NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
222 reportsClear category filter175,000 miles · Feb 25, 2016
Electrical SystemLatches/locks/linkagesStructure
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOOR HANDLES FRACTURED. THE FAILURE HAPPENED WITHOUT WARNING. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE BATTERY ALSO FAILED AND PREVENTED THE DRIVER AND PASSENGER SIDE WINDOWS FROM BEING USED. THE VEHICLE WAS DIAGNOSED A…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOOR HANDLES FRACTURED. THE FAILURE HAPPENED WITHOUT WARNING. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE BATTERY ALSO FAILED AND PREVENTED THE DRIVER AND PASSENGER SIDE WINDOWS FROM BEING USED. THE VEHICLE WAS DIAGNOSED AND THE DOOR HANDLES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.
NHTSA ODI #10838112
24,400 miles · Feb 23, 2016
Electrical SystemFire
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FUSE BOX CAUGHT FIRE AND CAUSED THE BATTERY TO DRAIN COMPLETELY. BYSTANDERS HELPED TO EXTINGUISH THE FIRE. ON ANOTHER OCCASION, THE VEHICLE LOST ALL POWER AND FUNCTIONALITY AND THE IGNITION KEY REMAINED STUCK IN THE IGNITION…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FUSE BOX CAUGHT FIRE AND CAUSED THE BATTERY TO DRAIN COMPLETELY. BYSTANDERS HELPED TO EXTINGUISH THE FIRE. ON ANOTHER OCCASION, THE VEHICLE LOST ALL POWER AND FUNCTIONALITY AND THE IGNITION KEY REMAINED STUCK IN THE IGNITION. THE VEHICLE WAS TOWED TO A DEALER AND REPAIRED, BUT THE FAILURE RECURRED NUMEROUS TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 24,400.
NHTSA ODI #10837830
125,000 miles · Feb 10, 2016
Electrical System
MY CAR WAS INVOLVED IN THE IGNITION RECALL...TOOK IT IN HAD IT ALL FIXED. NOW THAT SAME SWITCH HAS GONE FAULTY AGAIN. THE CAR WILL NOT TURN OVER. ACTS JUST LIKE THE STARTER IS GOING OUT, IT SLOW TO START AND GETS WORSE AND WORSE TILL IT WILL NO LONGER START. I HAVE HAD THE BATTERY REPLACED AND STARTER(DUE TO THAT SEEMED TO BE T…
Read full complaint
MY CAR WAS INVOLVED IN THE IGNITION RECALL...TOOK IT IN HAD IT ALL FIXED. NOW THAT SAME SWITCH HAS GONE FAULTY AGAIN. THE CAR WILL NOT TURN OVER. ACTS JUST LIKE THE STARTER IS GOING OUT, IT SLOW TO START AND GETS WORSE AND WORSE TILL IT WILL NO LONGER START. I HAVE HAD THE BATTERY REPLACED AND STARTER(DUE TO THAT SEEMED TO BE THE ISSUE. AFTER DIGGING DEEPER INTO THE DIAGNOSTIC CODE I HAVE DISCOVERED THAT SWITCH KEEPS COMING UP AS AN ISSUE.
NHTSA ODI #10825425
88,000 miles · Jan 23, 2016
Electrical SystemService BrakesSteering
AFTER ABIDING BY THE RECALL TO CHANGE THE IGNITION SWITCH, THE CAR STARTS FREAKING OUT RANDOMLY. THE DASH LIGHTS START GOING ON AND OFF. LOOSE POWER STEERING, POWER BRAKES AND THE CAR JUST STOPS. YOU CAN BE GOING 70 MILES AN HOUR DOWN THE HIGHWAY AND THE CAR JUST GIVES OUT. THE DEALERSHIP REFUSES TO FIX IT UNLESS I AM WILLIN…
Read full complaint
AFTER ABIDING BY THE RECALL TO CHANGE THE IGNITION SWITCH, THE CAR STARTS FREAKING OUT RANDOMLY. THE DASH LIGHTS START GOING ON AND OFF. LOOSE POWER STEERING, POWER BRAKES AND THE CAR JUST STOPS. YOU CAN BE GOING 70 MILES AN HOUR DOWN THE HIGHWAY AND THE CAR JUST GIVES OUT. THE DEALERSHIP REFUSES TO FIX IT UNLESS I AM WILLING TO PAY ALL THE FEES. I HAD A SECOND DEALERSHIP REPLACE SOME FUSES BUT AFTER 2 DAYS IT STARTED DOING IT AGAIN. AFTER THE FIRST EPISODES, I CALLED AND OPENED A TICKET WITH CHEVROLET, BUT BECAUSE THE DEALERSHIP I USED DIDN'T WANT TO MESS WITH THE CAR ANY MORE THEY WERE NOT VERY HELPFUL. NOW I AM DRIVING A DEATH TRAP BECAUSE I CAN'T AFFORD A NEW CAR AND I WON'T LET MY CHILDREN DRIVE OR BE IN THE CAR.
NHTSA ODI #10821885
160,000 miles · Jan 22, 2016
Electrical System
TURN IGNITION SWITCH OFF WHILE CAR OUT OF GEAR CAUSING IT TO ROLL FREELY.
NHTSA ODI #10821785
101,271 miles · Jan 17, 2016
Electrical System
THERE WAS A RECALL FOR THE IGNITION ON THE HHR, I HAD THE IGNITION CHANGED BUT ON THE WAY HOME THE LOCKS UNLOCKED AND LOCKED SEVERAL TIMES, THEN THE CRUSE KICKED OFF, THE RADIO STOPPED WORKING, THE LIGHTS ON THE INSTRUMENT CLUSTER WENT OFF AND ON, AND THE MOTOR STOPPED. I HAVE CONTACTED GM SEVERAL TIMES BUT THEY SAY THE IGNITI…
Read full complaint
THERE WAS A RECALL FOR THE IGNITION ON THE HHR, I HAD THE IGNITION CHANGED BUT ON THE WAY HOME THE LOCKS UNLOCKED AND LOCKED SEVERAL TIMES, THEN THE CRUSE KICKED OFF, THE RADIO STOPPED WORKING, THE LIGHTS ON THE INSTRUMENT CLUSTER WENT OFF AND ON, AND THE MOTOR STOPPED. I HAVE CONTACTED GM SEVERAL TIMES BUT THEY SAY THE IGNITION CHANGE HAD NOTHING TO DO WITH IT. THIS HAS HAPPENED SEVERAL TIMES SINCE AND ALSO HAD TO REMOVE THE FUSE FOR THE RADIO, BECAUSE IT WOULD RUN THE BATTERY DOWN. THIS HAS HAPPENED SEVERAL TIMES WHEN WE HAVE DRIVEN IT OVER THE LAST COUPLE OF YEARS. I FORMER MECHANIC THAT WORKED FOR A GM DEALER SAID THAT THERE IS A ELECTRICAL UNIT THAT THE IGNITION CONTROLLED AND THAT WITH THE PROBLEM WITH THE IGNITION CAUSED THE PROBLEM WITH THE ELECTRICAL UNIT. WE DO NOT DRIVE THE VEHICLE MUCH BECAUSE IT DOESN'T FEEL SAFE DRIVING IT, NOR WOULD WE SELL IT, BECAUSE OF THE PROBLEMS.
NHTSA ODI #10820744
135,000 miles · Dec 27, 2015
Electrical SystemVisibility/wiper
I WAS DRIVING TO MY FAMILY'S HOME ON CHRISTMAS, WHEN MY CAR SUDDENLY BEGAN TO SMELL LIKE BURNT RUBBER INSIDE OF THE CAR. IT WAS RAINING ON THAT DAY. SUDDENLY THE CARS AC, OR H VAC DID NOT WORK ANYMORE. UPON GOOGLING THINGS OF WHAT IT COULD BE, I FOUND OUT THAT THE RESISTOR AND BLOWER MOTOR HAD BEEN BURNT DO TO BE ALLOWING …
Read full complaint
I WAS DRIVING TO MY FAMILY'S HOME ON CHRISTMAS, WHEN MY CAR SUDDENLY BEGAN TO SMELL LIKE BURNT RUBBER INSIDE OF THE CAR. IT WAS RAINING ON THAT DAY. SUDDENLY THE CARS AC, OR H VAC DID NOT WORK ANYMORE. UPON GOOGLING THINGS OF WHAT IT COULD BE, I FOUND OUT THAT THE RESISTOR AND BLOWER MOTOR HAD BEEN BURNT DO TO BE ALLOWING WATER TO ENTER THE BLOWER MOTOR PANEL FROM THE OUTSIDE OF THE CAR. UPON LOOKING AT MY BLOWER MOTOR AND RESISTOR I FOUND EVIDENT BURN MARKS ON THEM. GM SHOULD INVESTIGATE HOW RAINWATER CAN ENTER THE CARS BLOWER MOTOR CAUSING A BURNING SMELL IN A INHALATION OF FUMES OF BURNING PLASTIC. NOT TO MENTION MY ABILITY NOT TO SEE OUT OF THE WINDOW DUE TO THE DEFROST NOT WORKING. THIS IS A SAFETY CONCERN!!
NHTSA ODI #10816331
148,000 miles · Dec 17, 2015
Electrical SystemEngine
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE STALLED AFTER THE ENGINE POWER GREATLY REDUCED AND ENGINE DISABLED WARNING INDICATORS ILLUMINATED. THE VEHICLE DID RESTART; HOWEVER…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE STALLED AFTER THE ENGINE POWER GREATLY REDUCED AND ENGINE DISABLED WARNING INDICATORS ILLUMINATED. THE VEHICLE DID RESTART; HOWEVER, THE FAILURE RECURRED EVERY 20 MINUTES ON SEVERAL OCCASIONS. THE VEHICLE WOULD RESTART AFTER APPROXIMATELY 10 MINUTES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE RECALL REPAIR WAS GUARANTEED FOR ONE YEAR. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
NHTSA ODI #10810979
Mileage unknown · Sep 23, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE ENGINE WAS TURNED OFF AND A CHIME SOUNDED. THE CONTACT THEN TURNED ON AND POWERED OFF THE VEHICLE AGAIN WHEN THE CHIME SUDDENLY DEACTIVATED. THE FAILURE RECURRED WHENEVER THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THAT THE IG…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE ENGINE WAS TURNED OFF AND A CHIME SOUNDED. THE CONTACT THEN TURNED ON AND POWERED OFF THE VEHICLE AGAIN WHEN THE CHIME SUDDENLY DEACTIVATED. THE FAILURE RECURRED WHENEVER THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. IN 2014, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10775307
75,000 miles · Sep 2, 2015
Electrical SystemSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE WAS REQUIRED TO MANEUVER THE VEHICLE. THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE WAS REQUIRED TO MANEUVER THE VEHICLE. THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. MA 10/26/2015 *CN
NHTSA ODI #10761100
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration