2023 Chevrolet Equinox

The vehicle experienced multiple instances of sudden engine stall and loss of motive power while navigating active downtown intersections and airport terminal lanes in Atlanta, GA. These failures occurred without warning, leaving the vehicle immobilized in high-traffic areas, including a turn in a multi-lane roadway. This defect creates an unreasonable risk of a rear-end collision or being stranded in hazardous traffic conditions. Incident Chronology: Initial Failure: In February 2026, the vehicle stalled in an intersection. After a manual reset of the Check Engine Light (CEL), the vehicle stalled again during a turn. Diagnostic codes P228C (Fuel Pressure Regulator 1 Exceeded Control Limits) and P0089 (Fuel Pressure Regulator 1 Performance) were present. First Attempted Repair: The dealership performed a Technical Service Bulletin (TSB)/recall procedure to calibrate the fuel pump and pressure sensors. Recurrence: Immediately upon retrieval, the vehicle stalled again in a "no parking" zone at a major airport after 45 minutes of operation. The vehicle would not restart or maintain idle, necessitating a second tow. Final Repair: The dealership replaced the fuel pump assembly. Additional Safety Concerns: Approximately 4,000 miles prior to the fuel pump failure, the vehicle experienced multiple "Reduced Engine Power" events and "Service ESC" flashes while traveling at highway speeds (approx. 70 mph) in rainy conditions. The dealership replaced all fuel injectors and spark plugs at that time. Manufacturer Response: Despite the "Engine" designation of the diagnostic codes, GM initially claimed the fuel pump was not covered under the powertrain warranty. While partial assistance was provided for repairs, the recurring nature of these stalls suggests a significant reliability issue with the high-pressure fuel system components and engine.

Recall/Loss of Power I am filing a safety complaint regarding a 2023 Chevy Equinox. The vehicle began losing engine power and will not go over 40 mph. This creates a dangerous driving situation because the vehicle cannot maintain highway speed. The vehicle has a fuel system recall, and the issue appears to be related to the fuel system. The vehicle is currently at a Chevrolet dealership and has been there for almost a month. The vehicle is currently inoperable. This is a safety concern because loss of engine power while driving could cause an accident. I am requesting that this issue be investigated as a safety defect. Sincerely, [XXX]   VIN [XXX] Mileage: 63,000 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Equinox completely stopped functioning in the middle of a major intersection as I was making a left turn during 5pm traffic. I was able to push the car out of the intersection with the help of other drivers (they had to exit their vehicles to assist) and the car restarted - I drove back roads to chevy dealership with the car cutting out unexpectedly twice more while the vehicle was moving and then restarting. No warning light came on. Dealership said my fuel pump "exploded" and pieces were also caught in the fuel injectors and all had to be replaced.

Within the past two months, I have experienced multiple significant mechanical failures that raise serious concerns about the reliability and safety of this vehicle. First, the air conditioning compressor failed at approximately 55,000 miles. This was an unexpected and costly repair for a vehicle that is only two years old and has been properly maintained. Shortly thereafter, the fuel pump failed. I became aware there was a recall related to the fuel system; however, when the dealership ran my VIN, it did not populate under the recall campaign. Despite this, the component still failed. Now, I am experiencing continued stalling and drivability issues, particularly when coming to a stop or when the automatic start/stop system engages at traffic lights. Based on the symptoms, I believe the secondary fuel pump may also be malfunctioning. A vehicle stalling in traffic creates a clear safety hazard. I rely on this vehicle daily, and repeated fuel system failures at this mileage are unacceptable. I am requesting the following: A full diagnostic review of the fuel system under manufacturer oversight Consideration for coverage or reimbursement of recent repairs Investigation into whether my vehicle should have been included in the applicable recall Assurance that this vehicle is safe to operate I have maintained this vehicle appropriately and did not expect major component failures at 55,000 miles. I am extremely concerned about both reliability and safety moving forward. Please advise on next steps and how Chevrolet intends to address this matter.

High capacity fuel pump stopped working while going up a hill. Lost all driving power on freeway and was unable to accelerate any more. Luckily there was a pull off on the freeway or I would have been on a blind turn with cars going 70mph. Had to have pump replaced at a local shop as there was no recall for 2023. 2021 and 2022 have the recall for this specific component.

My car has been shutting down or going into limp mode. It has happened 4 times now and has left me stranded. The second time it happened I was going highway speeds and car lost power causing me to almost get rearended trying to pull my car off road. The 3rd time it happened my car stahled while idling and I could not get it to start back up in the middle of traffic at intersection. I have had injector and pipe replaced, ecm updated and now its going back to dealer as it is currently broke down again.

In September 2025 engine light came on and the message Engine Power is Reduced. The message and light went off. In October 2025 the engine light came on again and another message came on. Something like service ES. I didn’t catch the rest of it. No trouble driving and engine light went out after driving awhile. I took it to the Chevy dealer and they told me I need a new fuel pump. Car has only 58,249 miles on it. I refused repair and told them there were several recalls, but not for my year. Apparently this is a major problem with the Chevy Equinox.