Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Interior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
3 reports
23,930 miles · Nov 15, 2004
Tires
ON 2 OCCASIONS WITHIN THE LAST 6 MONTHS, I HAVE HAD 2 TIRES ON MY 2000 CHEVROLET EXPRESS TRUCK FAIL DUE TO TREAD SEPARATION.THE TIRE IS THE "GENERAL AMERI 550 AS" WITH THE TIRE DOT STAMP OF "AD1L D7A 309". THE GENERAL AMERI 550 WAS THE TIRE THAT FORD LATER PULLED AS THE RECOMMENDED REPLACEMENT TO THE FIRESTONE TIRES. MY TRUCK WA…
Read full complaint
ON 2 OCCASIONS WITHIN THE LAST 6 MONTHS, I HAVE HAD 2 TIRES ON MY 2000 CHEVROLET EXPRESS TRUCK FAIL DUE TO TREAD SEPARATION.THE TIRE IS THE "GENERAL AMERI 550 AS" WITH THE TIRE DOT STAMP OF "AD1L D7A 309". THE GENERAL AMERI 550 WAS THE TIRE THAT FORD LATER PULLED AS THE RECOMMENDED REPLACEMENT TO THE FIRESTONE TIRES. MY TRUCK WAS PURCHASED IN 2002 WITH <100 MILES. NOW HAS 23930. MANY DEATHS HAVE BEEN CONTRIBUTED TO THIS TIRE MADE IN THE SAME TIME FRAME.*AK
NHTSA ODI #10098896
Mileage unknown · Jun 26, 2002
Interior LightingVisibility
INSIDE COURTESY LIGHTS WOULD NOT COME ON WHEN OPENING DOORS. ALSO, BOTH EXTERIOR POWER MIRRORS DO NOT OPERATE. VEHICLE BEEN TO DEALER ON SIX OCCASIONS, AND THEY WERE UNABLE TO LOCATE THE CAUSE. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8012695
Mileage unknown · Sep 15, 2000
Service Brakes, Hydraulic
WHEN APPLYING BRAKES IN DRY WEATHER VAN PULLS TO LEFT. WHEN BRAKES ARE APPLIED IN RAINY WEATHER, FRONT LEFT BRAKE LOCKS UP, AND ABS STARTS CHATTERING. THIS HAS BEEN AN ONGOING PROBLEM FOR THE LAST 5 MONTHS. VAN WAS TAKEN TO DEALERSHIP. BRAKE PADS/ CALIPERS/ ROTORS AND BRAKE HOSES WERE REPLACED. VAN STILLS PULLS TO LEFT. …
Read full complaint
WHEN APPLYING BRAKES IN DRY WEATHER VAN PULLS TO LEFT. WHEN BRAKES ARE APPLIED IN RAINY WEATHER, FRONT LEFT BRAKE LOCKS UP, AND ABS STARTS CHATTERING. THIS HAS BEEN AN ONGOING PROBLEM FOR THE LAST 5 MONTHS. VAN WAS TAKEN TO DEALERSHIP. BRAKE PADS/ CALIPERS/ ROTORS AND BRAKE HOSES WERE REPLACED. VAN STILLS PULLS TO LEFT. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
2000 Chevrolet G Series Problems, Complaints & Recalls | Skip That Year
Illustration