IllustrationPOWER STEERING GOES OUT. WARNING LIGHT INDICATES POWER STEERING. OCCURS WHILE FREEWAY OR CITY DRIVING AND WHILE STOPPED AT A TRAFFIC LIGHT OR STOP SIGN. OCCURS FROM 0 TO 65 MPH. TO RESOLVE ISSUE YOU MUST TURN OFF THE ENGINE WAIT A FEW SECONDS THEN TURN IT BACK ON. ISSUE HAS BEEN OCCURRING FOR THE LAST 3 TO FOUR MONTHS.
2007 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
8725–50K
15050–75K
12175–100K
132100–150K
43150K+
598 reports with mileage · 128 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 424 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
42 crash reports4 fire reports23 injury reports
What owners actually said
726 reportsA STRONG ODOR OF GASOLINE HAS BEEN NOTICEABLE WHEN EXITING THE VEHICLE. MECHANIC REPAIR SHOP STATES IT IS THE FUEL LINE AND RETURN WHICH HAVE RUSTED OUT. I HAVE SEEN NUMEROUS COMPLAINTS ABOUT THIS ISSUE WITH CHEVY HHR OWNERS. THIS IS A SAFETY ISSUE WHICH CAN LEAD TO DEATH IF A FIRE IGNITES. DOESN'T EVEN HAVE 100K MILES. RIDICULO…
Read full complaint
A STRONG ODOR OF GASOLINE HAS BEEN NOTICEABLE WHEN EXITING THE VEHICLE. MECHANIC REPAIR SHOP STATES IT IS THE FUEL LINE AND RETURN WHICH HAVE RUSTED OUT. I HAVE SEEN NUMEROUS COMPLAINTS ABOUT THIS ISSUE WITH CHEVY HHR OWNERS. THIS IS A SAFETY ISSUE WHICH CAN LEAD TO DEATH IF A FIRE IGNITES. DOESN'T EVEN HAVE 100K MILES. RIDICULOUS!
SMELLED FUEL AND FOUND FUEL LEAKING ON DRIVERS SIDE REAR. TOOK TO MECHANIC AND WAS SHOWN THAT ALL FUEL LINES WERE RUSTED FROM THE GAS TANK TO THE ENGINE. CALLED CHEVROLET AND THERE ARE NO RECALLS ON THIS VEHICLE AND MADE COMPLAINT THAT THIS IS A DANGERUOS PROBLEM FOR NOT ONLY FIRE BUT EXPLOSION. FOUND OTHER COMPLAINTS FOR THIS O…
Read full complaint
SMELLED FUEL AND FOUND FUEL LEAKING ON DRIVERS SIDE REAR. TOOK TO MECHANIC AND WAS SHOWN THAT ALL FUEL LINES WERE RUSTED FROM THE GAS TANK TO THE ENGINE. CALLED CHEVROLET AND THERE ARE NO RECALLS ON THIS VEHICLE AND MADE COMPLAINT THAT THIS IS A DANGERUOS PROBLEM FOR NOT ONLY FIRE BUT EXPLOSION. FOUND OTHER COMPLAINTS FOR THIS ON CARCOMPLAINTS.COM
LEAKING OF WATER FROM WIPER CROWL TO FAN MOTOR OF HEATER AND HAS BURNT RESISTER TO HEATER BLOWER MOTOR. LEAK OF WATER WAS QUITE A BIT ON FLOOR BOARD. AFRAID IT WILL CAUSE ELECTRICAL MALFUNCTION. LEAK OF WATER HAS HAPPENED DURING VEHICLE WAS PARKED OR IN MOTION.
PRIMEWELL VALERA SPORT AS 215/50R17X91W CRACK IN SIDEWALL.
FUEL LINE IS LEAKING BY THE DRIVERS SIDE DOOR AND THE FUEL RETURN VAPOR LINE NEEDS REPLACED
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE REVERSING THE VEHICLE AT LOW SPEEDS, THE STEERING WHEEL LOST POWER. THE VEHICLE WAS SERVICED PER AN UNKNOWN RECALL REGARDING THE STEERING WHEEL, BUT THE FAILURE RECURRED. THE VEHICLE WAS CURRENTLY WAITING TO BE TOWED TO THE DEALER THAT PERFORMED THE RECALL REPAIR, SIERRA MOTORS, L…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE REVERSING THE VEHICLE AT LOW SPEEDS, THE STEERING WHEEL LOST POWER. THE VEHICLE WAS SERVICED PER AN UNKNOWN RECALL REGARDING THE STEERING WHEEL, BUT THE FAILURE RECURRED. THE VEHICLE WAS CURRENTLY WAITING TO BE TOWED TO THE DEALER THAT PERFORMED THE RECALL REPAIR, SIERRA MOTORS, LOCATED AT 18475 5TH AVE, JAMESTOWN, CA 95327, (209) 916-4332). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.
POWER STEERING FAILS RANDOMLY WHILE DRIVING, STEERING BECOMES VERY DIFFICULT AND COULD BE VERY DANGEROUS.. PULLING OVER AND TURNING THE CAR OFF RESTARTS THE STEERING, BUT IT FAILS AGAIN RANDOMLY VERY VERY DANGEROUS. WHY NO RECALL?
THE CAR BEGAN HAVING DIFFICULTY STARTING AND WOULD REQUIRE MULTIPLE ATTEMPTS. UPON PARKING THE CAR AND GETTING OUT, I NOTICED A STRONG SMELL OF GAS THAT FADED VERY QUICKLY. THE FOLLOWING DAY THE TROUBLE STARTING CONTINUED AND THE GAS SMELL JUST GOT STRONGER AND STRONGER EVEN WHILE DRIVING. I PARKED THE CAR AND RETURNED AN HOUR L…
Read full complaint
THE CAR BEGAN HAVING DIFFICULTY STARTING AND WOULD REQUIRE MULTIPLE ATTEMPTS. UPON PARKING THE CAR AND GETTING OUT, I NOTICED A STRONG SMELL OF GAS THAT FADED VERY QUICKLY. THE FOLLOWING DAY THE TROUBLE STARTING CONTINUED AND THE GAS SMELL JUST GOT STRONGER AND STRONGER EVEN WHILE DRIVING. I PARKED THE CAR AND RETURNED AN HOUR LATER TO DISCOVER A WIDE PUDDLE OF FUEL DRIPPING FROM JUST IN FRONT OF THE REAR DRIVER'S SIDE TIRE. RESEARCH HAS SHOWN THAT THIS SEEMS TO BE HAPPENING TO A LOT OF HHR CUSTOMERS REGARDLESS OF LOCATION OR EXPOSURE TO ICE MELT CHEMICALS.
TAKATA RECALL MY HORN DON'T WORK THE SERVICE AIRBAGS STAYS ON. THE STRUTS BACK HATCH DON'T OPEN CRUISE CONTROL DON'T WORK CHECKED ALL MY FUSES AND THEY ARE ALL GOOD
Official recalls
414V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.