2008 Chevrolet Corvette

THE BATTERY ON MY CORVETTE PHYSICALLY EXPLODED WHEN I TRIED TO START IT AND LITERALLY BLEW PART OF THE BATTERY AWAY AND STARTED A FIRE. IT WOULD HAVE DEFINITELY KILLED ME IF I HAD THE HOOD OPEN AND WAS INSPECTING THE ENGINE. THE INCIDENT WAS REPORTED TO GM AND TODAY I RECEIVED THE ACDELCO GENERIC FORM LETTER DATED 25 SEPTEMBER 2020 MAKING THE ASSUMPTION THAT THE BATTERY WAS BEING CHARGED FOR 8-YEARS, MAKE THE ASSUMPTION IT WAS OVER CHARGED AND INSTRUCT ME TO GO AND BUY AN AIR FRESHENER TO GET THE ACID SMELL OUT OF MY VEHICLE. AS A PROUD AND LOYAL GM VEHICLE OWNER FOR THE PAST 50 YEARS, I FIND YOUR ARROGANT RESPONSE TO OUR COMPLAINT NOTHING LESS THAN DISGUSTING AND IS NOT ASSOCIATED WITH A PROFESSIONAL CORPORATION LIKE GENERAL MOTORS. FURTHERMORE, MAKING FALSE CLAIMS AND OUTRIGHT LYING DOES NOT HELP THE IMAGE OF YOUR COMPANY. ONE GETS THE IMPRESSION THAT YOU ARE READING A GENERAL RESPONSE FROM A Q-CARD WITHOUT ANY FEELING OR ANY INTENTION TO TRY AND ADDRESS THE ISSUE, NEVER MIND RESOLVING THE ISSUE. PROVIDE US WITH THE CONTACT DETAILS OF YOUR DEPARTMENT DIRECTOR TO TAKE IT UP DIRECTLY WITH HIM. DURING OUR CALL TODAY, 18 NOVEMBER 2020 YOUR OFFICE WAS ADAMANT THAT THERE IS A VERY CLEAR WARNING IN THE OWNERS MANUAL THAT STATES THAT A TRICKLE CHARGER SHOULD NOT BE USED AND THAT YOU WILL SEND US A COPY OF THE WARNING. WE REVIEWED THE GM EMAIL DATED 18 NOVEMBER 2020 AND IT DOES NOT HAVE ANY WARNING AGAINST USING A TRICKLE CHARGER. IN FACT, THE EMAIL RECEIVED RECOMMEND USING A TRICKLE CHARGER ' SEE BELOW: ---------------------------------------------------------------------------- EXTENDED STORAGE: REMOVE THE BLACK, NEGATIVE (−) CABLE FROM THE BATTERY OR USE A BATTERY TRICKLE CHARGER. ---------------------------------------------------------------------------

THERE IS A STRONG SMELL OF FUEL COMING FROM THE VEHICLE. PARTICULARLY THE REAR DRIVERS SIDE. WHEN THE CAR IS PARKED IN A GARAGE, THE SMELL OF FUEL IS PRETTY ABUNDANT. IT IS MOST NOTICABLE WHEN THE FUEL TANK IS FULL OR NEAR FULL AND WHILE THE SMELL IS LESS INTENSE WHEN THE TANK IS AT LOWER LEVELS, IT IS STILL PRESENT. THIS SMELL CAN BE NOTICED WHILE DRIVING WITH THE WINDOWS DOWN AS WELL, I THINK THE AIR FROM AROUND THE VEHICLE GETS PULLED INTO THE COCKPIT, DURING PERIODS OF DRIVING AND THE ONLY WAY TO NOT HAVE THE FUEL SMELL IS TO CLOSE THE WINDOWS AND RUN THE CLIMATE SYSTEM. I'D ASSUME THE CLIMATE CONTROL DRAWS AIR IN FROM THE FRONT IF THE VEHICLE WHICH ISN'T WHERE THE SMELL IS EMITTING FROM. I'VE TRIED CLEANING EVERYTHING I KNOW HOW TO AND CAN SAFELY REACH, THE SMELL OF FUEL DOESN'T GO AWAY. I ALSO DO NOT OVERFILL WHEN REFUELING MY VEHICLE. SOME RESEARCH INDICATES SEVERAL OTHER OWNERS OF THE SAME 2008 MODEL YEAR VEHICLES HAVE HAD SIMILAR ISSUES STEMMING FROM BRITTLE PLASTIC ON THE FUEL PUMP CRACKING AND SPRAYING/ VAPORIZING FUEL THROUGH THESE SMALL CRACKS WHILE THE VEHICLE IS RUNNING. APPARENTLY, FUEL CAN POOL ON TOP OF THE GAS TANK AND DRIP DOWN THE SIDE OF THE TANK POTENTIALLY DRIPPING ONTO THE HOT EXHAUST. OBVIOUS SAFETY HAZARD.

MY CAR REEKS OF GAS IF TANK IS FILLED MORE THAN HALF TANK FULL. FUEL SPRAYS FROM HIGH PRESSURE LINE AT THE TOP OF THE LEFT TANK, RUNS DOWN SIDES AND COLLECTS IN SHEETMETAL PAN THAT HOLDS TANK UP. THIS CAR HAS ONLY 20,000 MILES AND WAS OUT OF SERVICE FROM 2015 TO 2019 WITH A MASSIVE ELECTRICAL MELTDOWN OF THE ABS SYSTEM THAT COMPLETELY DESTROYED THE ECBM AND THE HARNESS PLUG. AFTER FIXING THE ABS SYSTEM IN 2019, AND DRIVING THE CAR AGAIN, I NOTICED STRONG FUEL SMELL INSIDE THE CAR. I UNDERSTAND GM HAD A RECALL ON THE FUEL TANK PROBLEM BUT IT ENDED IN 2018, BEFORE I STARTED HAVING THE FUEL ODOR PROBLEM.