NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
45 reportsClear category filter160,000 miles · Jul 6, 2021
Service Brakes, Hydraulic
The contact owns a 2006 Chevrolet HHR. The contact stated while starting the vehicle, the low unknown fluid warning light was illuminated. The contact checked the fluid levels and the fluid levels were at full. After a couple of days the contact restarted the vehicle and the warning light was off. The contact was concerned that …
Read full complaint
The contact owns a 2006 Chevrolet HHR. The contact stated while starting the vehicle, the low unknown fluid warning light was illuminated. The contact checked the fluid levels and the fluid levels were at full. After a couple of days the contact restarted the vehicle and the warning light was off. The contact was concerned that there might be an issue with brake fluid not flowing through the brake lines as designed which could cause the brakes to not work properly. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 160,000.
NHTSA ODI #11423614
Mileage unknown · Jun 12, 2014
Electrical SystemService Brakes, HydraulicSteering
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND POWER STEERING AND OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED TWO DAYS AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE VEHICLE HAD TO BE FLAT-BEDDED BACK TO THE DEALER, BECAUSE IT WOULDN'T START. IT WAS DETERMINED THE IGNITION SWITCH NEEDE…
Read full complaint
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND POWER STEERING AND OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED TWO DAYS AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE VEHICLE HAD TO BE FLAT-BEDDED BACK TO THE DEALER, BECAUSE IT WOULDN'T START. IT WAS DETERMINED THE IGNITION SWITCH NEEDED TO BE REPLACED. ALSO, THE RIGHT PASSENGER OUTSIDE MIRROR FELL OFF, THE RIGHT PASSENGER WIPER ARM BROKE, THE ROTORS WERE REPLACED TWICE IN TWO YEARS, AND THE REAR SHOCKS WERE REPLACED.*JB
NHTSA ODI #10595101
180,000 miles · Apr 29, 2014
Electrical SystemFuel/propulsion SystemService Brakes, Hydraulic
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELE…
Read full complaint
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELEASE FROM IGNITION, BAD ROTORS, LOOSE FRONT END BUSHINGS AND EXCESSIVE FRONT END VIBRATION OVER TYPICAL STREET CRACKS. BROKEN DRIVERS SIDE INTERIOR DOOR HANDLE, CRACKED WINDSHIELD...... *TR UPDATED 10/22/2014 *JS
NHTSA ODI #10585601
44,000 miles · Mar 15, 2012
Service Brakes, HydraulicCrashInjury
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND LIGHTLY DEPRESSING THE BRAKES, THE BRAKES DID NOT RESPOND. THE VEHICLE WOULD NOT STOP AND THE CONTACT STEERED THE VEHICLE ONTO GRASS AND CONTINUED TO DEPRESS THE BRAKES, BUT TO NO AVAIL. THE VEHICLE DID NOT COME TO A STOP UNTIL CRASHING …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND LIGHTLY DEPRESSING THE BRAKES, THE BRAKES DID NOT RESPOND. THE VEHICLE WOULD NOT STOP AND THE CONTACT STEERED THE VEHICLE ONTO GRASS AND CONTINUED TO DEPRESS THE BRAKES, BUT TO NO AVAIL. THE VEHICLE DID NOT COME TO A STOP UNTIL CRASHING INTO A TREE. THE CONTACT SUSTAINED A FRACTURED ANKLE AND THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE 44,000.
NHTSA ODI #10451774
6,000 miles · Mar 4, 2012
Service Brakes, Hydraulic
I BOUGHT MY HHR IN APRIL 1006. THE CAR HAD APPROXIMATELY 5,000 MILES WHEN I PURCHASED THE VEHICLE. THAT FALL, IN SEPTEMBER 2006, THE BRAKES BEGAN TO SHUDDER EVERY TIME I APPLIED THEM. I TOOK THE VEHICLE TO MY MECHANIC AND HE SAID THE ROTORS NEEDED TO BE GROUND AND TURNED. HE DID THIS AND THE VEHICLE WAS FINE UNTIL THE NEXT SUMME…
Read full complaint
I BOUGHT MY HHR IN APRIL 1006. THE CAR HAD APPROXIMATELY 5,000 MILES WHEN I PURCHASED THE VEHICLE. THAT FALL, IN SEPTEMBER 2006, THE BRAKES BEGAN TO SHUDDER EVERY TIME I APPLIED THEM. I TOOK THE VEHICLE TO MY MECHANIC AND HE SAID THE ROTORS NEEDED TO BE GROUND AND TURNED. HE DID THIS AND THE VEHICLE WAS FINE UNTIL THE NEXT SUMMER (2007) WHEN IT BEGAN TO SHUDDER AGAIN. I TOOK THE VEHICLE IN AND HAD THE BRAKES CHECKED. THIS TIME I HAD TO HAVE BOTH THE PADS AND THE ROTORS REPLACED. IN FALL 2008, HE VEHICLE BEGAN TO SHUDDER AGAIN. I TOOK THE CAR IN AND THE ROTORS ONE AGAIN NEEDED TO BE GROUND AND TURNED AND ONE SHOCK WAS LEAKING. I STOPPED DRIVING THE CAR EVERY DAY AND ALTERNATELY DROVE MY PICKUP AND THE BRAKES LASTED BEYOND THE ONE YEAR MARK. HOWEVER, IN 2010, THE BRAKES BEGAN TO SHUDDER AGAIN AND I HAD TO TAKE THE CAR IN AND HAVE THE ROTORS GROUND AND TURNED AGAIN. IT IS NOW MARCH 2012 AND HE BRAKES ARE BAD AGAIN. I DO NOT DRIVE THE CAR IN THE SUMMER BECAUSE THE WARM WEATHER SEEMS TO MAKE THE PROBLEM WORSE. ALSO, BECAUSE OF THE BRAKE ISSUE, I HAVE HAD TO PUT TWO NEW SETS OF TIRES ON THE VEHICLE DUE TO ABNORMAL WEAR. I WOULD LIKE TO ADD THAT I DO NOT SPEED AND DO NOT BRAKE QUICKLY OR RIDE THE BRAKES. *TR
NHTSA ODI #10450187
46,000 miles · Jan 10, 2012
Air BagsService Brakes, HydraulicStructure
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS EXCITING THE VEHICLE WHEN THE INTERIOR DRIVER'S SIDE DOOR HANDLE DETACHED. THE CONTACT ALSO STATED THAT ON A SEPARATE OCCASION WHILE DRIVING 40 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE FRONT END OF THE VEHICLE WOULD SHAKE ABNORMALLY WHEN THE BRAKES W…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS EXCITING THE VEHICLE WHEN THE INTERIOR DRIVER'S SIDE DOOR HANDLE DETACHED. THE CONTACT ALSO STATED THAT ON A SEPARATE OCCASION WHILE DRIVING 40 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE FRONT END OF THE VEHICLE WOULD SHAKE ABNORMALLY WHEN THE BRAKES WERE DEPRESSED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THAT INSIDE DOOR ASSEMBLY FAILED AND NEEDED TO BE REPLACED ALONG WITH BOTH SIDE FRONT ROTORS. THE MANUFACTURER WAS CONTACTED AND CONFIRMED TO THE CONTACT THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 08V046000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 89,000.
NHTSA ODI #10443273
106,000 miles · Dec 7, 2011
Air BagsService Brakes, HydraulicCrashInjury
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WAS DEPRESSED AND THE PEDAL WENT TO THE FLOORBOARD ABNORMALLY. THE FAILURE CAUSED THE DRIVER TO CRASH INTO ANOTHER VEHICLE FROM THE REAR. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY AND THE DRIVER WAS INJURED. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WAS DEPRESSED AND THE PEDAL WENT TO THE FLOORBOARD ABNORMALLY. THE FAILURE CAUSED THE DRIVER TO CRASH INTO ANOTHER VEHICLE FROM THE REAR. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY AND THE DRIVER WAS INJURED. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND DEEMED AS DESTROYED. THE POLICE STATED THAT THE AIR BAGS SHOULD HAVE DEPLOYED AND THE INSURANCE COMPANY PLANNED TO INSPECT THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 106,000.
NHTSA ODI #10438863
82,000 miles · Nov 29, 2011
Service Brakes, Hydraulic
BRAKE PEDAL ASSEMBLY: AT THE UPPER BRAKE PEDAL, AT THE CROSS TUBE THERE WAS A DEFECTIVE WELD, ONLY WELDED ON ONE SIDE AND THE WELD DID NOT ADHERE TO CROSS BAR. THE WELD DID NOT PENETRATE METAL, CAUSING THE PEDAL TO SLIDE TO THE LEFT. *KB
NHTSA ODI #10437658
Mileage unknown · Aug 11, 2011
Electrical SystemPower TrainService Brakes, Hydraulic
I AM SCARED, FOR MY FAMILY'S SAFETY FEAR THAT THIS VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE...WHEN A VEHICLE STALLS YOU LOOSE ALL POWER...THAT IS POWER STEERING, BRAKES.....THE ABILITY TO MAINTAIN CONTROL OF YOUR VEHICLE I AM ATTACHING A LINK THAT GM SHOULD REVIEW.....DANGER TH…
Read full complaint
I AM SCARED, FOR MY FAMILY'S SAFETY FEAR THAT THIS VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE...WHEN A VEHICLE STALLS YOU LOOSE ALL POWER...THAT IS POWER STEERING, BRAKES.....THE ABILITY TO MAINTAIN CONTROL OF YOUR VEHICLE I AM ATTACHING A LINK THAT GM SHOULD REVIEW.....DANGER THIS VEHICLE IS AN ACCIDENT WAITING TO HAPPEN !!!!!!!!!!!!! COPY THIS LINK TO YOUR WEB BROWSER HTTP-//ABCLOCAL.GO.COM/WTVD/STORY?SECTION=NEWS/ABC11_INVESTIGATES&ID=6811236 IF YOU WOULD PREFER I CAN SEND A TYPED TRANSCRIPT (WORD FOR WORD) OF THIS NEWS BROADCAST? I WILL NOT ALLOW MY WIFE AND KIDS LIFE TO BE PUT IN DANGER, BY LETTING THEM RIDE IN THIS VEHICLE THIS VEHICLE IS UNSAFE AND SHOULD BE RECALLED THE LINK I AM ATTACHING SHOWS A NEWS BROADCAST IN RALEIGH NC. ON CHANNEL 11 NEWS !!!!! INVOLVING NUMBER 12 ISSUE ON MY LONG LIST BELOW WITH THE CHEVY HHR STALLING WHILE DRIVING..... I PURCHASED A 2006 CHEVY HHR LT, IN 2007. SINCE I HAVE PURCHASED THIS VEHICLE THE FOLLOWING ISSUES HAVE OCCURRED. MILEAGE ON CAR 33,346 1) THE KEY LOCKED UP IN IGNITION..9/06/07 2) SHIFTER FROZE UP AND WOULD NOT COME OUT OF PARK. . 9/06/07 3) HEADLINER TRIM ? ENERGY ABSORPTION CAPABILITY 4) FRONT END AND WHOLE CAR STARTED TO SHAKE WHEN APPLYING BRAKE..9/06/07 DEALER TURNED ROTORS( BUT DID NOT FIX ISSUE) 5) REPLACED DRIVER SIDE RUNNING BOARD..9/06/07. 6) GOT IN VEHICLE ONE MORNING TRIED TO TAKE KIDS TO SCHOOL, VEHICLE WOULD NOT GO OVER 15 MPH, HAD TOWED BACK TO LAWSON CHEVROLET. WORKING ON GETTING DATE/MILEAGE..THIS ISSUE OCCURRED TWICE BEFORE. *TR
NHTSA ODI #10418526
79,000 miles · Apr 6, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC BECAUSE OF A VIBRATION AND SHAKING THAT OCCURRED WHENEVER THE BRAKES WERE APPLIED. THE MECHANIC TURNED THE ROTORS AND REPLACED THE BRAKE PADS. THE FAILURE RECURRED WITHIN SIX MONTHS IN ADDITION TO AN ABNORMAL GRINDING NOI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC BECAUSE OF A VIBRATION AND SHAKING THAT OCCURRED WHENEVER THE BRAKES WERE APPLIED. THE MECHANIC TURNED THE ROTORS AND REPLACED THE BRAKE PADS. THE FAILURE RECURRED WITHIN SIX MONTHS IN ADDITION TO AN ABNORMAL GRINDING NOISE EXHIBITED BY THE BRAKES. THE VEHICLE WAS NOT INSPECTED OF FURTHER REPAIRED. THE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 85,000. UPDATED 06/17/11*LJ UPDATED 06/21/11
NHTSA ODI #10394388
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration