Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
825–50K
1350–75K
1675–100K
21100–150K
12150K+
72 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports6 fire reports6 injury reports
What owners actually said
223 reports
Mileage unknown · Nov 19, 2002
Fuel System, Gasoline
THE CONSUMER STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER ON NUMEROUS OCCASIONS WHILE GOING UPHILL OR PASSING. THE VEHICLE WAS TAKEN TO A SHOP AND THE FUEL FILTER WAS REPLACED-THIS DIDN'T REMEDY THE PROBLEM. DURING A 600 MILE TRIP, THE CONSUMER HEARD A HIGH PITCHED NOISE COMING FROM THE LEFT REAR UNDERSIDE. THIS ONLY H…
Read full complaint
THE CONSUMER STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER ON NUMEROUS OCCASIONS WHILE GOING UPHILL OR PASSING. THE VEHICLE WAS TAKEN TO A SHOP AND THE FUEL FILTER WAS REPLACED-THIS DIDN'T REMEDY THE PROBLEM. DURING A 600 MILE TRIP, THE CONSUMER HEARD A HIGH PITCHED NOISE COMING FROM THE LEFT REAR UNDERSIDE. THIS ONLY HAPPENED WHEN THE ENGINE WAS RUNNING. IT HAD BECOME APPARENT TO THE CONSUMER THAT THE PROBLEM COULD BE FROM THE FUEL PUMP OR FILTER SOCK. THE GAS TANK WAS CHECKED FOR DIRTY GAS, BUT THE FUEL TANK LIQUID WAS CLEAN. THE FUEL PUMP/FILTER WAS REPLACED AND REMEDIED THE PROBLEM, UPON INSPECTION OF THE FUEL PUMP THE CONSUMER NOTICED THAT THE PUMP HAD A LABEL AFFIXED TO IT'S SIDE, THE LABEL HAD PARTIALLY MELTED AND THE RESIDUE HAD RUN INTO THE FILTER SOCK WHICH PROBABLY CAUSED THE LOSS OF POWER. *SCC *NLM
NHTSA ODI #568337
Mileage unknown · Oct 24, 2002
Fuel System, Gasoline
CONSUMER NOTICED THE CONTAINER GAS TANK IS RUSTED.*TS CONSUMER WAS INFORMED BY MANUFACTURER THAT THE GAS TANK IS ON NATIONAL BACK ORDER.*JB
NHTSA ODI #8021545
Mileage unknown · Oct 22, 2002
Fuel System, Other
CONSUMER STATES GAS TANK LEAKS, CANT FILL UP BECAUSE GAS LEAKS OUT. TOOK TO CHEVROLET AND THEY CANT GET A NEW GAS TANK. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
NHTSA ODI #8021352
Mileage unknown · Sep 28, 2002
Power Train
TRANSMISSION FAILURE OCCURRED DO TO PRESSURE BUILD UP IN TRANMISSION HOUSING CAUSING THE TOP OF THE HOUSING TO CRACK. TRANSMISSION HAD MASSIVE FLUID LEAK AND DEBRIS WAS FLOATING IN TRANSMISSION. DEBRIS DAMAGED GEARING IN TRANMISSION AND CAUSING IT TO BE REPLACED. COST TO REPLACE TRANSMISSION WAS $1997.37. I AM CURRENTLY IN C…
Read full complaint
TRANSMISSION FAILURE OCCURRED DO TO PRESSURE BUILD UP IN TRANMISSION HOUSING CAUSING THE TOP OF THE HOUSING TO CRACK. TRANSMISSION HAD MASSIVE FLUID LEAK AND DEBRIS WAS FLOATING IN TRANSMISSION. DEBRIS DAMAGED GEARING IN TRANMISSION AND CAUSING IT TO BE REPLACED. COST TO REPLACE TRANSMISSION WAS $1997.37. I AM CURRENTLY IN CONTACT WITH MY CHEVY DEALER TO FIND OUT IF THEY WILL COMPENSATE ME. I WILL ALSO BE CONTACTING CORPORATE CHEVY OFFICES AS WELL. MR
NHTSA ODI #767846
Mileage unknown · Sep 19, 2002
Seats
AFTER I STOPPED I FELT THE SEAT GO BACK. I FOUND THE BRACKET THAT ATTACHED THE SEAT FRAME TO THE SLIDING TRACK HAD CRACKED. THE METAL APPEARS TO BE TOO BRITTLE AND THIN FOR THE APPLICATION. I AM A RELIABILITY ENGINEER WITH SIGNIFICANT STRUCTURAL FAILURE BACKGROUND AND IT APPEARS THE THIN METAL (~1/16") SHATTERED FROM IMBRITTLEME…
Read full complaint
AFTER I STOPPED I FELT THE SEAT GO BACK. I FOUND THE BRACKET THAT ATTACHED THE SEAT FRAME TO THE SLIDING TRACK HAD CRACKED. THE METAL APPEARS TO BE TOO BRITTLE AND THIN FOR THE APPLICATION. I AM A RELIABILITY ENGINEER WITH SIGNIFICANT STRUCTURAL FAILURE BACKGROUND AND IT APPEARS THE THIN METAL (~1/16") SHATTERED FROM IMBRITTLEMENT OR SOME SIMILAR PROCESS.*AK
NHTSA ODI #767431
Mileage unknown · Aug 19, 2002
Suspension
LOWER CONTROL ARM HEAD OF BOLT BROKE INTO TWO PIECES AND FELL OFF. THIS COULD OF CAUSE LOSS OF CONTROL IF IT HAD FALLEN OFF WHILE DRIIVING.*AK
NHTSA ODI #8016662
Mileage unknown · Aug 19, 2002
Service Brakes, Hydraulic
WHEN BACKING UP AND SLOWING DOWN ABS STARTS TO CLATTER. ITS AN INTERMITTENT PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8016591
Mileage unknown · Jul 30, 2002
Fuel System, Gasoline
A MALFUNCTION IN FUEL TANK OR FUEL LINE CAUSING AN OIL LEAK. HAD PART REPLACED, PROBLEM STILL OCCURRED. . DEALER CONTACTED.*AK
NHTSA ODI #8015108
Mileage unknown · Jul 18, 2002
Steering
WHEN MAKING A TURN THERE IS A LOUD CLUNKING NOISE. VEHICLE WAS INSPECTED BY DEALER, WHO DETERMINED THAT UPPER COLUMN SHAFT FAILED. A RECALL HAS BEEN ISSUED ON SIMILAR/ MAKE AND MODELS; HOWEVER THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #8014270
Mileage unknown · Jul 9, 2002
Steering
WHILE DRIVING STEERING WHEEL BROKE IN HALF. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
1998 Chevrolet Lumina Problems, Complaints & Recalls | Skip That Year
Illustration