NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
742 reports135,000 miles · Nov 9, 2010
Traction Control System
IT HAS BEEN GOING ON FOR A FEW MONTHS NOW. IT IS MORE NOTICEABLE WHEN I AM TURNING RIGHT OR LEFT OR PULLING AWAY FROM THE CURB WHERE I AM PARELLEL PARKED. THE ENGINE MAKES A WHIRRING SOUND, THE ENGINE BECOMES SLUGGISH AND THE SERVICE TRACTION SYSTEM AND TRAC OFF LIGHTS COME ON. ONCE I STRAIGHTEN THE WHEEL, THE NOISE STOPS AND…
Read full complaint
IT HAS BEEN GOING ON FOR A FEW MONTHS NOW. IT IS MORE NOTICEABLE WHEN I AM TURNING RIGHT OR LEFT OR PULLING AWAY FROM THE CURB WHERE I AM PARELLEL PARKED. THE ENGINE MAKES A WHIRRING SOUND, THE ENGINE BECOMES SLUGGISH AND THE SERVICE TRACTION SYSTEM AND TRAC OFF LIGHTS COME ON. ONCE I STRAIGHTEN THE WHEEL, THE NOISE STOPS AND THE LIGHTS GO OFF. IT ALSO OCCURS WHEN I AM TURNING RIGHT OR LEFT WHERE I NEED TO BREAK AS I AM TURNING. *TR
NHTSA ODI #10365122
135,000 miles · Nov 9, 2010
Traction Control System
IT HAS BEEN GOING ON FOR A COUPLE OF MONTHS. IT IS NOTICEABLE WHEN I AM TURNING RIGHT OR LEFT OR PULLING OUT FROM BEING PARELLEL PARKED, THE ENGINE MAKES A GRINDING NOISE, IT BECOMES SLUGGISH AND THE SERVICE TRACTION SYSTEM AND THE TRAC OFF LIGHTS COME ON. ONCE I STRAIGHTEN THE WHEEL, THE NOISE STOPS AND LIGHTS GO OFF. WHEN …
Read full complaint
IT HAS BEEN GOING ON FOR A COUPLE OF MONTHS. IT IS NOTICEABLE WHEN I AM TURNING RIGHT OR LEFT OR PULLING OUT FROM BEING PARELLEL PARKED, THE ENGINE MAKES A GRINDING NOISE, IT BECOMES SLUGGISH AND THE SERVICE TRACTION SYSTEM AND THE TRAC OFF LIGHTS COME ON. ONCE I STRAIGHTEN THE WHEEL, THE NOISE STOPS AND LIGHTS GO OFF. WHEN I AM TURNING EITHER RIGHT OR LEFT AND NEED TO BRAKE, IT DOES THE SAME THING. *TR
NHTSA ODI #10365119
114,000 miles · Sep 28, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE FILLED THE FUEL TANK AND RETURNED TO THE VEHICLE, THE FUEL GAUGE WOULD REGISTER THAT THE TANK WAS EMPTY. AFTER A FEW DAYS, THE FUEL GAUGE WOULD REGISTER EMPTY AND THE VEHICLE WOULD SUDDENLY SHUT OFF COMPLETELY. SHE HAD TO REFILL THE TANK TO START THE …
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE FILLED THE FUEL TANK AND RETURNED TO THE VEHICLE, THE FUEL GAUGE WOULD REGISTER THAT THE TANK WAS EMPTY. AFTER A FEW DAYS, THE FUEL GAUGE WOULD REGISTER EMPTY AND THE VEHICLE WOULD SUDDENLY SHUT OFF COMPLETELY. SHE HAD TO REFILL THE TANK TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE PROBLEM COULD POSSIBLY BE THE FUEL PUMP OR FUEL FILTER. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 114,000
NHTSA ODI #10358059
91,000 miles · Sep 16, 2010
Electrical System
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT ANTI THEFT SYSTEM MALFUNCTIONED AND THE CONTACT WAS NOT ABLE TO START THE VEHICLE. THE DEALER WAS NOT INFORMED ABOUT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91000 AND THE CURRENT MILEAGE WAS 96000.
NHTSA ODI #10355924
97,000 miles · Sep 6, 2010
Electrical System
WHILE MAKING A LEFT TURN IN AN INTERSECTION, CAR COMPLETELY SHUT DOWN, AND I LOST BRAKES AND STEERING. CAR IMMEDIATELY RESTARTED BUT TIME ON CLOCK WAS WRONG. I BELIEVE THE COMPUTER IS SHUTTING THE CAR DOWN. SHORTLY AFTER THIS INCIDENT, MY KEYLESS ENTRY FAILED TO LOCK THE CAR UNTIL I RESTARTED THE CAR AND TRIED AGAIN. I, AGAI…
Read full complaint
WHILE MAKING A LEFT TURN IN AN INTERSECTION, CAR COMPLETELY SHUT DOWN, AND I LOST BRAKES AND STEERING. CAR IMMEDIATELY RESTARTED BUT TIME ON CLOCK WAS WRONG. I BELIEVE THE COMPUTER IS SHUTTING THE CAR DOWN. SHORTLY AFTER THIS INCIDENT, MY KEYLESS ENTRY FAILED TO LOCK THE CAR UNTIL I RESTARTED THE CAR AND TRIED AGAIN. I, AGAIN, NOTICED, THE TIME ON MY CLOCK HAD CHANGED, INDICATING A COMPUTER SHUTDOWN. *TR
NHTSA ODI #10354062
119,000 miles · Sep 4, 2010
Exterior LightingTraction Control System
THE TRACTION CONTROL SYSTEM AND ABS LIGHTS COME ON IN MY CAR AND I HAVE HAD EVERYTHING REPLACED THAT THE MECHANIC HAS TOLD ME TOO AND ITS STILL ON. THIS IS ON EVERY TIME I DRIVE THE CAR. THE ABS BEING ON IS VERY DANGEROUS AND I HAVE KIDS. PLEASE THERE IS A LOT OF PEOPLE COMPLAINING ABOUT THIS ON THIS PARTICULAR TYPE OF CAR CHEVY…
Read full complaint
THE TRACTION CONTROL SYSTEM AND ABS LIGHTS COME ON IN MY CAR AND I HAVE HAD EVERYTHING REPLACED THAT THE MECHANIC HAS TOLD ME TOO AND ITS STILL ON. THIS IS ON EVERY TIME I DRIVE THE CAR. THE ABS BEING ON IS VERY DANGEROUS AND I HAVE KIDS. PLEASE THERE IS A LOT OF PEOPLE COMPLAINING ABOUT THIS ON THIS PARTICULAR TYPE OF CAR CHEVY IMPALA 2001 - 2002. *TR
NHTSA ODI #10353841
Mileage unknown · Aug 25, 2010
Engine And Engine Cooling
ENGINE/LOW COOLANT LEVEL LIGHT ON! OVERHEATING. PROBLEMS APPEAR TO BE SAME AS OTHER OWNERS OF 2001 IMPALA'S! HAD TO REPLACE ENGINE. STILL SAME PROBLEM W COOLANT. *TR
NHTSA ODI #10351643
125,000 miles · Aug 24, 2010
Exterior Lighting
ON THE 2001 IMPALA THE TURN SIGNALS WORK INTERMITTENTLY. THERE IS NO CONSISTENCY ON WHEN THE ISSUE HAPPENS, IT SUDDENLY STARTS. WHAT ACTUALLY CAUSES IT IS UNKNOWN. SOMETIMES PUSHING THE HAZARD BUTTON SEVERAL TIMES WILL CORRECT THE ISSUE TEMPORARILY. THE ONLY WAY TO FIX THIS ISSUE IS TO $400+ TO REPLACE THE SWITCH ON A WELL K…
Read full complaint
ON THE 2001 IMPALA THE TURN SIGNALS WORK INTERMITTENTLY. THERE IS NO CONSISTENCY ON WHEN THE ISSUE HAPPENS, IT SUDDENLY STARTS. WHAT ACTUALLY CAUSES IT IS UNKNOWN. SOMETIMES PUSHING THE HAZARD BUTTON SEVERAL TIMES WILL CORRECT THE ISSUE TEMPORARILY. THE ONLY WAY TO FIX THIS ISSUE IS TO $400+ TO REPLACE THE SWITCH ON A WELL KNOWN ISSUE AFFECTING 1000'S OF IMPALA OWNERS OVER MANY YEARS OF THE DESIGN. *TR
NHTSA ODI #10351547
42,000 miles · Aug 20, 2010
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS ADVISED THAT THE ENGINE HEAD GASKET WAS FAILING. THE DEALER ADVISED THAT THE GASKET WAS MANUFACTURED FROM PLASTIC AND WOULD EVENTUALLY, WOULD NOT RETAIN COOLANT FROM PENETRATING THE ENGINE AND TRANSMISSI…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS ADVISED THAT THE ENGINE HEAD GASKET WAS FAILING. THE DEALER ADVISED THAT THE GASKET WAS MANUFACTURED FROM PLASTIC AND WOULD EVENTUALLY, WOULD NOT RETAIN COOLANT FROM PENETRATING THE ENGINE AND TRANSMISSION. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 42,000.
NHTSA ODI #10350815
53,500 miles · Aug 16, 2010
Traction Control System
THE ABS SYSTEM ON MY 2001 CHEVROLET IMPALA ENGAGES AND THE "TRACTION ACTIVE" LIGHT COMES ON WHEN MAKING A SHARP TURN FROM A STOPPED POSITION. THE LIGHT GOES OFF AND THE ABS SYSTEM DISENGAGES WITHIN ABOUT 5 SECONDS. THIS HAPPENS AT LEAST ONCE EACH TIME THE CAR IS DRIVEN. THREE TRIPS TO THE LOCAL CHEVROLET DEALER AND NO REPAIRS MA…
Read full complaint
THE ABS SYSTEM ON MY 2001 CHEVROLET IMPALA ENGAGES AND THE "TRACTION ACTIVE" LIGHT COMES ON WHEN MAKING A SHARP TURN FROM A STOPPED POSITION. THE LIGHT GOES OFF AND THE ABS SYSTEM DISENGAGES WITHIN ABOUT 5 SECONDS. THIS HAPPENS AT LEAST ONCE EACH TIME THE CAR IS DRIVEN. THREE TRIPS TO THE LOCAL CHEVROLET DEALER AND NO REPAIRS MADE AND NO SOLUTION THUS FAR. THE CHEVY DEALER SAYS THEY CANNOT DUPLICATE THE PROBLEM. *TR
NHTSA ODI #10349541
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration