IllustrationTL*THE CONTACT OWNS A 1996 CHEVROLET G10. THE INTAKE MANIFOLD BEGAN LEAKING, BECAME WORSE OVER TIME. AS OF MAY 23, 2008, THE MECHANIC REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 98,000 AND CURRENT MILEAGE WAS UNAVAILABLE.
1996 Chevrolet G10
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all G10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
8 reportsCONSUMER STATES THAT TRANSMISSION IS SLIPPING. DELAER NOTIFIED.*AK
THE DRIVER'S SIDE SEAT BROKE OFF THE TRACKS AND ANCHOR, CAUSING THE SEAT TO ROCK BACKWARDS, IT WAS REPLACED ONCE, AND THIS INCIDENT HAS OCCURRED AGAIN. *AK
WE HAVE REPLACED 3 DIFFERENT REAR AXLES/GEARS. BEFORE REPLACING WE DIDNT HAVE ANY PROBLEM WITH BACKLASH. WE HAVE HAD THE VAN LOOKED AT & THE DEALERSHIP STATES THEY DIDNT NEED TO LOOK AT THE VAN THAT THEY HAD A BULLETIN STATING THIS WAS NORMAL BACKLASH & USUALLY FOUND IN TRUCKS. WE HAVE HAD ONE FIRE WITH THE REAR AXLE BURNING B…
Read full complaint
WE HAVE REPLACED 3 DIFFERENT REAR AXLES/GEARS. BEFORE REPLACING WE DIDNT HAVE ANY PROBLEM WITH BACKLASH. WE HAVE HAD THE VAN LOOKED AT & THE DEALERSHIP STATES THEY DIDNT NEED TO LOOK AT THE VAN THAT THEY HAD A BULLETIN STATING THIS WAS NORMAL BACKLASH & USUALLY FOUND IN TRUCKS. WE HAVE HAD ONE FIRE WITH THE REAR AXLE BURNING BUT NOW WE CAN TELL IF THE REAR AXLE IS BLOWING. WE HAVE SPOKE TO SEVERAL OTHER OWNERS OF THESE VANS & THEY SEEM TO BE HAVING A HOWLING IN THE ENGINE/ PAINT BURNING OFF THE HOUSING UNIT & THEY WERE TOLD THIS WAS NORMAL. THE OTHER OWNER HAS STATED HE HAS REPLACED 2 REAR AXLES. PLEASE CONTACT ME TO WHETHER OR NOT AN INVESTIGATION IS BEING PERFORMED OR HOW THE THREE OF US WHO ARE HAVING THE SAME TYPE OF PROBLEMS (REAR AXLE) BUT GM KEEPS STATING THIS IS NORMAL. SOMEONE COULD HAVE BEEN KILLED IF WE DIDNT HAVE AN EXTINGUISER TO PUT THE FIRE OUT BEFORE THE FIRE DEPT ARRIVED.
THE PANEL ON THE INSIDE OF THE DOOR IS COMING LOOSE, AND CAUSING THE DOOR TO STICK AND JAM SO THAT THE PASSENGERS CAN'T GET OUT. DEALER HAD REPAIRED DOOR PANEL, BUT PROBLEM REOCCURRED FOR THE 3RD TIME. *AK
BRAKE FAIL ON OCCASIONS, BATTERY FAILED.
BRAKE PEDAL GOES TO FLOOR.
STEERING FAILURE, CAR WANDERS ALL OVER ROA.D
Official recalls
296V186000 · Electrical System:wiring:fuses And Circuit Breakers
Sep 26, 1996
WATER INTRUSION INTO THE KICK PANEL AREAS IN FRONT OF BOTH THE DRIVER AND PASSENGER DOORS CAN CAUSE A CORROSION PATH BETWEEN THE BATTERY FEED AND THE ELECTRICAL GROUND.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE AN ELECTRICAL SHORT LEADING TO IGNITION AND COMBUSION OF THE PLASTICS IN THE ELECTRICAL COMPONENTS OF THE VEHICLE RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE 25 AMP CIRCUIT BREAKERS WITH 25 AMP FUSES IN THE FUSE BLOCK; REMOVE A TEMPORARY PAPER FUSE-BLOCK COVER; INSTALL A PLASTIC SHIELD OVER THE FUSE BLOCK; REPLACE AND REORIENT THE POWER DOOR LOCK RELAY (IF EQUIPPED); INSPECT THE REMOTE KEYLESS ENTRY MODULE (IF EQUIPPED) FOR SIGNS OF CORROSION, REPLACE IF CORRODED, AND REORIENT IT; AND APPLY ADDITIONAL BODY SEALER IN KEY AREAS.
96V187000 · Steering:linkages
Sep 26, 1996
THE STEERING LINKAGE ASSEMBY CONTAINS A RELAY ROD TAPERED-STUD ATTACHMENT NUT THAT WAS NOT TORQUED TO PROPER SPECIFICATIONS.
Consequence & remedy
Consequence: THE TAPERED STUD CAN LOOSEN AND THE DRIVER WOULD NOTICE A LAG IN THE RESPONSIVENESS TO STEERING WHEEL INPUTS. EVENTUALLY THE RELAY ROD STUD CAN FRACTURE RESULTING LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL REMOVE THE EXISTING CRIMPED NUT AND INSTALL A NEW NUT TORQUED TO SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.