NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
119 reportsClear category filter300,000 miles · Jun 17, 2014
Air BagsSteeringStructure
AIR BAG LIGHT COME ON IN THE PASSAGE SET WHEN KNOW ONE IN THE SET.THE STEERING MADE FUNNY POPPING NOISE. AN ALL THE DOOR HANDLE BROKE WHERE YOU COULD NOT GET OUT OF THE AUTO. AND THE CAR SHOW ON CAR FAX THAT IT IS A BUY BACK AUTO. BUT GM SAY IT NOT. AND ONE OF THE HANDLE IS BREAKING ON THE DRIVER SIDE. AND I CAN NOT SALE IT BECA…
Read full complaint
AIR BAG LIGHT COME ON IN THE PASSAGE SET WHEN KNOW ONE IN THE SET.THE STEERING MADE FUNNY POPPING NOISE. AN ALL THE DOOR HANDLE BROKE WHERE YOU COULD NOT GET OUT OF THE AUTO. AND THE CAR SHOW ON CAR FAX THAT IT IS A BUY BACK AUTO. BUT GM SAY IT NOT. AND ONE OF THE HANDLE IS BREAKING ON THE DRIVER SIDE. AND I CAN NOT SALE IT BECAUSE IT SHOW AS A BUY BACK.TDMV SAY IT WAS AND THEN THEY CHANGE THERE MIND. I FILL LIKE SOMEONE AT GM PAY THEM OFF . I KNOW THIS HAS BEEN A LONG TIME BUT I STILL HAVE THE CAR. AND I AM STILL LOOKING FOR HELP.I WILL KEEP A COPY FOR MY RECORD. *TR
NHTSA ODI #10599040
48,000 miles · Jun 16, 2014
Structure
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE DETACHED AND SHE WAS UNABLE TO EXIT THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10598511
98,000 miles · May 22, 2014
Structure
MY DRIVER AND PASSENGER INSIDE DOOR HANDLES BROKE OFF AND I HAVE TO ROLL DOWN MY WINDOWS TO EXIT AND IF MY CAR IS INVOLVED IN A EMERGENCY I WOULD NOT BE ABLE TO EXIT QUICKLY AND I'VE DONE SOME CHECKING ON LINE AND DISCOVERED ITS A ON GOING PROBLEMS WITH THEM. *TR
NHTSA ODI #10593323
180,000 miles · Apr 29, 2014
Electrical SystemFuel/propulsion SystemService Brakes, Hydraulic
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELE…
Read full complaint
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELEASE FROM IGNITION, BAD ROTORS, LOOSE FRONT END BUSHINGS AND EXCESSIVE FRONT END VIBRATION OVER TYPICAL STREET CRACKS. BROKEN DRIVERS SIDE INTERIOR DOOR HANDLE, CRACKED WINDSHIELD...... *TR UPDATED 10/22/2014 *JS
NHTSA ODI #10585601
37,000 miles · Apr 23, 2014
Structure
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE FROM THE WINDSHIELD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE COMPUTER BOARD HAD BECOME WET. THE TECHNICIAN WAS NOT ABLE TO SPECIFICALLY DETERMINE THE FAILURE THAT ALLOWED THE WATE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WATER WAS LEAKING INTO THE VEHICLE FROM THE WINDSHIELD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE COMPUTER BOARD HAD BECOME WET. THE TECHNICIAN WAS NOT ABLE TO SPECIFICALLY DETERMINE THE FAILURE THAT ALLOWED THE WATER TO ENTER THE VEHICLE HOWEVER, THERE WERE REPAIRS MADE TO THE COMPUTER BOARD. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT WAS 50,000.
NHTSA ODI #10584483
160,000 miles · Apr 22, 2014
Structure
BOTH DRIVER SIDE AND PASSENGER SIDE FRONT INNER DOOR MECHANISM LEVERS HAVE BROKEN MAKING MY VEHICLE ONLY ABLE TO EXIT BY ROLLING MY WINDOW DOWN AND OPENING DOOR WITH OUTSIDE HANDLE, THE REPAIR IS ALMOST 1000.00 FOR THE 2 DOORS WITH LABOR AND I HAD A MECHANIC LOOK AT INNER DOOR AND DETERMINE MECHANISM LEVER IS MADE OUT OF FIBER G…
Read full complaint
BOTH DRIVER SIDE AND PASSENGER SIDE FRONT INNER DOOR MECHANISM LEVERS HAVE BROKEN MAKING MY VEHICLE ONLY ABLE TO EXIT BY ROLLING MY WINDOW DOWN AND OPENING DOOR WITH OUTSIDE HANDLE, THE REPAIR IS ALMOST 1000.00 FOR THE 2 DOORS WITH LABOR AND I HAD A MECHANIC LOOK AT INNER DOOR AND DETERMINE MECHANISM LEVER IS MADE OUT OF FIBER GLASS/PLASTIC MATERIAL WHICH WITH ANY AMOUNT OF EXERTION WILL BREAK IN FREEZING TEMPERATURES. I LIVE IN ILLINOIS. *TR
NHTSA ODI #10584248
65,000 miles · Apr 21, 2014
Structure
THE DOOR HANDLES ON BOTH THE FRONT DRIVER AND FRONT PASSENGER SIDE OF THE CAR HAVE BROKEN. YOU CANNOT OPEN THE CAR DOOR FROM THE INSIDE UNLESS YOU LOWER THE WINDOW. IF THE ELECTRICAL SYSTEMS FAILED SUCH AS IN AN ACCIDENT, THE OCCUPANTS COULD BE TRAPPED INSIDE THE CAR. EVEN WHEN REPLACING THE DOOR HANDLES BY PAYING FOR THE REPAIR…
Read full complaint
THE DOOR HANDLES ON BOTH THE FRONT DRIVER AND FRONT PASSENGER SIDE OF THE CAR HAVE BROKEN. YOU CANNOT OPEN THE CAR DOOR FROM THE INSIDE UNLESS YOU LOWER THE WINDOW. IF THE ELECTRICAL SYSTEMS FAILED SUCH AS IN AN ACCIDENT, THE OCCUPANTS COULD BE TRAPPED INSIDE THE CAR. EVEN WHEN REPLACING THE DOOR HANDLES BY PAYING FOR THE REPAIRS YOURSELF, THE HANDLES JUST BREAK AGAIN BEFORE TOO LONG SINCE THE SAME MATERIALS/PARTS ARE USED. A QUICK GOOGLE SEARCH SHOWS 100'S TO 1000'S OF OTHER OWNERS OF THE 2006 HHR WITH THE SAME PROBLEM. *TR
NHTSA ODI #10584013
33,837 miles · Apr 12, 2014
Electrical SystemSteeringStructure
WE HAVE HAD SEVERAL PROBLEMS WITH OUR HHR SINCE WE BOUGHT IT IN AUGUST OF 2007. THE FIRST PROBLEM OCCURRED JUST AFTER PURCHASING IT, WHEN WE WERE DRIVING IT OUT ON A HIGHWAY FOR A FIRST TIME OUTING WITH IT, WHEN I NOTICED THE FRONT WHEELS SEEMED TO BE FLOATING BACK AND FORTH. I SLOWED DOWN AND IMMEDIATELY TOOK IT HOME. WE …
Read full complaint
WE HAVE HAD SEVERAL PROBLEMS WITH OUR HHR SINCE WE BOUGHT IT IN AUGUST OF 2007. THE FIRST PROBLEM OCCURRED JUST AFTER PURCHASING IT, WHEN WE WERE DRIVING IT OUT ON A HIGHWAY FOR A FIRST TIME OUTING WITH IT, WHEN I NOTICED THE FRONT WHEELS SEEMED TO BE FLOATING BACK AND FORTH. I SLOWED DOWN AND IMMEDIATELY TOOK IT HOME. WE CONTACTED OUR LOCAL DEALER, AND HAD THE CAR BROUGHT IN TO BE CHECKED OUT. WE WERE TOLD THE FRONT BUSHINGS WERE BAD & NEEDED REPLACING. THE DEALER REPLACED THE BUSHINGS. (UNDER WARRANTY) IN SEPTEMBER OF 2007, WE HAD TO REPLACE OUR CARS REMOTE CONTROL, EVEN THOUGH IT WAS ONLY 1 YEARS OLD. OUR DEALER REPLACED IT BUT WE HAD TO PAY $81.82 OUT OF OUR POCKET. OCTOBER 2007, I BROUGHT OUR CAR INTO OUR DEALER BECAUSE IT HAD A ROUGH RIDE AND GROANING SOUNDS. THE DEALER LOOKED AT IT AND SAID THE SOUND WAS COMING FROM THE STEERING COLUMN. THEY REPLACED OUR STEERING COLUMN UNDER WARRANTY. DECEMBER OF 2007 MY WIFE, MOTHER & I WENT TO A CHRISTMAS LIGHT PARADE IN OUR TOWN; WHEN WE GOT HOME I TURNED OFF THE IGNITION & WHEN I ATTEMPTED TO REMOVE THE KEY, IT WOULD NOT COME OUT. THAT MONDAY I CALLED OUR LOCAL DEALER & THEY HAD US BRING IN THE CAR ON 12/3/07. THEY REPORTED THAT THERE WAS NO POWER TO THE INTER LOCK2 AND A FUSE HAD BROWN. THEY FOUND THAT A WIRE HARNESS WAS PINCHED UNDER THE COLUMN COVER & REPAIRED THE HARNESS (UNDER WARRANTY) JANUARY 29,2008 I BROUGHT OUR 2006 HHR INTO OUR DEALER AGAIN COMPLAINING ABOUT SQUEAKING AND POPPING NOISE WITH CLUNKING IN LEFT FRONT. THEY SAID THEY HEARD NOISE FROM STABILIZER LINKS PIVOT JOINT AT LINK TIRES MISS-MATCHED. THEY REPLACED BOTH STABILIZERS LINKS UNDER WARRANTY. CONTINUED ON NEXT REPORT *JS
NHTSA ODI #10579347
80,000 miles · Apr 11, 2014
Structure
IN 2010 THE INSIDE DOOR HANDLE ON THE DRIVERS SIDE OF MY HHR BROKE AND FELL DOWN INSIDE THE DOOR. THE ONLY WAY TO OPEN THE DOOR IS TO OPEN THE WINDOW AND OPEN THE DOOR FROM THE OUTSIDE. I HAD THE IT REPLACED AT COUGHLIN CHEVROLET DEALERSHIP IN CIRCLEVILLE OHIO.. IN NOVEMBER OF 2013, THE DOOR LATCHES BROKE ON THE FRONT DRIVER…
Read full complaint
IN 2010 THE INSIDE DOOR HANDLE ON THE DRIVERS SIDE OF MY HHR BROKE AND FELL DOWN INSIDE THE DOOR. THE ONLY WAY TO OPEN THE DOOR IS TO OPEN THE WINDOW AND OPEN THE DOOR FROM THE OUTSIDE. I HAD THE IT REPLACED AT COUGHLIN CHEVROLET DEALERSHIP IN CIRCLEVILLE OHIO.. IN NOVEMBER OF 2013, THE DOOR LATCHES BROKE ON THE FRONT DRIVERS SIDE AND THE PASSINGERS SIDE. IF WE USE THE CAR WE HAVE TO DRIVE WITH THE WINDOWS DOWN SO THAT WE COULD GET OUT IF . THE DEALERSHIP TOLD ME THAT THIS IS COMMON ON HHR.. IF AN ACCIDENT HAPPEN, WE COULD BE TRAPPED IN THE CAR. THERE SHOULD BE A RECALL ON THIS. *JS
NHTSA ODI #10579166
58,000 miles · Apr 3, 2014
Electrical SystemStructureSuspensionCrash
I WAS DRIVING IN THE RIGHT LANE GOING WESTBOUND APPROACHING A STOP LIGHT WHEN I APPLIED MY BRAKES IT DID NOT SLOW DOWN,I PRESSED THE BRAKE HARD AN CAR KEPT GOING INTO THE REAR OF A TRUCK THAT WAS STOPPING AT THE LIGHT. MY CAR WAS NOT STOPPING. LIKE IT HAD NO CONTROL. THE AIRBAGS DID NOT DEPLOY. IM CONCERNED THAT THE IGNITION TUR…
Read full complaint
I WAS DRIVING IN THE RIGHT LANE GOING WESTBOUND APPROACHING A STOP LIGHT WHEN I APPLIED MY BRAKES IT DID NOT SLOW DOWN,I PRESSED THE BRAKE HARD AN CAR KEPT GOING INTO THE REAR OF A TRUCK THAT WAS STOPPING AT THE LIGHT. MY CAR WAS NOT STOPPING. LIKE IT HAD NO CONTROL. THE AIRBAGS DID NOT DEPLOY. IM CONCERNED THAT THE IGNITION TURNED OFF WHEN I WENT OVER SOME POT HOLES IN THE ROAD. MY CAR IS ONE OF THE VEHICLES ON THE RECALL LIST FOR THE IGNITION SWITCH, I HAD REPLACED IGNITION SWITCH MONTHS AGO DUE TO SAME PROBLEM. WHAT ARE MY OPTIONS TO GET THIS PROBLEM RESOLVED? *TR
NHTSA ODI #10577022
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration