED …
Read full complaint
WAS DRIVING CAR JUST PULLED OFF FROM A RED LIGHT MAKING A LEFT TURN AND CAR STARTED TO PULL FORWARD THEN COULD NOT STEER MYSELF WENT OFF ROAD ALMOST INTO TREES THEN JERKED ITSELF LEFT PULLING BACK TO ROAD AND ONTO ONCOMING TRAFFIC THEN STOPPED WAS ABLE TO DRIVE HOME SLOWLY W/ HAZARDS ON. 2ND INCIDENT WAS DRIVING AND CAR STARTED TO PULL /JERK FORWARD FAST TRIED TO PUT ON BRAKES AND WAS VERY DIFFICULT TO BRING CAR TO A STOP ALMOST FELT LIKE WAS NOT GOING TO STOP W/ALL MY PRESSURE APPLYING TO BRAKES WAS STILL HARD TO STOP CAR. ALL 4 INCIDENTS WERE SIMILAR IN THAT CAR KIND OF TOOK OFF ON IT'S OWN AND WAS NOT CONTROLLABLE AS FAR AS STEERING OR BRAKING. THIS CAR IS IN LOCAL CHEVROLET DEALERSHIP FOR LAST FEW DAYS FOR THEM TO FIND/CORRECT THIS PROBLEM OUR DAUGHTER IS DRIVING THIS CAR AND IT'S NOT SAFE RIGHT NOW FOR HER TO DRIVE. THE DEALERSHIP CAN NOT FIND THE PROBLEM. FIRST THEY THOUGHT ANTI LOCK BRAKES HAD A GLITCH, OR THE TRANSMISSION,BUT CAR IS NOT DOING THIS WHEN THEY TAKE FOR SHORT DRIVES AND THEY CAN NOT PIN POINT THIS PROBLEM. ,BUT THERE IS MOST CERTAINLY A PROBLEM. I DO NOT WANT MY CHILD TO GET HURT OR WORSE DRIVING THIS VEHICLE B/C NO ONE CAN DETECT THE PROBLEM. ALSO CAR HAD A BURNING RUBBERY/LIKE A BELT SMELL BEFORE AT LEAST 2 OF THESE INCIDENTS. ALL BELTS CHECK OUT OK. NO PROBLEMS. I HAVE A RELATIVE THAT HAD A CHEV VAN THAT IN LAST YEAR OR SO CAR BASICALLY TOOK OFF ON IT'S OWN AT A SPEED OF 50MPH. COULD NOT STOP VEHICLE WAS PUTTING ALL WEIGHT PRESSURE ON BRAKE CAR FINALLY CAME TO A STOP. PROB WOUND UP BEING A COMPUTER CHIP IN TRANSMISSION TRIGGERED THE CRUISE CONTROL COMPUTER CHIP TRANSMISSION HAD TO BE CHANGED . PLEASE CHECK INTO THIS TO SEE IF RELATED TO OUR ISSUE. THANK YOU. *JB
NHTSA ODI #10198551
47,000 miles · Jul 1, 2006
Vehicle Speed Control
WHILE WAITING AT A TRAFFIC LIGHT TO MAKE A LEFT TURN, THE ENGINE REVVED UP TO ITS MAXIMUM SPEED. LUCKILY MY HUSBAND WAS DRIVING AND WAS ABLE TO MAKE IT AROUND THE CORNER AND OFF THE ROAD. THE ONLY WAY BESIDES THE BRAKE TO SLOW THE ENGINE WAS TURNING IT OFF. WHEN HE CHECKED HE FOUND THE ACCELERATOR CABLE HAD COME OUT OF THE CL…
Read full complaint
WHILE WAITING AT A TRAFFIC LIGHT TO MAKE A LEFT TURN, THE ENGINE REVVED UP TO ITS MAXIMUM SPEED. LUCKILY MY HUSBAND WAS DRIVING AND WAS ABLE TO MAKE IT AROUND THE CORNER AND OFF THE ROAD. THE ONLY WAY BESIDES THE BRAKE TO SLOW THE ENGINE WAS TURNING IT OFF. WHEN HE CHECKED HE FOUND THE ACCELERATOR CABLE HAD COME OUT OF THE CLIP ON THE TOP OF THE ENGINE. (THERE ARE TWO WIRES SIDE BY SIDE. THE FRONT ONE--ACCELERATOR--WAS THE ONE THAT CAME OUT) SINCE HE PUSHED IT BACK IN PLACE IT HAS BEEN FINE, BUT IT CAN BE A VERY DANGEROUS THING TO HAPPEN. HE HAS TAPED THE WIRE IN PLACE JUST IN CASE. *JB
NHTSA ODI #10161202
75,000 miles · Nov 30, 2005
Vehicle Speed Control
DT: THE CONTACT STATED THE VEHICLE CONTINUED TO ACCELERATE AFTER RELEASING THE GAS PEDAL. THE FIRST TIME WHEN THE PROBLEM OCCURRED THE VEHICLE WORKED PROPERLY AFTER TAPPING THE GAS PEDAL. AFTER THE THIRD TIME THE VEHICLE WAS TAKEN TO A DEALERSHIP, WHO DETERMINED THAT THE PROBLEM WAS THE THROTTLE STICKING. THE VEHICLE…
Read full complaint
DT: THE CONTACT STATED THE VEHICLE CONTINUED TO ACCELERATE AFTER RELEASING THE GAS PEDAL. THE FIRST TIME WHEN THE PROBLEM OCCURRED THE VEHICLE WORKED PROPERLY AFTER TAPPING THE GAS PEDAL. AFTER THE THIRD TIME THE VEHICLE WAS TAKEN TO A DEALERSHIP, WHO DETERMINED THAT THE PROBLEM WAS THE THROTTLE STICKING. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. *AK
NHTSA ODI #10144077
Official recalls
2Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration