ENGINE HEAD GASKET FAILED, CAUSING COOLANT TO LEAK INTO ENGINE AND DAMAGE BEARINGS. ENGINE WAS REPLACED AT A COST OF $2,961.87. TWO YEARS LATER, SAME THING HAPPENED TO REMANUFACTURED ENGINE AGAIN, THIS TIME THE INTAKE MANIFOLD GASKET CAUSING COOLANT TO LEAK INTO ENGINE OIL COMPARTMENT AND CAUSE DAMAGE. COST TO US $390 ( NOT …
Read full complaint
ENGINE HEAD GASKET FAILED, CAUSING COOLANT TO LEAK INTO ENGINE AND DAMAGE BEARINGS. ENGINE WAS REPLACED AT A COST OF $2,961.87. TWO YEARS LATER, SAME THING HAPPENED TO REMANUFACTURED ENGINE AGAIN, THIS TIME THE INTAKE MANIFOLD GASKET CAUSING COOLANT TO LEAK INTO ENGINE OIL COMPARTMENT AND CAUSE DAMAGE. COST TO US $390 ( NOT COVERED UNDER JASPER WARRANTY BECAUSE JASPER DID NOT INSTALL INTAKE MANIFOLD GASKET ON REMANUFACTURED ENGINE, HALLEEN DID). *AK
NHTSA ODI #721394
Mileage unknown · Feb 3, 2000
Engine And Engine CoolingFire
WHILE CONSUMER'S DAUGTHER WAS DRIVING ABOUT 35 MPH ENGINE CAUGHT ON FIRE WITHOUT A WARNING, FORCING DRIVER OFF THE ROAD. VEHICLE WAS TOTALED. *AK
NHTSA ODI #856217
Mileage unknown · Nov 22, 1999
Engine And Engine Cooling
I PURCHASED THIS VEHICLE THROUGH PHH MANAGEMENT AS A USED FLEET VEHICLE FROM THE COMPANY I WORK FOR, MARCONI COMMUNICATIONS(PREVIOUSLY RELTEC). I KNEW THE PERSON TOWHOM THE VEHICLE WAS ASSIGNED, AND PURCHASED IT AT THE END OF THE LEASE. THE VEHICLE COULD BE DESCRIBED AS "PRISTINE" CONDITION EXCEPT FOR THE RECURRING UNEXPECTED …
Read full complaint
I PURCHASED THIS VEHICLE THROUGH PHH MANAGEMENT AS A USED FLEET VEHICLE FROM THE COMPANY I WORK FOR, MARCONI COMMUNICATIONS(PREVIOUSLY RELTEC). I KNEW THE PERSON TOWHOM THE VEHICLE WAS ASSIGNED, AND PURCHASED IT AT THE END OF THE LEASE. THE VEHICLE COULD BE DESCRIBED AS "PRISTINE" CONDITION EXCEPT FOR THE RECURRING UNEXPECTED SHUTDOWN PROBLEMS. THESE SHUTDOWNS HAVE HAPPENED IN SINGLE LANE CONSTRUCTION ZONES ON THE OHIO TURNPIKE AND ON THE BRIDGE TO CANADA, AND IT IS A MIRACLE WE HAVE NOT BEEN INVOLVED IN AN ACCIDENT YET. THE FAILURES SEEM TO OCCUR MOSTLY IN TEMPERATURES ABOVE 70 F AND AT SPEEDS ABOVE 55 MPH. AND ESPECIALLY WITH 4 OR MORE ADULTS ABOARD OR SOME REASONABLE LOAD. I HAVE SPENT IN EXCESS OF $500 DOLLARS ON EXPERIMENTAL PARTS CHANGEOUTS TRYING TO REMEDY THE PROBLEM BUT TO NO AVAIL. *AK
NHTSA ODI #715127
Mileage unknown · Sep 9, 1999
Engine And Engine Cooling
WHILE TRAVELING ON THE HIGHWAY AT 55 MPH THE ENGINE STALLED WITHOUT PRIOR WARNING ,CAUSING LOSS OF POWER STEERING. THE DEALER DETERMINED, THE CAUSE OF FAILURE WAS A CRACK IN THE ENGINE BLOCK. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #847269
Mileage unknown · Mar 10, 1999
Engine And Engine CoolingFire
THE WIRING TO THE RADIATOR COOLING FANS IS NOT CIRCUIT PROTECTED. NO FUSABLE LINK OR FUSE. WHEN THE WIRING OR FAN SHORTS IT CAUSES THE WIRING TO BURN. THIS IN TURN AFFECTS THE WIRING BUNDLE IT RUNS THROUGH AND WILL CAUSE AN ELECTRICAL FIRE. I HAVE SINCE PUT A FUSE IN THE SYSTEM PER THE RATING OF THE FAN AND GAUGE OF WIRING. …
Read full complaint
THE WIRING TO THE RADIATOR COOLING FANS IS NOT CIRCUIT PROTECTED. NO FUSABLE LINK OR FUSE. WHEN THE WIRING OR FAN SHORTS IT CAUSES THE WIRING TO BURN. THIS IN TURN AFFECTS THE WIRING BUNDLE IT RUNS THROUGH AND WILL CAUSE AN ELECTRICAL FIRE. I HAVE SINCE PUT A FUSE IN THE SYSTEM PER THE RATING OF THE FAN AND GAUGE OF WIRING. IT SHOULD BE REQUIRED ON SUCH A HIGH AMPERAGE MOTOR TO HAVE SOME SORT OF ELECTRICAL PROTECTION.
NHTSA ODI #704233
Mileage unknown · Jan 7, 1999
Engine And Engine Cooling
WHILE DRIVING THE VAN AT ANY SPEED, ANY TIME A VALVE SPRING BREAKS. VAN GOES TO A ROUGH IDLE. HEARS A KNOCKING IN THE MOTOR AND THE MOTOR OVERHEATS. THIS HAS HAPPENED TWO OTHER TIMES; 8/11/97 WITH 130,000 MILES, AND 7/15/98 WITH 146,000 MILES. EACH TIME VALVE SPRINGS HAVE BEEN REPLACED BY THE DEALER.
NHTSA ODI #833126
Mileage unknown · Jan 26, 1998
Electrical SystemEngine And Engine Cooling
WHILE DRIVING UNDER 40 MPH THE VEHICLE INTERMITTENTLY SHUTS OFF. THE DRIVER RECEIVES NO INDICATION THAT THE VEHICLE IS GOING TO SHUT OFF. THE DEALER HAS REPLACED THE AIR INTAKE CONTROL, THE COMPUTER AND THE IGNITION SWITCH. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Consequence & remedy
Consequence: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Remedy: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.
THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME POSITION.
Consequence & remedy
Consequence: IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.
Remedy: DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.
VEHICLE FAILS TO CONFORM TO FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE SAFETY BELT OF THE LEFT THIRD ROW SEAT ON THE SIX PASSENGER VAN AND THE CENTER SECOND ROW SEAT OF THE SEVEN PASSENGER VAN MAY LOCK UP AND CANNOT BE WITHDRAWN FROM THE RETRACTOR.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANTS OF THESE SEATS WILL NOT BE ABLE TO USE THE AFFECTED BELT. IN THE EVENT OF A VEHICLE CRASH, UNBELTED OCCUPANTS ARE AT INCREASED RISK OF INJURY.
Remedy: OWNERS ARE BEING ASKED TO INSPECT THEIR VEHICLES TO DETERMINE IF THE SUSPECT RETRACTOR EXHIBITS A LOCKUP CONDITION. BASED ON THIS INSPECTION, DEALERS WILL REPLACE THE SAFETY BELTS IF THE BELT LOCKS UP. REPLACEMENT OF THE SUSPECT SAFETY BELT WILL BE AVAILABLE TO CONSUMERS FOR THE LIFE OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE94070 · Trnsaxl Oil Hose Separates
Opened Sep 15, 1994 · Closed Jan 18, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
1993 Chevrolet Lumina Apv Problems, Complaints & Recalls | Skip That Year
Illustration