IllustrationI TURN MY KEY YO TURN OFF MY CAR IN IT WANT GO PASS THE ACC.
2004 Chevrolet Malibu Classic
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu Classic years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1325–50K
1350–75K
1575–100K
33100–150K
14150K+
92 reports with mileage · 24 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports7 injury reports
What owners actually said
116 reportsTHE THEFT SYSTEM LIGHT HAS BEEN AN ISSUE WITH THIS CAR FOR SOME TIME. THE THEFT SYSTEM LIGHT COMES ON AND STAYS ON BY ITSELF AS WELL THE SYSTEMS MAKES THE HORN HONK WHEN OPENING OR CLOSING THE CAR DOOR. THE THEFT SYSTEM HAS MADE IT SO THAT I CANNOT START MY CAR & THIS HAS BEEN AN ON GOING PROBLEM WITH MY CAR.
DUE TO THE PASSLOCK SENSOR INSIDE THE IGNITION LOCK CYLINDER CASE FAILURE, THE VEHICLE WILL STALL AT ANY MOMENT AND ANYWHERE, WHICH MAKES MORE LIKELY TO BE INVOLVED IN A WRECK BECAUSE OF THIS. GM STATED THAT THE PROBLEM WITH THE VEHICLE STALLING WAS DUE TO THE KEY COMING OUT FROM THE IGNITION CYLINDER. GM ADDED WEIGHT TO THE PLA…
Read full complaint
DUE TO THE PASSLOCK SENSOR INSIDE THE IGNITION LOCK CYLINDER CASE FAILURE, THE VEHICLE WILL STALL AT ANY MOMENT AND ANYWHERE, WHICH MAKES MORE LIKELY TO BE INVOLVED IN A WRECK BECAUSE OF THIS. GM STATED THAT THE PROBLEM WITH THE VEHICLE STALLING WAS DUE TO THE KEY COMING OUT FROM THE IGNITION CYLINDER. GM ADDED WEIGHT TO THE PLASTIC PORTION OF THE KEY AS A SOLUTION TO THE PROBLEM BUT THE REAL PROBLEM FOR THE VEHICLE TO STALL IS NOT THAT, IT IS DUE TO THE FAILURE OF THE PASSLOCK SENSOR.
ENDS OF HOLLOW SWAY BAR BROKE OFF AFFECTING CONTROL. MECHANIC SAID IT WAS A COMMON PROBLEM AND SHOULD HAVE HAD A RECALL.
I TURN MY CAR ON DRIVE GO TO GET OUT THE KEY WON'T COME OUT SOMETIMES IT DOES AND MOST TIME IS DOESN'T. I TRY TURN THE CAR BACK ON PUTTING THE CAR IN DRIVE THEN PARK AND TURNING THE KEY TO OFF POSITION AND THE CAR STILL DOESN'T GO INTO THE PARK POSITION SO THE KEY DOESN'T GO INTO OFF POSITION TO TAKE KEY OUT. THE CAR STAYS ON …
Read full complaint
I TURN MY CAR ON DRIVE GO TO GET OUT THE KEY WON'T COME OUT SOMETIMES IT DOES AND MOST TIME IS DOESN'T. I TRY TURN THE CAR BACK ON PUTTING THE CAR IN DRIVE THEN PARK AND TURNING THE KEY TO OFF POSITION AND THE CAR STILL DOESN'T GO INTO THE PARK POSITION SO THE KEY DOESN'T GO INTO OFF POSITION TO TAKE KEY OUT. THE CAR STAYS ON WITHOUT THE IGNITION BEING ON. THE CAR IS STATIONARY BUT THE CAR WON'T GO INTO PARK TO TURN THE CAR COMPLETELY OFF. SPOKE TO GM PROBLEM WITH TRANSMISSION SHIFT CABLE BUT THEY WON'T HELP ME. THE KEEP SAYING THERE IS NO RECALL FOR MY CAR. THERE WAS A RECALL FOR THIS GM'S RECALL 14152. PLEASE HELP. THANK YOU!
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND WAS UNABLE TO BE RESTARTED. THE SECURITY PASS LOCK AND ANTI-LOCK WARNING INDICATORS RANDOMLY FLASHED INTERMITTENTLY. THE VEHICLE BEGAN TO STALL AT RANDOM. THE VEHICLE WAS DIAGNOSED BY A MECHANIC WHO STATED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND WAS UNABLE TO BE RESTARTED. THE SECURITY PASS LOCK AND ANTI-LOCK WARNING INDICATORS RANDOMLY FLASHED INTERMITTENTLY. THE VEHICLE BEGAN TO STALL AT RANDOM. THE VEHICLE WAS DIAGNOSED BY A MECHANIC WHO STATED THAT THE FUEL PUMP REGULATOR FAILED. THE VEHICLE WAS REPAIRED, BUT CONTINUED TO STALL. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
REC'D RECALL ON IGNITION SWITCH. TOOK VEHICLE TO DEALER AND SERVICE REP TOOK 1OF MY VEHICLE KEYS, BROUGHT KEY BACK AND SAID REPAIR COMPLETES. NEVER DID HE TOUCH MY CAR. IMMEDIATELY AFTER THIS, VEHICLE WOULDN'T START. WHATEVER WAS DONE TO MY KEY THREW OFF MY ALARM SYSTEM AND LOCKED UP VEHICLE .DEALER REFUSED TO TAKE RESPONSIBILIT…
Read full complaint
REC'D RECALL ON IGNITION SWITCH. TOOK VEHICLE TO DEALER AND SERVICE REP TOOK 1OF MY VEHICLE KEYS, BROUGHT KEY BACK AND SAID REPAIR COMPLETES. NEVER DID HE TOUCH MY CAR. IMMEDIATELY AFTER THIS, VEHICLE WOULDN'T START. WHATEVER WAS DONE TO MY KEY THREW OFF MY ALARM SYSTEM AND LOCKED UP VEHICLE .DEALER REFUSED TO TAKE RESPONSIBILITY. CONTACTED GM AND WAS CONTACTED BACK. THEY MADE NOTE OF COMPLAINT. NOW WATCHING C CNBC AND THE IGNITION RECALL. I AM CONCERNED AS ONLY 1KEY WAS TOUCHED BY DEALER AND THAT WAS IT.
TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE DRIVER LOST CONTROL OF THE VEHICLE, DROVE DOWN AN EMBANKMENT, AND CRASHED INTO A CREEK. DURING THE CRASH, THE FRONT END OF THE VEHICLE SUSTAINED SIGNIFICANT DAMAGE. THE AIR BAGS DID NOT DEPLOY AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROY…
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE DRIVER LOST CONTROL OF THE VEHICLE, DROVE DOWN AN EMBANKMENT, AND CRASHED INTO A CREEK. DURING THE CRASH, THE FRONT END OF THE VEHICLE SUSTAINED SIGNIFICANT DAMAGE. THE AIR BAGS DID NOT DEPLOY AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 195,000.
VEHICLE WAS PARKED. KEY WILL TURN, THE ENGINE WILL CRANK BUT WILL NOT START. MECHANIC CHECKED THE VEHICLE ON SITE AND HAD TO BE PULLED TO THE MECHANIC'S SHOP. MECHANIC DISCOVERED THAT ANTI THEFT SYSTEM WAS ON. THE ISSUE WAS FIXED. AMOUNT OF REPAIR WAS ABOUT 100 DOLLARS.
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING, THE THEFT SYSTEM WARNING LIGHT ILLUMINATED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO MANEUVER OFF THE ROAD AND SHUT THE VEHICLE OFF. THE CONTACT WAS ABLE TO RESTART THE ENGINE AFTER RESETTING THE THEFT SYSTEM. THE VEHICLE WAS NOT D…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING, THE THEFT SYSTEM WARNING LIGHT ILLUMINATED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO MANEUVER OFF THE ROAD AND SHUT THE VEHICLE OFF. THE CONTACT WAS ABLE TO RESTART THE ENGINE AFTER RESETTING THE THEFT SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
Official recalls
114V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA04018 · Loss Of Electric Power Steering
Opened Jul 1, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Additional source detail variants (2)
Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Steering
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)