TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE REMEDY CAUSED OTHER ISSUES WITH THE VEHICLE. WHEN THE VEHICLE WAS STARTED, SMOKE APPEARED UNDER THE HOOD AND THE CONTACT NOTICED A CRACK IN THE VACUUM HOSE.…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE REMEDY CAUSED OTHER ISSUES WITH THE VEHICLE. WHEN THE VEHICLE WAS STARTED, SMOKE APPEARED UNDER THE HOOD AND THE CONTACT NOTICED A CRACK IN THE VACUUM HOSE. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WATER PUMP NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 185,000.
NHTSA ODI #10939293
90,000 miles · Sep 17, 2016
Engine
MY COMPLAINT IS ABOUT RECALL # 15V701000, AND ALSO MY CAR STARTED LEAKING WATER INTO THE OIL SO I HAD TO PARK IT UP FOR A WHILE AND JUST BEEN WITHOUT A RIDE EVER SINCE ANY HELP WOULD BE APPRECIATED.
NHTSA ODI #10907344
121,000 miles · Mar 9, 2016
Engine
VEHICLE MAKING BANGING NOISE TOOK TO SHOP TOLD A BURNT VALVE, ( IT WAS DRIVEN IN/OUT OF SHOPS) SECOND SHOP WEEKS OF INVESTIGATING, SAME DIAGNOSIS. LACKED FUNDS TO REPAIR, TOOK HOME. READ ABOUT RECALL CONTACTED MANUFACTURER REFERRED TO LOCAL DEALER. DEALER SAID PARTS WERE BEING ORDERED BASED ON RECALL, BUT TOOK IT IN EARLIE…
Read full complaint
VEHICLE MAKING BANGING NOISE TOOK TO SHOP TOLD A BURNT VALVE, ( IT WAS DRIVEN IN/OUT OF SHOPS) SECOND SHOP WEEKS OF INVESTIGATING, SAME DIAGNOSIS. LACKED FUNDS TO REPAIR, TOOK HOME. READ ABOUT RECALL CONTACTED MANUFACTURER REFERRED TO LOCAL DEALER. DEALER SAID PARTS WERE BEING ORDERED BASED ON RECALL, BUT TOOK IT IN EARLIER THAN CONTACT. SERVICE PERSON INDICATED THAT MY VEHICLE IS NOT PART OF RECALL..THEY COULD DIAGNOSE AND REPAIR BUT COST IN THE THOUSANDS. I COULDN'T AFFORD THAT OR CONTINUE GETTING TICKETS (NOT ABLE TO MOVE IT BECAUSE BATTERY NEEDED A FULL CHARGE. I AM A WOMAN KNOW LITTLE ABOUT CARS, DID NOT WANT TO GET STUCK IF IT DEFAULTED. SECOND REPAIR SHOP ADVISED ME THAT I COULD DRIVE IT UNTIL IT JUST STOPPED, THE DEALER SAID IT WAS DEFINITELY NOT IN RECALL SO I DONATED TO KARS FOR KIDS. ON 3/8/16 GOT A CALL FROM SAME LOT TELLING ME MY RECALL PARTS HAD COME IN. PUZZLED & ALARMED TOLD CALLER ABOUT THEIR SERVICE DEPT. SHE SEEMED A PUZZLED SO I EXPLAINED WHAT HAPPENED. SHE CHECKED &TOLD ME THAT THERE WAS NO RECORD OF MY APPOINTMENT & SERVICE PERSON HAD NO KNOWLEDGE OF ME. PUZZLED AS TO WHAT IS GOING ON? PAID AAA $60.00 FOR TOW PAID $35.00 FOR USED TIRE. TOW GUY SAID I COULD DRIVE CAR DEALER AND SAVE TOW FEE BUT I'M NOT COMFORTABLE DRIVING BROKE CAR SO I HAD HIM TOW.MY QUESTION IS HOW DOES A CONSUMER KNOW IF THEIR SPECIFIC CAR FALLS UNDER A RECALL? THE CAR WAS MY LANDLORD'S DYING GIFT TO ME. I DROVE HIM AND HIS WIFE TO CHURCH, TO THE BANK, TO THE DOCTOR, FOR OIL CHANGES, ETC. I NEVER RECALLED TAKING IT FOR A RECALL AND MY LANDLORD WAS IN HIS 90'S I DIDN'T KNOW IF HE HAD OVERLOOKED RECALL SO MY MOTIVATION TO CHECK. TALKED TO MGR. OF DEALERSH 3/8/16 HE SAID HE WOULD INVESTIGATE, SERVICE PERSON WAS EXPERIENCED AND HE WAS SORRY ABOUT MY VEHICLE. NOW I, A SENIOR CITIZEN HAVE NO MEANS OF TRANSPORTATION.
NHTSA ODI #10845748
Mileage unknown · Jan 20, 2016
Engine
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE DEALER SCHEDULED AN APPOINTMENT AND LATER INDICATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED, BUT COULD NOT PROVIDE A DATE FOR WHEN THE VEHICLE WOULD RECEIVE T…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE DEALER SCHEDULED AN APPOINTMENT AND LATER INDICATED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED, BUT COULD NOT PROVIDE A DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10821269
80,000 miles · Jan 7, 2016
Air BagsEngine
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WAS PROTRUDING AS IF IT WERE GOING TO EXPLODE. IN ADDITION, THE CONTACT MENTIONED THAT OIL WAS LEAKING ONTO THE EXHAUST MANIFOLD AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE PASSENGER SIDE AIR BAG WAS PROTRUDING AS IF IT WERE GOING TO EXPLODE. IN ADDITION, THE CONTACT MENTIONED THAT OIL WAS LEAKING ONTO THE EXHAUST MANIFOLD AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10818652
245,000 miles · Dec 16, 2015
EngineFire
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STARTED TO SMOKE EXCESSIVELY. THE CONTACT HEARD A LOUD NOISE THEN THERE WAS FIRE COMING FROM THE FRONT UNDER THE HOOD OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE VALVE COVER GASKET FAILED AND THE UPPER MANIFOLD WAS CRACK.…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STARTED TO SMOKE EXCESSIVELY. THE CONTACT HEARD A LOUD NOISE THEN THERE WAS FIRE COMING FROM THE FRONT UNDER THE HOOD OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE VALVE COVER GASKET FAILED AND THE UPPER MANIFOLD WAS CRACK. THE VEHICLE WAS DESTROYED DUE TO THE FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AFTER THE FIRE OCCURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.
NHTSA ODI #10810738
2,136,813 miles · Dec 14, 2015
EngineFire
ENGINE COMPARTMENT CAUGHT FIRE.WHILE I WAS DRIVING.
NHTSA ODI #10810147
229,000 miles · Oct 28, 2014
Engine
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE DRIVING 35 MPH, AN UNUSUAL SOUND EMITTED FROM THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ENGINE CRADLE WAS LOOSE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE …
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE DRIVING 35 MPH, AN UNUSUAL SOUND EMITTED FROM THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ENGINE CRADLE WAS LOOSE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 229,000.
NHTSA ODI #10650823
112,000 miles · Apr 29, 2013
Engine
TL* THE CONTACT OWNS 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE ENGINE RATTLED AND MADE A LOT OF NOISE UNTIL IT WARMED UP. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 112,000. *TR
NHTSA ODI #10509822
76,800 miles · Dec 19, 2012
Engine
MY REPORT: ORIGINAL DIAGNOSTIC CODE WAS 3RD CYLINDER SPARK PLUG. SYMPTOMS WERE CONSISTENT WITH THIS. CAR DROVE FINE THAT EVENING UNTIL THE ENGINE HAD TROUBLE, SPUTTERED AND SHUT OFF. MECHANIC LOOKED AT IT AND DETERMINED THERE WAS NO COOLANT AND CAME TO THE CONCLUSION THAT THE ENGINE FAILED BECAUSE THIS MODEL AND YEAR IS KNOWN F…
Read full complaint
MY REPORT: ORIGINAL DIAGNOSTIC CODE WAS 3RD CYLINDER SPARK PLUG. SYMPTOMS WERE CONSISTENT WITH THIS. CAR DROVE FINE THAT EVENING UNTIL THE ENGINE HAD TROUBLE, SPUTTERED AND SHUT OFF. MECHANIC LOOKED AT IT AND DETERMINED THERE WAS NO COOLANT AND CAME TO THE CONCLUSION THAT THE ENGINE FAILED BECAUSE THIS MODEL AND YEAR IS KNOWN FOR COOLANT LEAK INTERNALLY BY INTAKE MANIFOLD GASKET. THERE WERE NO SIGNS OF COOLANT LEAK EXTERNALLY PRIOR TO THIS, DIDN'T BLOW WHITE SMOKE OUT THE BACK, THE LOW COOLANT LIGHT DIDN'T GO ON, THE OIL WAS FULL, NO MILKY STUFF IN RADIATOR EITHER, THE CAR DROVE LIKE NEW, AND THE CAR ONLY HAD 76,000 MILES ON IT. THE CAR HAD ONE PREVIOUS OWNER AND WAS WELL-MAINTAINED BY THAT OWNER AND MYSELF. I BOUGHT IT 2 YEARS AGO WITH ONLY 38,000 MILES ON IT. I LOOKED INTO WHY THE INTAKE MANIFOLD GASKET WOULD LEAK AND FOUND 2 REPORTS. BECAUSE THIS WAS A DEFECT, I SHOULD BE COMPENSATED WITH AND ENGINE OR MONEY FOR THE ENGINE FROM CHEVY: PROBLEM REPORTS: CHEVROLET LUMINA REPORT: INTAKE MANIFOLD GASKETS MAY LEAK COOLANT OR ENGINE OIL MODEL YEARS AFFECTED: 1994, 1995, 1996, 1997, 1998, 2000, 2001 ENGINES AFFECTED: 3.1L V6, 3.4L V6, 3.8L V6 THE INTAKE MANIFOLD GASKET MAY DEVELOP AND EXTERNAL ENGINE OIL OR COOLANT LEAK. IN SOME CASES, AN INTERNAL COOLANT LEAK MAY OCCUR CAUSING COOLANT TO MIX WITH THE ENGINE OIL. OUR TECHNICIANS TELL US THAT OPERATING THE ENGINE WITH A COOLANT/OIL MIX CAN RESULT IN INTERNAL ENGINE DAMAGE. REPLACING THE INTAKE MANIFOLD GASKET SHOULD CORRECT THESE LEAKS. UNFORTUNATELY THE 3.1 LITRE ENGINE HAS A MANUFACTURE FLAW. THE GASKET IS PLASTIC AND RUBBER. OVER TIME THE PLASTIC CRACKS DUE THE HEAT AND THE RUBBER SEAL FAILS. FELPRO HAS REDESIGNED THAT GASKET. INSTEAD OF BEING PLASTIC AND RUBBER IT IS STEEL AND RUBBER. *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
1998 Chevrolet Lumina Problems, Complaints & Recalls | Skip That Year
Illustration