NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
222 reportsClear category filter126,000 miles · Apr 16, 2014
Electrical SystemUnknown Or Other
I STARTED MY CAR AND PUT IT IN GEAR. THE AUTOMATIC DOOR LOCKS LOCKED ALL DOORS. AS I WAS DRIVING THE PASSENGER FRONT DOOR UN LACHTED AND CAME OPEN. ALL THE OTHER DOORS WERE STILL CLOSED AND LOCKED. I STOPPED MY CAR PUT IT IN PARK AND THE PASSENGER FRONT DOOR LOCK WAS IN THE LOCK POSTION STILL AND WAS UNABLE TO CLOSE THE DOO…
Read full complaint
I STARTED MY CAR AND PUT IT IN GEAR. THE AUTOMATIC DOOR LOCKS LOCKED ALL DOORS. AS I WAS DRIVING THE PASSENGER FRONT DOOR UN LACHTED AND CAME OPEN. ALL THE OTHER DOORS WERE STILL CLOSED AND LOCKED. I STOPPED MY CAR PUT IT IN PARK AND THE PASSENGER FRONT DOOR LOCK WAS IN THE LOCK POSTION STILL AND WAS UNABLE TO CLOSE THE DOOR. I CHECKED THE DOOR LATCH AND IT WAS IN THE OPEN POSTION. FINALLY AFTER LOCKING AND UNLOCKING THE DOORS WITH THE DOOR LOCK THE DOOR. CLOSED. THOUGHT WE WERE SAFE TO GO THEN PUT MY CAR IN DRIVE AGAIN AND THE DOOR CAME OPEN AGAIN. WORKED WITH THE DOOR AGAIN AND NOW IT WILL NOT OPEN. GOOD THING WE WERE NOT ON THE HIGHWAY WHEN IT HAPPENED. NOW ANOTHER SAFTEY ISSUE MY CAR WILL NOT GO ALL THE WAY INTO PARK UNLESS THE NOSE OF THE CAR IS AT A DOWNWARD ANGLE AND CANNOT GET THE KEY OUT OF THE IGNITION. WORSE GM CAR I HAVE EVER OWNED. *TT
NHTSA ODI #10583226
Mileage unknown · Apr 16, 2014
Air BagsElectrical SystemPower Train
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED THE STEERING WHEEL AND FRONT END WERE SHAKING, AND THERE WAS A NOISE COMING FROM THE VEHICLE. THE TECHNICIAN FOUND A WORN OUT BEARING, THE STEERING SHAFT HAD AN INTERNAL FAILURE AND THE SWAY BAR LINKS WERE WORN. THE STEE…
Read full complaint
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED THE STEERING WHEEL AND FRONT END WERE SHAKING, AND THERE WAS A NOISE COMING FROM THE VEHICLE. THE TECHNICIAN FOUND A WORN OUT BEARING, THE STEERING SHAFT HAD AN INTERNAL FAILURE AND THE SWAY BAR LINKS WERE WORN. THE STEERING COLUMN, INTERMEDIATE SHAFT AND SWAY BAR LINKS WERE REPLACED. ALSO, IT WAS DIFFICULT TO SHIFT OUT OF PARK AT TIMES. IT WAS DETERMINED A LIQUID HAD BEEN SPILLED IN THE SHIFTER. ALSO, THE CONSUMER WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. *JB
NHTSA ODI #10582760
10,000 miles · Apr 15, 2014
Electrical SystemLatches/locks/linkages
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND FRONT PASSENGER SIDE INTERIOR DOOR HANDLES WERE FRACTURED. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE USING THE INTERIOR DOOR HANDLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE DOOR HANDLES HAD BROKEN OFF DUE TO THE WEAKENED …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND FRONT PASSENGER SIDE INTERIOR DOOR HANDLES WERE FRACTURED. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE USING THE INTERIOR DOOR HANDLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE DOOR HANDLES HAD BROKEN OFF DUE TO THE WEAKENED PLASTIC MATERIALS USED TO MANUFACTURE THEM. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 100,000. UPDATED 07/08/14 MA THE CONSUMER ALSO STATED THE VEHICLE STALLED.
NHTSA ODI #10582854
Mileage unknown · Apr 14, 2014
Air BagsElectrical SystemSteeringCrash
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO AIR BAG MALFUNCTION. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE CONSUMER WAS INVOLVED IN AN ACCIDENT IN 2010, AND THE AIR BAG DID NOT DEPLOY. ALSO, THE VEHICLE STALLED AND WAS RECALLED FOR IGNITION AND STEERING PROBLEMS. *JB UPDATED 04/15/14
NHTSA ODI #10578733
33,837 miles · Apr 12, 2014
Electrical SystemSteeringStructure
WE HAVE HAD SEVERAL PROBLEMS WITH OUR HHR SINCE WE BOUGHT IT IN AUGUST OF 2007. THE FIRST PROBLEM OCCURRED JUST AFTER PURCHASING IT, WHEN WE WERE DRIVING IT OUT ON A HIGHWAY FOR A FIRST TIME OUTING WITH IT, WHEN I NOTICED THE FRONT WHEELS SEEMED TO BE FLOATING BACK AND FORTH. I SLOWED DOWN AND IMMEDIATELY TOOK IT HOME. WE …
Read full complaint
WE HAVE HAD SEVERAL PROBLEMS WITH OUR HHR SINCE WE BOUGHT IT IN AUGUST OF 2007. THE FIRST PROBLEM OCCURRED JUST AFTER PURCHASING IT, WHEN WE WERE DRIVING IT OUT ON A HIGHWAY FOR A FIRST TIME OUTING WITH IT, WHEN I NOTICED THE FRONT WHEELS SEEMED TO BE FLOATING BACK AND FORTH. I SLOWED DOWN AND IMMEDIATELY TOOK IT HOME. WE CONTACTED OUR LOCAL DEALER, AND HAD THE CAR BROUGHT IN TO BE CHECKED OUT. WE WERE TOLD THE FRONT BUSHINGS WERE BAD & NEEDED REPLACING. THE DEALER REPLACED THE BUSHINGS. (UNDER WARRANTY) IN SEPTEMBER OF 2007, WE HAD TO REPLACE OUR CARS REMOTE CONTROL, EVEN THOUGH IT WAS ONLY 1 YEARS OLD. OUR DEALER REPLACED IT BUT WE HAD TO PAY $81.82 OUT OF OUR POCKET. OCTOBER 2007, I BROUGHT OUR CAR INTO OUR DEALER BECAUSE IT HAD A ROUGH RIDE AND GROANING SOUNDS. THE DEALER LOOKED AT IT AND SAID THE SOUND WAS COMING FROM THE STEERING COLUMN. THEY REPLACED OUR STEERING COLUMN UNDER WARRANTY. DECEMBER OF 2007 MY WIFE, MOTHER & I WENT TO A CHRISTMAS LIGHT PARADE IN OUR TOWN; WHEN WE GOT HOME I TURNED OFF THE IGNITION & WHEN I ATTEMPTED TO REMOVE THE KEY, IT WOULD NOT COME OUT. THAT MONDAY I CALLED OUR LOCAL DEALER & THEY HAD US BRING IN THE CAR ON 12/3/07. THEY REPORTED THAT THERE WAS NO POWER TO THE INTER LOCK2 AND A FUSE HAD BROWN. THEY FOUND THAT A WIRE HARNESS WAS PINCHED UNDER THE COLUMN COVER & REPAIRED THE HARNESS (UNDER WARRANTY) JANUARY 29,2008 I BROUGHT OUR 2006 HHR INTO OUR DEALER AGAIN COMPLAINING ABOUT SQUEAKING AND POPPING NOISE WITH CLUNKING IN LEFT FRONT. THEY SAID THEY HEARD NOISE FROM STABILIZER LINKS PIVOT JOINT AT LINK TIRES MISS-MATCHED. THEY REPLACED BOTH STABILIZERS LINKS UNDER WARRANTY. CONTINUED ON NEXT REPORT *JS
NHTSA ODI #10579347
118,000 miles · Apr 4, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED MOMENTS LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED MOMENTS LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
NHTSA ODI #10577391
58,000 miles · Apr 3, 2014
Electrical SystemStructureSuspensionCrash
I WAS DRIVING IN THE RIGHT LANE GOING WESTBOUND APPROACHING A STOP LIGHT WHEN I APPLIED MY BRAKES IT DID NOT SLOW DOWN,I PRESSED THE BRAKE HARD AN CAR KEPT GOING INTO THE REAR OF A TRUCK THAT WAS STOPPING AT THE LIGHT. MY CAR WAS NOT STOPPING. LIKE IT HAD NO CONTROL. THE AIRBAGS DID NOT DEPLOY. IM CONCERNED THAT THE IGNITION TUR…
Read full complaint
I WAS DRIVING IN THE RIGHT LANE GOING WESTBOUND APPROACHING A STOP LIGHT WHEN I APPLIED MY BRAKES IT DID NOT SLOW DOWN,I PRESSED THE BRAKE HARD AN CAR KEPT GOING INTO THE REAR OF A TRUCK THAT WAS STOPPING AT THE LIGHT. MY CAR WAS NOT STOPPING. LIKE IT HAD NO CONTROL. THE AIRBAGS DID NOT DEPLOY. IM CONCERNED THAT THE IGNITION TURNED OFF WHEN I WENT OVER SOME POT HOLES IN THE ROAD. MY CAR IS ONE OF THE VEHICLES ON THE RECALL LIST FOR THE IGNITION SWITCH, I HAD REPLACED IGNITION SWITCH MONTHS AGO DUE TO SAME PROBLEM. WHAT ARE MY OPTIONS TO GET THIS PROBLEM RESOLVED? *TR
NHTSA ODI #10577022
Mileage unknown · Apr 3, 2014
Electrical System
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE . *SMD THE CONSUMER STATED THE ENGINE SHUT OFF, AT LEAST 10 TIMES WHILE DRIVING ON THE EXPRESSWAY. THE DEALER WAS UNABLE TO FIND A PROBLEM. *JB
NHTSA ODI #10575608
Mileage unknown · Apr 1, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR . THE CONTACT RECEIVED A RECALL NOTICE OF NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM); HOWEVER, THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THERE ARE NO FAILURES AT THIS TIME. ..UPDATED 05-09-14 *BF UPDATED 05/13/14
NHTSA ODI #10576173
90,100 miles · Mar 31, 2014
Air BagsElectrical SystemCrashInjury
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING 35 MPH AND MAKING A LEFT TURN THE ENGINE STALLED WITHOUT WARNING CAUSING THE CONTACT TO LOSE CONTROL AND CRASHED INTO A POLE. THE CONTACT SUFFERED INJURIES TO THE FACE, KNEE, WRIST, NECK, AND BACK. THE VEHICLE WAS TOWED FOR FURTHER INSPECTION. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING 35 MPH AND MAKING A LEFT TURN THE ENGINE STALLED WITHOUT WARNING CAUSING THE CONTACT TO LOSE CONTROL AND CRASHED INTO A POLE. THE CONTACT SUFFERED INJURIES TO THE FACE, KNEE, WRIST, NECK, AND BACK. THE VEHICLE WAS TOWED FOR FURTHER INSPECTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT NHTSA CAMPAIGN RECALL NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) WAS RECEIVED AFTER THE CRASH. THE FAILURE AND CURRENT MILEAGE WAS 90,100. UPDATED 05/19/14*LJ
NHTSA ODI #10575806
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration