IllustrationCORRODED AND LEAKING FUEL FILLER NECK. FOOLISH DESIGN INVOLVING DISSIMILAR METALS HELD IN CONTACT AND SURROUNDED WITH A CONDUIT WHICH HOLDS WATER AND ROAD SALT. DESIGN IS DESTINED FOR FAILURE. GM HAS A PARTIAL RECALL FOR THE SNOW BELT. SUCH A FOOLISH DESIGN SHOULD BE FIXED EVERYWHERE AS IT IS JUST A MATTER OF TIME UNTIL FAILURE.
2003 Chevrolet Express 1500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports2 fire reports1 injury reports
Fuel/propulsion System complaints
4 reportsTL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500 VAN. THE CONTACT STATED THAT WHEN FUELING THE VEHICLE, FUEL SPRAYED FROM THE FILLER NECK. THE DEALER DIAGNOSED THAT FUEL FILLER PIPE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN AND THE MECHANIC ADVISED THAT THE RETURN AND DELIVERY FUEL LINES WOULD HAVE TO BE REPLACED DUE TO CORROSION…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN AND THE MECHANIC ADVISED THAT THE RETURN AND DELIVERY FUEL LINES WOULD HAVE TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
ON A FEW OCCASIONS PRIOR TO LOCATING A LEAK, I NOTICED A GASOLINE SMELL. FINALLY WHEN FILLING EARLIER THIS MONTH, I SAW A LOT OF LEAKING COMING OUT OF THE FUEL FILLER TUBE, BETWEEN THE METAL TUBE AND THE PLASTIC COVER SURROUNDING THE TUBE. WHEN I GOT HOME, I CUT OFF THE PLASTIC TUBE ABOUT HALFWAY AND FOUND A STATIC WIRE RUNNIN…
Read full complaint
ON A FEW OCCASIONS PRIOR TO LOCATING A LEAK, I NOTICED A GASOLINE SMELL. FINALLY WHEN FILLING EARLIER THIS MONTH, I SAW A LOT OF LEAKING COMING OUT OF THE FUEL FILLER TUBE, BETWEEN THE METAL TUBE AND THE PLASTIC COVER SURROUNDING THE TUBE. WHEN I GOT HOME, I CUT OFF THE PLASTIC TUBE ABOUT HALFWAY AND FOUND A STATIC WIRE RUNNING THE LENGTH OF THE TUBE. EVERYWHERE, WHERE THIS WIRE TOUCHED TO METAL PIPE, IT WAS CORRODED COMPLETELY THROUGH. THE STATIC WIRE IS OF A DIFFERENT MATERIAL AND WAS NOT CORRODED. PRESENTLY I HAVE WRAPPED THE TUBE WITH A GASOLINE RESISTANT TAPE. BUT, I WILL HAVE TO REPLACE THE TUBE SOON. THE LOCAL DEALERSHIP HAS QUOTED APPROX. $241.00 WITHOUT INSTALLATION. ARE THERE OTHER INSTANCES LIKE THIS AND IS THERE A RECALL I'M NOT AWARE OF. THANK YOU FOR YOUR TIME. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE11040 · Fuel Filler Pipe Corrosion/leakage
Opened Dec 14, 2011 · Closed Aug 16, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.
Fuel System, Gasoline
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints occurred on Chevrolet Express vans, and 1 of the complaints involved a GMC Savana. All vehicles were equipped with the left side cargo door option. For vehicles so equipped, water and road debris can become trapped in the protective conduit that covers the fuel filler pipe and may subsequently cause the pipe to corrode. If the corrosion creates a significant perforation in the pipe, fuel may leak onto the ground while refueling the vehicle. An illuminated Check Engine light (on some vehicles) or the presence of fuel odor may also act as precursors to fuel leakage. Fuel in the presence of an ignition source could cause a fire to occur. In their response to ODI's information request, GM reported 24 owner reports and 1 field report alleging fuel filler pipe failure/corrosion in the subject vehicle population. Six additional records were also provided that included the replacement of the fuel filler pipe, however not enough information existed to determine a relation to the alleged problem. After further review of the reports, ODI determined that a total of 27 individual GM reports were related to filler pipe corrosion. The complaints received from both ODI and GM primarily occurred in the corrosion states. During the investigation, the scope of the subject vehicle population was expanded to include MY 2004 Express vans, and MY 2003 and 2004 GMC Savana vans (with V6 engines) also equipped with left hand side door options, since the Savana vans also utilize the same, or substantially similar fuel filler pipe configuration. GM subsequently modified the design of the fuel filler pipe on vehicles equipped with side doors to correct the corrosion concern, so these vehicles do not have the defect issue.The affected vehicle population shown above reflects the total number of vehicles registered in the salt-belt states listed in GM's defect information report (DIR). Prior to the safety recall announcement, GM had issued a special coverage adjustment for vehicles in these states, during which a total of 771 repairs were made. Accordingly the vehicle population noted in the DIR reflects that of the remaining vehicle population.The investigation is closed based on GM's announcement of safety recall 12V388. The reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10463398, 10459328, 10456403, 10453725, 10445925, 10443143, 10441615, 10413568, 10413214, 10411911, 10353717, 10259377.