NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,006 reports32,000 miles · Oct 2, 2007
Tires
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE VEHICLE HAS FIRESTONE FIREHAWK GTX, SIZE 215/50R17 TIRES. THE PASSENGER SIDE REAR TUBELESS TIRE HAS TREAD SEPARATION AND LOOKS AS IF IT WERE SLICED DOWN THE CENTER. THE SEPARATION BEGAN IN ONE PLACE ON THE TIRE, BUT IS CURRENTLY IN FOUR DIFFERENT PLACES. THE CONTACT HAS NOT YET C…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE VEHICLE HAS FIRESTONE FIREHAWK GTX, SIZE 215/50R17 TIRES. THE PASSENGER SIDE REAR TUBELESS TIRE HAS TREAD SEPARATION AND LOOKS AS IF IT WERE SLICED DOWN THE CENTER. THE SEPARATION BEGAN IN ONE PLACE ON THE TIRE, BUT IS CURRENTLY IN FOUR DIFFERENT PLACES. THE CONTACT HAS NOT YET CALLED THE TIRE MANUFACTURER OR THE PLACE WHERE HE PURCHASED THE TIRES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 38,000 AND FAILURE MILEAGE WAS 32,000. *UPDATED 12/12/07 *BF UPDATED 12/12/07 *TR
NHTSA ODI #10204677
15,550 miles · Oct 2, 2007
Service Brakes, Hydraulic
STEERING WHEEL SHAKES LEFT & RIGHT WHEN STOPPING SPEED 40 MILES PER HOUR AND UP. THE 1ST TIME THE HHR WAS IN FOR THIS PROBLEM WAS 3 MONTHS AGO 15,550 MILES. DEALER SAID THEY COULD NOT FIND ANY THING THAT IT COULD BE THE ROAD AS I WAS DRIVING ON. TOOK IT IN AGAIN AT 17,500 THIS TIME IT WAS THE ROTORS WHERE WARPED. DEALER MACHINED…
Read full complaint
STEERING WHEEL SHAKES LEFT & RIGHT WHEN STOPPING SPEED 40 MILES PER HOUR AND UP. THE 1ST TIME THE HHR WAS IN FOR THIS PROBLEM WAS 3 MONTHS AGO 15,550 MILES. DEALER SAID THEY COULD NOT FIND ANY THING THAT IT COULD BE THE ROAD AS I WAS DRIVING ON. TOOK IT IN AGAIN AT 17,500 THIS TIME IT WAS THE ROTORS WHERE WARPED. DEALER MACHINED THE ROTORS. *JB
NHTSA ODI #10204637
11,000 miles · Oct 1, 2007
Power Train
TL*THE CONTACT'S SPOUSE OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFT WOULD OCCASIONALLY STICK OR SHIFT INTO ANY GEAR WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE NEW PART HAS BEEN ORDERED. THE CURRENT MILEAGE WAS 11,400 AND FAILURE MILEAGE WAS 11,000.
NHTSA ODI #10204589
10,000 miles · Sep 18, 2007
Electrical System
THE OUTSIDE TEMPERATURE GAUGE CONSISTENTLY "STICKY" OR READS INACCURATE OUTSIDE TEMPERATURE. ONLY AFTER DRIVING AN AVERAGE OF 45MPH FOR AT LEAST 3 OR 4 MINUTES WILL THE GAUGE UPDATE. TYPICAL CITY DRIVING NEVER ALLOWS FOR THE 45MPH AVERAGE AND THUS GAUGE CONTINUALLY STICKS AT THE MORNING COLDER TEMPERATURE. ONLY AFTER 2 HOURS …
Read full complaint
THE OUTSIDE TEMPERATURE GAUGE CONSISTENTLY "STICKY" OR READS INACCURATE OUTSIDE TEMPERATURE. ONLY AFTER DRIVING AN AVERAGE OF 45MPH FOR AT LEAST 3 OR 4 MINUTES WILL THE GAUGE UPDATE. TYPICAL CITY DRIVING NEVER ALLOWS FOR THE 45MPH AVERAGE AND THUS GAUGE CONTINUALLY STICKS AT THE MORNING COLDER TEMPERATURE. ONLY AFTER 2 HOURS WILL THE GAUGE UPDATE PROPERLY SO IF RUNNING ERRANDS LESS THAN 2 HOURS AND NOT DRIVING FREEWAY THE GAUGE NEVER UPDATES AND STICKS AT THE LOW MORNING TEMPERATURE. *TR
NHTSA ODI #10203373
26,000 miles · Aug 22, 2007
Service Brakes, Hydraulic
STEERING WHEEL AND FRONT END SHAKING VIOLENTLY WHEN BRAKING. BROUGHT INTO DEALERSHIP @ APPROX 27,000MI AND TOLD ROTORS NEEDED TO BE RESURFACED BECAUSE THEY WERE WARPED. MANAGER SAID THEY WERE WARPED DUE TO "DRIVING HABITS", BRAKES GETTING WET-THEN USED, AND/OR HARD STOPS. THIS HAS NEVER BEEN THE CASE WITH ANY OTHER VEHICLE I'VE …
Read full complaint
STEERING WHEEL AND FRONT END SHAKING VIOLENTLY WHEN BRAKING. BROUGHT INTO DEALERSHIP @ APPROX 27,000MI AND TOLD ROTORS NEEDED TO BE RESURFACED BECAUSE THEY WERE WARPED. MANAGER SAID THEY WERE WARPED DUE TO "DRIVING HABITS", BRAKES GETTING WET-THEN USED, AND/OR HARD STOPS. THIS HAS NEVER BEEN THE CASE WITH ANY OTHER VEHICLE I'VE DRIVEN FOR A COMPARABLE AMOUNT OF TIME. *TR
NHTSA ODI #10200464
27,000 miles · Aug 21, 2007
Electrical SystemInjury
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING WHILE HIS SPOUSE WAS DRIVING. SHE SUSTAINED MINOR INJURIES. THE DEALER STATED THAT THE WIRING SHORT CIRCUITED IN THE STEERING HARNESS AND CAUSED THE FAILURE. THE VIN, ENGINE SIZE, AND SPEED WERE UNKNOWN. …
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER SIDE AIR BAG DEPLOYED WITHOUT WARNING WHILE HIS SPOUSE WAS DRIVING. SHE SUSTAINED MINOR INJURIES. THE DEALER STATED THAT THE WIRING SHORT CIRCUITED IN THE STEERING HARNESS AND CAUSED THE FAILURE. THE VIN, ENGINE SIZE, AND SPEED WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 27,000.
NHTSA ODI #10200259
24,350 miles · Aug 6, 2007
Service Brakes, Hydraulic
DRIVING HOME FROM OUT OF STATE, APPLIED BRAKES AND STEERING WHEEL SHUDDERED VIOLENTLY, WITH REDUCED BRAKING ABILITY. TOOK TO DEALER, DIAGNOSED WARPED ROTORS. THE SAME PROBLEM HAD OCCURRED THREE MONTHS EARLIER, AT 20,000 MILES. VEHICLE NOW HAS 24,000 MILES. ROTORS WERE RESURFACED BOTH TIMES. *JB
NHTSA ODI #10198664
9,505 miles · Aug 3, 2007
Engine And Engine Cooling
CAR HAS DIED SEVERAL DIFFERENT TIMES AND HAS BEEN IN THE SERVICE DEPARTMENT 5 DIFFERENT TIMES, AND SERVICE TECH'S CAN'T DIAGNOSE A PROBLEM, NOR CAN THEY DUPLICATE THE PROBLEM, SO I'M STUCK TO DRIVE A CAR THAT IS NOT SAFE, DYING IN THE MIDDLE OF TRAFFIC, EVEN ON INTERSTATE. *JB
NHTSA ODI #10198456
9,000 miles · Aug 1, 2007
Electrical System
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE VEHICLE SHUT OFF AFTER IT WAS DRIVEN TWO MILES. THE VEHICLE WOULD NOT RESTART. WHEN THE KEY WAS TURNED IN THE IGNITION, THE VEHICLE ATTEMPTED TO RESTART. THERE WERE NO WARNING INDICATOR LIGHTS. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE STARTER. HOWEVER, THE FAIL…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE VEHICLE SHUT OFF AFTER IT WAS DRIVEN TWO MILES. THE VEHICLE WOULD NOT RESTART. WHEN THE KEY WAS TURNED IN THE IGNITION, THE VEHICLE ATTEMPTED TO RESTART. THERE WERE NO WARNING INDICATOR LIGHTS. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE STARTER. HOWEVER, THE FAILURE CONTINUES. THE DEALER WAS UNABLE TO DETERMINE HOW TO REPAIR THE FAILURE. THE FAILURE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 18,860 AND FAILURE MILEAGE WAS 9,000.
NHTSA ODI #10198185
13,500 miles · Jul 14, 2007
Electrical SystemVehicle Speed Control
THE OUTSIDE TEMP INDICATOR STOPPED WORKING. THE DEALER REPLACED A "BODY CONTROL MODULE" THIS CAUSED THE CRUISE CONTROL TO STOP WORKING. 1 "ELECTRONIC CONTROL MODULE" WAS INSTALLED. PROBLEM STILL EXISTED. A SECOND ECM WAS INSTALLED AND THE CRUISE ONCE AGAIN WORKS, HOWEVER NOW MY DRIVING LIGHTS NO LONGER WORK. IT WILL BE RETURNED …
Read full complaint
THE OUTSIDE TEMP INDICATOR STOPPED WORKING. THE DEALER REPLACED A "BODY CONTROL MODULE" THIS CAUSED THE CRUISE CONTROL TO STOP WORKING. 1 "ELECTRONIC CONTROL MODULE" WAS INSTALLED. PROBLEM STILL EXISTED. A SECOND ECM WAS INSTALLED AND THE CRUISE ONCE AGAIN WORKS, HOWEVER NOW MY DRIVING LIGHTS NO LONGER WORK. IT WILL BE RETURNED TO THE DEALER FOR A TIME TO TRY TO GET ALL THE ELECTRONICS TO WORK AS THEY SHOULD. *TR
NHTSA ODI #10196351
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration